2008 Jeep Wrangler Technical Service Bulletins

95 technical service bulletins (TSBs) are on record for the 2008 Jeep Wrangler. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 11023612Sep 18, 2025Brakes. Switch - clutch starter interlock & master cylinder assembly - clutch
• 11022027Aug 15, 2025Other or unknown. Verify Reman part number availability. Order the "R" part number for all orders: Warranty, Mopar, customer pay and service contract. Order "68" part number for New unsold units only.
• 11022026Aug 15, 2025Other or unknown. Verify Reman part number availability. Order the "R" part number for all orders: Warranty, Mopar, customer pay and service contract. Order "68" part number for New unsold units only.
• 11017445Apr 2, 2025Other or unknown. Actuator - a/c and heater
• 11017435Apr 2, 2025Other or unknown. Actuator - a/c and heater
• 11010205Oct 30, 2024Transmission and drivetrain. Plate - Planetary
• 10248509Sep 15, 2023Electrical system. Connector kit Before ordering this connector repair kit 68018957A$, check it in the Mopar Connector Repair Kit Website to confirm part number and applicability. There is an error with the wiring diagrams in Service Library that is causing the incorrect repair kit part number to populate. Please use the Mopar Connector Repair Kit Website until this issue is resolved.
• 10244348Sep 15, 2023Electrical system. Connector kit Before ordering this connector repair kit 68018957A$, check it in the Mopar Connector Repair Kit Website to confirm part number and applicability. There is an error with the wiring diagrams in Service Library that is causing the incorrect repair kit part number to populate. Please use the Mopar Connector Repair Kit Website until this issue is resolved.
• 10229998May 26, 2021Seat belts, Brakes. KEY, BLANK WITH TRANSMITTER Please note that after programming the new key integrated transmitter that Lock, Unlock and Remote Start will all function as expected but the Remote Start Cancel button requires a double (2x) button press versus the original single (1x) button press to cancel the remote start function and turn the vehicle off.
• 10223386May 26, 2021Electrical system. KEY, BLANK WITH TRANSMITTER Please note that after programming the new key integrated transmitter that Lock, Unlock and Remote Start will all function as expected but the Remote Start Cancel button requires a double (2x) button press versus the original single (1x) button press to cancel the remote start function and turn the vehicle off.
• 10223226May 26, 2021Seat belts, Brakes. KEY, BLANK WITH TRANSMITTER Please note that after programming the new key integrated transmitter that Lock, Unlock and Remote Start will all function as expected but the Remote Start Cancel button requires a double (2x) button press versus the original single (1x) button press to cancel the remote start function and turn the vehicle off.
• 10198300May 26, 2021Equipment. KEY, BLANK WITH TRANSMITTER Please note that after programming the new key integrated transmitter that Lock, Unlock and Remote Start will all function as expected but the Remote Start Cancel button requires a double (2x) button press versus the original single (1x) button press to cancel the remote start function and turn the vehicle off.
• 10221097Apr 7, 2021Transmission and drivetrain. Transmission Kit with Torque Converter 1. All Promaster (VF) 3.6L/62TE equipped vehicles. If the transmission bracket to the transmission case fasteners are removed during servicing, the fasteners (Part Number 06511385A$) are one-time usage.
• 10215916Jan 20, 2021Visibility (wipers, defrost, mirrors). Warranty Bulletin D-18-16 Rev. B Mopar Windshield Made With Corning Gorilla Glass (Rev. B)
• 10187095Jan 20, 2021Visibility (wipers, defrost, mirrors). Warranty Bulletin D-18-16 Rev. B Mopar Windshield Made With Corning Gorilla Glass (Rev. B)
• 10221831Aug 19, 2020Transmission and drivetrain, Electrical system. (Revision A) No Start No Crank ? Starter Will Not Engage And There Are No Related Codes Or Concerns
• 10180221Aug 19, 2020Transmission and drivetrain, Electrical system, Engine. (Revision A) No Start No Crank ? Starter Will Not Engage And There Are No Related Codes Or Concerns
• 10223525Jun 1, 2020Electrical system. Malfunction Indicator Lamp (MIL) Illumination. Diagnostic Trouble Codes P0407 ? EGR Sensor B Circuit Low, or P0408 ? EGR Sensor B Circuit High Set
• 10175743Apr 30, 2020Equipment, Body and structure. Disinfectant Solution Recommended for COVID-19
• 10175735Apr 22, 2020Electrical system, Equipment. Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are necessary.
• 10175510Mar 4, 2020Equipment. DIPAP Requirements - Addition of Jeep Wrangler (JL/JK) and Jeep Gladiator (JT) Hard Top and Targa Top Panel Replacements - All Dealers (Rev. A)
• 10220101Nov 20, 2019Body and structure. Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.
• 10220099Nov 20, 2019Body and structure. Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.
• 10220097Nov 20, 2019Body and structure, Equipment. Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.
• 10169249Nov 20, 2019Body and structure, Equipment. Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.
• 10169247Nov 20, 2019Equipment. Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.
• 10169245Nov 20, 2019Body and structure. Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.
• 10168378Oct 2, 2019Body and structure. DOOR, Assembly (Front or Rear) For concern of flag nut not aligned to hole, use a blunt tool and lightly tap on the flag nut to knock it loose from e-coat that has dried it in place.
• 10166537Aug 7, 2019Equipment. RADIO [RES] - New and/or Service Exchange For RES radio concerns. Use the wiTECH 2.0 and inspect the radio part number and serial number under the Radio/ECU Details tab. Please verify that the radio part number and/or serial number is not "FFFF". If either field shows "FFFF", please contact Mike Wielgat at 248-576-6696 or Rohan Negandhi at 248-421-9608 If no response in 15 minutes, proceed with repair.
• 10159313Mar 14, 2019Steering, Equipment. The SKU is a Tie Rod Center Stud. The Customer commnunication requested return of unsold inventory to inpsect for possible incorrect direction threads (right hand rather than left hand). Incorrect direction threads will prevent it from being installed.
• 10138874Jun 1, 2018Transmission and drivetrain. Customer Satisfaction Notification S80 Aftermarket Dana 60 Front Axle The aftermarket front axle steering knuckles have been machined with an incorrect taper during the manufacturing process on about 250 of the above vehicles, with approximately 80 of the axles sold by Mopar aftermarket. This condition can result in premature axle knuckle wear. The aftermarket front axle knuckles must be replaced with new axle…
• 10219885Jun 14, 2017Brakes. Front Brake Caliper Hose Leak (X71 Warranty Extension) This bulletin involves replacing both front brake caliper hoses and wheel speed sensors. Customers may experience a brake fluid leak coming from the front wheel opening area. This issue is due to corrosion at the crimps on the brake caliper hosesFig. 1.If the customer describes the symptom/condition listed above, perform the Repair Procedure.Example Of…
• 10219850Jun 14, 2017Wheels, Brakes. (X71) Front Left and Right Brake Caliper Hoses & Both Wheel Speed Sensors - 2007 - 2010 Jeep Wranglers (JK)
• 10138910Jun 14, 2017Brakes. Front Brake Caliper Hose Leak (X71 Warranty Extension) This bulletin involves replacing both front brake caliper hoses and wheel speed sensors. Customers may experience a brake fluid leak coming from the front wheel opening area. This issue is due to corrosion at the crimps on the brake caliper hosesFig. 1.If the customer describes the symptom/condition listed above, perform the Repair Procedure.Example Of…
• 10138875Jun 14, 2017Wheels, Brakes. (X71) Front Left and Right Brake Caliper Hoses & Both Wheel Speed Sensors - 2007 - 2010 Jeep Wranglers (JK)
• 10219849Jun 1, 2017Transmission and drivetrain. Customer Satisfaction Notification S80 Aftermarket Dana 60 Front Axle The aftermarket front axle steering knuckles have been machined with an incorrect taper during the manufacturing process on about 250 of the above vehicles, with approximately 80 of the axles sold by Mopar aftermarket. This condition can result in premature axle knuckle wear. The aftermarket front axle knuckles must be replaced with new axle…
• 10139978Mar 8, 2017Seat belts. Restraints Remove I-Sheet from packaging. Correct information sheet (I-Sheet) has been added to Star Parts. Print I-Sheet for technician use.
• 10139985Mar 1, 2017Seat belts. Restraints Information Sheet (I-Sheet) has been added to Star Parts. Print I-Sheet for technician use.
• 10121707Jul 19, 2016Equipment, Visibility (wipers, defrost, mirrors), Body and structure. Out Of Tolerance Door And Windshield Frame Gaps Causing Water Leaks This bulletin involves adjusting the windshield frame and A-pillar between the door to close gaps and prevent water leaks. The customer may describe gaps between the windshield frame, door and top of cowl. There may also be a water leak.
• 10218307Apr 30, 2016Electrical system. Flash: UConnect and Voice Recognition Inoperative This bulletin involves replacing the Hands Free Module (HFM). The customer may describe the following conditions: · A complete loss of UConnect operation. · A complete loss of Voice Recognition functionality
• 10140258Apr 30, 2016Equipment, Electrical system. Flash: UConnect and Voice Recognition Inoperative This bulletin involves replacing the Hands Free Module (HFM). The customer may describe the following conditions: · A complete loss of UConnect operation. · A complete loss of Voice Recognition functionality
• 10191460Feb 26, 2016Engine cooling. Valve Body. These may cause over drive cycling.
• 10121927Jan 26, 2016Engine cooling. NAG1 (5A580) Valve Body As per Warranty Bulletin D-13-22, please use R2108213A$ valve body for all Warranty (W), Mopar (M) and Mopar Vehicle Protection (F) claims.~ Assembly also includes Filter (52108325AA) and Gasket (52108332AA).~
• 10217425Oct 22, 2015Visibility (wipers, defrost, mirrors). Cracked Vinyl Soft Top Window This bulletin provides soft top vinyl window precautions during cold weather.
• 10216187Oct 22, 2015Visibility (wipers, defrost, mirrors). Cracked Vinyl Soft Top Window This bulletin provides soft top vinyl window precautions during cold weather.
• 10151768Oct 22, 2015Body and structure. Cracked Vinyl Soft Top Window This bulletin provides soft top vinyl window precautions during cold weather.
• 10144799Mar 11, 2015Body and structure. Part Description: Soft Top Quarter Window or Rear Window Issue Description: Please cycle the zipper 5-10 times when there is a single skipped zipper tooth.
• 10229181Feb 12, 2015Engine cooling. Part Description: 5.7L Long Block Issue Description: This 5.7L Long Block Assembly is compatible with both EGR and Non-EGR applications. An EGR Block-Off Plate (53032739AA) must be ordered when installing this Long Block Assembly in a Non-EGR application. Unless, the EGR Block-Off Plate is being transferred from the old engine.
• 10223602Feb 12, 2015Engine cooling. Part Description: 5.7L Long Block Issue Description: This 5.7L Long Block Assembly is compatible with both EGR and Non-EGR applications. An EGR Block-Off Plate (53032739AA) must be ordered when installing this Long Block Assembly in a Non-EGR application. Unless, the EGR Block-Off Plate is being transferred from the old engine.
• 10223599Feb 11, 2015Engine cooling. Part Description: Valve Body Assembly Issue Description: Valve body design was changed between 2010MY and 2011MY applications. To prevent mix matching valve bodies and solenoid packs the connectors are color coded.~ Valve bodies with a white connector can be used on 2010, 2009, 2008..., model years. Valve bodies with a gray connector can only be used on 2011, 2012, 2013..., model years.~ Solenoid packs with a white…

← All problems reported for the 2008 Jeep Wrangler