2015 Jeep Wrangler Technical Service Bulletins

225 technical service bulletins (TSBs) are on record for the 2015 Jeep Wrangler. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10139994Mar 29, 2017Seats. Heated Seat Elements; Cushion and Back DEALERCONNECT HEATED ELEMENT RESISTANCE INFO OUT IS OF SPEC. Prior to ordering any of the parts (55057300A$, 55057293A$, 55057301A$, 55057294A$) Please contact Micah Straub at cell phone# 248-613-2478 for further instructions. Leave a voice mail and your call will be returned promptly. 5.1 to 7.8 is the correct resistance value although ambient temperature will affect this…
• 10139992Mar 29, 2017Body and structure. Door Hinge Assembly Side door hinge noisy. Only replace the door hinge with the integral check device. Do not replace the simple hinge if it is not damaged it is not the source of the noise. Replacing it unnecessary and is an over-repair.
• 10217579Mar 24, 2017Steering, Lane departure, Wheels, Back-over prevention (rear camera), Exterior…. Clockspring Replacement (X68 Warranty Extension) This bulletin involves diagnosing the clockspring/Steering Angle Sensor (SAS).If the diagnostic tests indicate the clockspring/SAS requires replacement, replace the clockspring, upper and lower steering column shrouds and steering wheel back cover. Some customers may experience the illumination of the airbag warning lamp or traction control indicator lamp.
• 10140047Mar 24, 2017Air bags. Clockspring Replacement (X68 Warranty Extension) This bulletin involves diagnosing the clockspring/Steering Angle Sensor (SAS).If the diagnostic tests indicate the clockspring/SAS requires replacement, replace the clockspring, upper and lower steering column shrouds and steering wheel back cover. Some customers may experience the illumination of the airbag warning lamp or traction control indicator lamp.
• 10217521Mar 15, 2017Fuel system. Oil Pump Assembly If error code P06DD present on any Pentastar V6 application, please inspect oil pump for relief valve failure. See photo attached. If valve is found out of place please call Bob Jackson (248) 944-0466 [email protected], or Joe Lovell (734) 309-6467 [email protected] before proceeding. If unable to reach after 15 minutes record the following information and proceed with oil pump…
• 10139989Mar 15, 2017Engine cooling. Oil Pump Assembly If error code P06DD present on any Pentastar V6 application, please inspect oil pump for relief valve failure. See photo attached. If valve is found out of place please call Bob Jackson (248) 944-0466 [email protected], or Joe Lovell (734) 309-6467 [email protected] before proceeding. If unable to reach after 15 minutes record the following information and proceed with oil pump…
• 10139978Mar 8, 2017Seat belts. Restraints Remove I-Sheet from packaging. Correct information sheet (I-Sheet) has been added to Star Parts. Print I-Sheet for technician use.
• 10139985Mar 1, 2017Seat belts. Restraints Information Sheet (I-Sheet) has been added to Star Parts. Print I-Sheet for technician use.
• 10121845Nov 30, 2016Electrical system. Hands Free Module - Convergence Telematics Module (CTM) Before replacing the Hands Free Module (HFM), please contact Gaurav Saxena at cell (248) 260-0583 or Tim Kraft at cell (248) 766-5826 ~ IMPORTANT - do not reset the HFM, clear codes or perform a battery reset before calling. Engineering is currently root causing this issue and your assistance is greatly appreciated. Seeking vehicles with HFM in a locked state…
• 10121844Nov 30, 2016Electrical system. RHB/RBZ Radio For JK, MK, and RT ONLY: RHB/RBZ radio that supports Bluetooth and Hands- Free For issues with Bluetooth, Hands-Free Calling, and/or Voice Commands, DO NOT replace the radio. Diagnose the Hands-Free Module system (also called the Telematics Module). The Telematics Module (and associated components) is the system responsible for these features. Please reference; 8T - Navigation/Telecommunication…
• 10121890Nov 29, 2016Equipment. Replace Vehicle Emission Certification Information Label This bulletin involves replacing the Vehicle Emission Certification Information (VECI) Label.Owner may be turned away from Inspection and Maintenance (IM) station or fail IM testing because of missing emission components on VECI label. The customer may notice that some info is missing on their VECI labels.is missing.
• 10223853Sep 30, 2016Equipment. Replace Vehicle Emission Certification Information Label This bulletin involves replacing the Vehicle Emission Certification Information (VECI) Label.Owner may be turned away from Inspection and Maintenance (IM) station or fail IM testing because of missing emission components on VECI label. The customer may notice that some info is missing on their VECI labels.is missing.
• 10223855Sep 7, 2016Visibility (wipers, defrost, mirrors). Washer Fluid Level Sensor Prior to replacing this part due to "Low Washer Fluid" tell tale light on the dash and the washer fluid bottle is full, please perform the this inspection. Inspect the sensor for a fluid coating on the sensor pins. Orange colored rain repellant can cause this fluid build-up. Clean the pins, drain the reservoir, and fill with Mopar approved washer fluid. Check to determine if the issue has…
• 10121719Aug 30, 2016Air bags. Non-desiccated Passenger Frontal Airbag This bulletin involves providing to purchasers of affected un-sold vehicles, prior to purchase, the attached "Important Notice" document and retain a signed copy. No customer symptoms or conditions are associated with this RRT. If a customer?s VIN is listed in VIP or your RRT VIN list, RRT applies only to those unsold Vins listed.
• 10121718Aug 30, 2016Air bags. Non-desiccated Passenger Frontal Airbag This bulletin involves providing to purchasers of affected un-sold vehicles, prior to purchase, the attached "Important Notice" document and retain a signed copy. No customer symptoms or conditions are associated with this RRT. If a customer?s VIN is listed in VIP or your RRT VIN list, RRT applies only to those unsold Vins listed.
• 10224871Aug 24, 2016Electrical system. Hands Free Module - CTM ? Peiker Before replacing the Hands Free Module (HFM), please contact Gaurav Saxena at cell (248) 260-0583 or Tim Kraft at cell (248) 766-5826 ~ IMPORTANT - do not reset the HFM, clear codes or perform a battery reset before calling. Engineering is currently root causing this issue and your assistance is greatly appreciated. Seeking vehicles with HFM in a locked state, inoperative, or offline.
• 10130084Aug 24, 2016Electrical system. Hands Free Module - CTM ? Peiker Before replacing the Hands Free Module (HFM), please contact Gaurav Saxena at cell (248) 260-0583 or Tim Kraft at cell (248) 766-5826 ~ IMPORTANT - do not reset the HFM, clear codes or perform a battery reset before calling. Engineering is currently root causing this issue and your assistance is greatly appreciated. Seeking vehicles with HFM in a locked state, inoperative, or offline.
• 10108544Aug 3, 2016Equipment. "Console Lid JK ONLY - If you are replacing the console lid because it does not open properly or because it does not close properly, please also replace the console base and the lock cylinder (04746315) in addition to the console lid. If you have any questions, please call Mike Wicker on cell (248) 821-9350 prior to replacing the component. If you don’t receive a response within 15 minutes, please continue with…
• 10084052Aug 3, 2016Air bags. "Non-desiccated Passenger Frontal Airbag This bulletin involves providing to purchasers of affected un-sold vehicles, prior to purchase, the attached ""Important Notice"" document and retain a signed copy. No customer symptoms or conditions are associated with this RRT. If a customer’s VIN is listed in VIP or your RRT VIN list, RRT applies only to those unsold Vins listed."
• 10121683Jul 20, 2016Engine cooling. 3.2L - 3.6L Cylinder Head Assy Multiple cylinder head replacement. If cylinder head is replaced on a vehicle more than 1 time for any reason, please call any of the following people.~ First: Ron Dallison ? Cell (248) 292-9510 [email protected] ~ Second: Joe Lovell - Cell (734) 309-6467 [email protected]~ If a response is not received within 15 mins, then proceed with the necessary repair.
• 10121707Jul 19, 2016Visibility (wipers, defrost, mirrors), Equipment, Body and structure. Out Of Tolerance Door And Windshield Frame Gaps Causing Water Leaks This bulletin involves adjusting the windshield frame and A-pillar between the door to close gaps and prevent water leaks. The customer may describe gaps between the windshield frame, door and top of cowl. There may also be a water leak.
• 10121671Jul 13, 2016Equipment, Electrical system. RHB/RBZ Radio For JK, MK, and RT ONLY: RHB/RBZ radio that supports Bluetooth and Hands- Free. For issues with Bluetooth, Hands-Free Calling, and/or Voice Commands, DO NOT replace the radio. Diagnose the Hands-Free Module system (also called the Telematics Module). The Telematics Module (and associated components) is the system responsible for these features. Please reference; 8T - Navigation/Telecommunication…
• 10121652Jul 9, 2016Transmission and drivetrain, Electrical system. Flash: Powertrain Diagnostic And System Enhancements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find that one of the following Diagnostic Trouble Codes (DTCs) have been set: · **P0300 - Multiple Cylinder Misfire (3.6L Engine Sales…
• 10121654Jul 6, 2016Equipment, Visibility (wipers, defrost, mirrors). Actuator- A/C Heater Before replacing this actuator call Matt Sasina at cell (248) 464-4982. If no response in 15 minutes, continue with repair.
• 10218269Jun 22, 2016Electrical system. Anti-Lock Brake Module (ABS) 2015 and 2016 JK ONLY; Before replacing the ABS module, please call Breanne Scherbaty at cell (586) 604-4582. If you don't receive response within 15 minutes, please continue with normal repair procedure.
• 10140136Jun 22, 2016Brakes, Electrical system. Anti-Lock Brake Module (ABS) 2015 and 2016 JK ONLY; Before replacing the ABS module, please call Breanne Scherbaty at cell (586) 604-4582. If you don't receive response within 15 minutes, please continue with normal repair procedure.
• 10080242Jun 22, 2016Brakes. "anti-lock brake module (abs) 2015 and 2016 jk only; before replacing the abs module, please call breanne scherbaty at cell (586) 604-4582. If you don't receive response within 15 minutes, please continue with normal repair procedure."
• 10217358Jun 15, 2016Tires. TPM Sensor or Control Module 2015 and 2016 JK vehicles only - Engineering is investigating a Tire Pressure Monitor (TPM) issue for TPM lamp ON.~ Prior to replacing any components (Sensor or TPM Control Module) on MY15 or 16 JK vehicles, please contact Raja Charabuddi on cell (248) 202-7313. If no response within 15 minutes, proceed with repair.
• 10217354Jun 15, 2016Equipment. Console Lid JK ONLY - If you are replacing the console lid because it does not open properly or because it does not close properly, please also replace the console base and the lock cylinder (04746315) in addition to the console lid. If you have any questions, please call Mike Wicker on cell (248) 821-9350 prior to replacing the component. If you don?t receive a response within 15 minutes, please continue with…
• 10140108Jun 15, 2016Tires. TPM Sensor or Control Module 2015 and 2016 JK vehicles only - Engineering is investigating a Tire Pressure Monitor (TPM) issue for TPM lamp ON.~ Prior to replacing any components (Sensor or TPM Control Module) on MY15 or 16 JK vehicles, please contact Raja Charabuddi on cell (248) 202-7313. If no response within 15 minutes, proceed with repair.
• 10140104Jun 15, 2016Equipment. Console Lid JK ONLY - If you are replacing the console lid because it does not open properly or because it does not close properly, please also replace the console base and the lock cylinder (04746315) in addition to the console lid. If you have any questions, please call Mike Wicker on cell (248) 821-9350 prior to replacing the component. If you don?t receive a response within 15 minutes, please continue with…
• 10080207Jun 15, 2016Tires, Electrical system. "tpm sensor or control module 2015 and 2016 jk vehicles only - engineering is investigating a tire pressure monitor (tpm) issue for tpm lamp on.~ prior to replacing any components (sensor or tpm control module) on my15 or 16 jk vehicles, please contact raja charabuddi on cell (248) 202-7313. If no response within 15 minutes, proceed with repair."
• 10080203Jun 15, 2016Equipment, Electrical system. "pentastar oil filter adapter before replacing this part, please call any one of the following people. Engineering is seeking information regarding this part.~ dye must be used to determine where the leak is coming from before replacing. Also please check the recently updated service bulletin number 09-008-15.
• 10080180Jun 15, 2016Equipment. "console lid jk only - if you are replacing the console lid because it does not open properly or because it does not close properly, please also replace the console base and the lock cylinder (04746315) in addition to the console lid. If you have any questions, please call mike wicker on cell (248) 821-9350 prior to replacing the component. If you don’t receive a response within 15 minutes, please continue with…
• 10226277Jun 9, 2016Body and structure. Discolored Door Hinge Nuts This bulletin involves replacing all the lower nuts on the side upper and lower door hinges. The customer may describe discoloring or rust from the lower nut securing the doors to the hinges.
• 10137063Jun 9, 2016Body and structure. Discolored Door Hinge Nuts This bulletin involves replacing all the lower nuts on the side upper and lower door hinges. The customer may describe discoloring or rust from the lower nut securing the doors to the hinges.
• 10219814Jun 1, 2016Transmission and drivetrain. 9-spd Transmission: FOR NAFTA Market Only: If you are ordering this transmission please follow all wiTECH pop ups and Warranty Payment Guidelines. If this vehicle contains 1 of the 30 Diagnostic Codes in the 9 Speed Tutorial located on the Service Home Page then please follow the repair steps and submit a Topology report as well as a Vehicle Scan Report with the Warranty Claim.~
• 10218250Jun 1, 2016Transmission and drivetrain. 9-spd Transmission: FOR NAFTA Market Only: If you are ordering this transmission please follow all wiTECH pop ups and Warranty Payment Guidelines. If this vehicle contains 1 of the 30 Diagnostic Codes in the 9 Speed Tutorial located on the Service Home Page then please follow the repair steps and submit a Topology report as well as a Vehicle Scan Report with the Warranty Claim.~
• 10218248Jun 1, 2016Engine cooling. Pentastar Oil Filter Adapter: Before replacing this part, please call any one of the following people. Engineering is seeking information regarding this part.~ Dye must be used to determine where the leak is coming from before replacing. Also please check the recently updated Service Bulletin Number 09-008-15.
• 10139936Jun 1, 2016Transmission and drivetrain. 9-spd Transmission: FOR NAFTA Market Only: If you are ordering this transmission please follow all wiTECH pop ups and Warranty Payment Guidelines. If this vehicle contains 1 of the 30 Diagnostic Codes in the 9 Speed Tutorial located on the Service Home Page then please follow the repair steps and submit a Topology report as well as a Vehicle Scan Report with the Warranty Claim.~
• 10139934Jun 1, 2016Engine cooling. Pentastar Oil Filter Adapter: Before replacing this part, please call any one of the following people. Engineering is seeking information regarding this part.~ Dye must be used to determine where the leak is coming from before replacing. Also please check the recently updated Service Bulletin Number 09-008-15.
• 10228098May 18, 2016Engine cooling. 3.2L - 3.6L Cylinder Head Assy Multiple cylinder head replacement. If cylinder head is replaced on a vehicle more than 1 time for any reason, please call any of the following people.~ First: Ron Dallison ? Cell (248) 292-9510 [email protected] ~ Second: Joe Lovell - Cell (734) 309-6467 [email protected]~ If a response is not received within 15 mins, then proceed with the necessary repair.~
• 10228142May 11, 2016Equipment, Engine cooling. Pentastar Oil Filter Adapter
• 10218303May 4, 2016Equipment, Electrical system. RES / RHA / REB radio that supports Bluetooth and Hands-Free For issues with Bluetooth, Hands-Free Calling, and/or Voice Commands, DO NOT replace the radio. Diagnose the Hands-Free Module system (also called the Telematics Module). The Telematics Module (and associated components) is the system responsible for these features.
• 10140254May 4, 2016Equipment, Electrical system. RES / RHA / REB radio that supports Bluetooth and Hands-Free For issues with Bluetooth, Hands-Free Calling, and/or Voice Commands, DO NOT replace the radio. Diagnose the Hands-Free Module system (also called the Telematics Module). The Telematics Module (and associated components) is the system responsible for these features.
• 10139956Apr 20, 2016Vehicle speed control. Adaptive Cruise Control Sensor 1) If you are replacing this part due to the cluster displaying Clean Radar Sensor in Front of Vehicle or DTC C1266 ACC Sensor Blinded, please verify that there is no blockage in front of the sensor. Blockage can occur from mud, ice, snow, front end damage, bracket damage, the sensor not attached to the bracket properly or an aftermarket fascia installed. This fault can occur…
• 10218289Apr 7, 2016Transmission and drivetrain, Electrical system. Flash: Powertrain Diagnostic And System Enhancements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find that one of the following Diagnostic Trouble Codes (DTCs) have been set: · **P0335 - Crankshaft Position Sensor Circuit. · P0306…
• 10218122Apr 7, 2016Transmission and drivetrain. Diagnostic And System Improvements.
• 10215156Apr 7, 2016Equipment, Electrical system. Diagnostic And System Improvements.
• 10140181Apr 7, 2016Engine cooling, Electrical system. Flash: Powertrain Diagnostic And System Enhancements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find that one of the following Diagnostic Trouble Codes (DTCs) have been set: · **P0335 - Crankshaft Position Sensor Circuit. · P0306…

← All problems reported for the 2015 Jeep Wrangler