2019 Jeep Wrangler Technical Service Bulletins

837 technical service bulletins (TSBs) are on record for the 2019 Jeep Wrangler. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 11007954Sep 17, 2024Electrical system. Battery Drain Suspected or "Identified" From USB or Media Hub
• 11006814Aug 29, 2024Engine. Pump – water & connector - oil cooler tube
• 11006622Aug 23, 2024Suspension. Click Noise From Front End While Driving And Or Turning.
• 11006516Aug 17, 2024Steering. Shimmy Felt In Front End
• 11006887Aug 8, 2024Wheels. WHEEL - STEEL
• 11006237Aug 7, 2024Other or unknown, Body and structure. WARRANTY BULLETIN D-23-04 2018 - 2024 (Current) Jeep Wrangler (JL) and 2020 - 2024 (Current) Jeep Gladiator (JT) - Corrosion Warranty Claim Simplification (Rev. D)
• 11006240Aug 6, 2024Transmission and drivetrain. Griding/Gear Clash From Transfer Case When Going Into 4WD, Above 5 mph (8 kph).
• 11005356Jul 24, 2024Transmission and drivetrain. Carrier – planetary & shaft kit - output
• 11005320Jul 24, 2024Body and structure. "Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges or other exterior surface areas of the hinges, doors, fenders, swing gates or liftgates. NOTE: Verify current warranty policy to determine if digital imaging pre-authorization is required or pre-approval is required from the Regional Office; depending on market.
• 11003796Jul 1, 2024Body and structure. Water Leak From Front Door. Water On Front Floor.
• 11002828Jun 25, 2024Engine, Electrical system. "Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC) Inaccurate, Battery Charging Message, Presence of IBS related Diagnostic Trouble Codes (DTCs), or Battery Warning Lamp On "
• 11002351Jun 25, 2024Engine. Pump – water & connector - oil cooler tube
• 11002350Jun 25, 2024Engine. Pump – water & connector - oil cooler tube
• 11002019Jun 21, 2024Electrical system, Body and structure. SWITCH Power Window Before replacing the window switch, please follow these steps: 1.- Review the master window Switch for any physical issue (Button stuck, broke). If not, physical issue is found move to next step 2.- Make sure all the switches harness are properly connected, disconnect the switch and reconnect it, and reverify the issue. If after performing these steps the switch remains faulty, please replace…
• 11002424Jun 20, 2024Visibility (wipers, defrost, mirrors). Wiperunit - windshield wiper, blade - front wiper
• 11002315Jun 20, 2024Body and structure. Wiperunit - windshield wiper, blade - front wiper
• 11002314Jun 20, 2024Body and structure. Wiperunit - windshield wiper, blade - front wiper.
• 11001459Jun 7, 2024Engine. Suspected Engine Coolant Leak
• 11001383Jun 6, 2024Body and structure. Freedom Panel Underside Rough And Or White Coating Flaking
• 11001319May 30, 2024Steering. "Air Trapped in Steering Damper Warranty Extension XF1 A shimmy in the steering wheel after hitting an irregularity on the road surface (symptom is more prevalent in cold temperatures). This bulletin involves replacing the steering damper."
• 11001026May 29, 2024Body and structure. Water Leaking Near Front Bulkhead Or Cowl Area On Driver’s Side.
• 11000801May 15, 2024Transmission and drivetrain. "Axle Assembly Do not replace the Axle for Axle Locker Sensor failure. The parts kit (SENSOR KIT, Axle: 68544629A$) must be used to repair the Axle Locker Sensor on JL/JT equipped with the M210 and M220 Tru-Lok axles (DSE). Internal axle components are serviceable. Complete axle assemblies should not be replaced unless necessary due to damaged housing. Over repairs may be subject to chargeback."
• 11000795May 7, 2024Transmission and drivetrain. "VALVE BODY & CONTROL UNIT Transmission Ensure clutch pressure check has been completed and documented prior to valve body replacement."
• 11000168May 6, 2024Electrical system. HEADLAMP
• 11001198May 5, 2024Engine. Suspected Engine Coolant Leak
• 11000862May 3, 2024Steering. "Loss Of Power Steering Assist. U0131 Lost Communication With Electro Hydraulic Power Steering Control Module (EHPS)."
• 11000195May 2, 2024Engine. "PUMP WATER For 2016-2024MY 3.6L Pentastar Upgrade with suspected coolant leak. PRIOR TO PERFORMING ANY WATER PUMP REPLACEMENT, PROCEED WITH INSPECTION INSTRUCTIONS FROM THE LATEST VERSION OF STAR ONLINE PUBLICATION S2307000002. Please submit pictures of the leak area thru the DIDI process outlined in the STAR Online document. NOTE: Some coolant residue may be found at the water pump weep hole plug area which may…
• 10251863Jan 23, 2024Exterior lighting, Back-over prevention (rear camera). Front and Rear Axle Sensor Kit **Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find that the following Diagnostic Trouble Code (DTC) has been set: ? C1451-11 - Service Axle Locker System** Customers may also comment on a Service Axle Locker message displayed in the Electronic Vehicle Information Center (EVIC) for this condition.
• 10251817Jan 17, 2024Electrical system. Revised Customer Satisfaction Notification Y40 ? Control Module Software Updates
• 10251845Jan 13, 2024Electrical system, Equipment. Floor Console USB Inoperative Customers may comment on the following: ? Customer states the Apple Carplay/Android Auto? does not work or is intermittently working when their device is plugged into the center console bin USB port. This replacing the center console USB cable.
• 10251785Jan 13, 2024Equipment. SOS and Assistance Call Not Working After Radio Exchange Unit Installed
• 10251816Jan 12, 2024Electrical system. Customer Satisfaction Notification Y40 Control Module Software Updates
• 10251783Jan 10, 2024Electrical system. Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC) Inaccurate, Battery Charging Message, Presence of IBS related Diagnostic Trouble Codes (DTCs), or Battery Warning Lamp On
• 10248848Nov 17, 2023Equipment. Spring Front Upr - Isolator Before replacing this part. Please contact FCA REDACTED CONTENT. ~ If no response in 15 minutes, proceed with repair.
• 10248877Nov 16, 2023Transmission and drivetrain. Verifying Camshaft Diagnosis
• 10248857Nov 3, 2023Seats. Buzz Squeak Rattle (BSR) From Rear Seat Area.
• 10247441Oct 18, 2023Electrical system. Inspecting And Disconnecting Negative Battery Cables On ESS Vehicles
• 10247404Oct 2, 2023Back-over prevention (rear camera), Vehicle speed control. ERG Hydraulic Tensioner Before replacing any FEAD components, please check FEAD belt layout as per the engine sales code. Customer complaint may include a noise from under the hood described as a squeal, screech, squeak, chirp or belt-related noise and/or noisy tensioner/pulley. Please refer to SOL# S2309000007.
• 10248584Sep 30, 2023Fuel system. Message in cluster for "Performance Limited Service Fuel System" with no DTC's
• 10244423Sep 30, 2023Electrical system, Fuel system. Message in cluster for "Performance Limited Service Fuel System" with no DTC's
• 10248576Sep 21, 2023Engine cooling. Engine oil leak
• 10244415Sep 21, 2023Engine cooling. Engine oil leak
• 10244356Sep 20, 2023Suspension. LIFTER, Hydraulic Roller Deactivating Please do not replace MDS lifters because the disconnecting pin is not lined up, this is normal and not a defect.
• 10248568Sep 18, 2023Visibility (wipers, defrost, mirrors), Lane departure. Exterior Mirror And Or Blind Spot Inoperative.
• 10244407Sep 18, 2023Electrical system, Visibility (wipers, defrost, mirrors). Exterior Mirror And Or Blind Spot Inoperative.
• 10248565Sep 15, 2023Equipment. Buzz Squeak Rattle (BSR) From Sound Bar Or Sport Bar Area.
• 10248509Sep 15, 2023Electrical system. Connector kit Before ordering this connector repair kit 68018957A$, check it in the Mopar Connector Repair Kit Website to confirm part number and applicability. There is an error with the wiring diagrams in Service Library that is causing the incorrect repair kit part number to populate. Please use the Mopar Connector Repair Kit Website until this issue is resolved.
• 10244404Sep 15, 2023Body and structure. Buzz Squeak Rattle (BSR) From Sound Bar Or Sport Bar Area.
• 10244348Sep 15, 2023Electrical system. Connector kit Before ordering this connector repair kit 68018957A$, check it in the Mopar Connector Repair Kit Website to confirm part number and applicability. There is an error with the wiring diagrams in Service Library that is causing the incorrect repair kit part number to populate. Please use the Mopar Connector Repair Kit Website until this issue is resolved.
• 10248562Sep 13, 2023Transmission and drivetrain. 8-Speed Transmission, Additional Transmission Fluid Leak Inspection/Repair Guidelines.

← All problems reported for the 2019 Jeep Wrangler