2020 Jeep Wrangler Technical Service Bulletins

1,020 technical service bulletins (TSBs) are on record for the 2020 Jeep Wrangler. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 11018453May 12, 2025Transmission and drivetrain. "Transmission Fluid Please note fluid color/condition/odor is NOT an indicator of transmission health and should not be used as the reason for unit replacement. Visible ""glitter"" or debris in the pan does not justify complete unit replacements."
• 11018452May 12, 2025Transmission and drivetrain. Transmission "Transmission For transmission concerns related to DTCs P0733-00, P1DA8-00, and/or P1D92-00, a repair is available, and transmission replacement is NOT required. Please reference TSB 21-009-25 Rev. A, for details on D-clutch replacement. Please also note, visible ""glitter"" or debris in the pan and fluid color/condition/odor is NOT an indicator of transmission health and should not be used as the…
• 11018451May 12, 2025Engine. 3.6L PSU Long Block Misfire DTC codes and/or rough idle and/or valvetrain noise. Refer to SOL # S2509000004. It is also important to confirm that the vehicle being repaired has the latest calibration/software update for oil pump operation mode (high pressure mode) during engine start up. RU, VF, WL & WD vehicles already include the latest oil pump mode in all 25MY and beyond. 24MY service releases are also available.
• 11017401Apr 29, 2025Engine. "No Start, Stop Start Inoperative, Battery or Check Engine Light (CEL) Illuminated"
• 11017073Apr 16, 2025Steering. "Drag Link Long Socket FOR STEERING SHIMMY DIAGNOSIS, PLEASE REFERENCE S1819000004 Rev. Q AND 19 - Steering / Diagnosis and Testing (IN SERVICE LIBRARY). PLEASE REFER 19 - Steering / Linkage / END, Tie Rod / Diagnosis and Testing IF YOU HAVE BALL JOINT LOOSENESS CONCERN. PLEASE DO NOT REPLACE DRAG LINK AND TIE ROD UNLESS PART HAS VISIABLE DAMAGE OR FREE PLAY EXCEEDS SPECS."
• 11016879Apr 5, 2025Transmission and drivetrain. "850RE D Clutch Repair **Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must have at least 11,265 km (7,000 mi.) and exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs):** ● P0733-00 - Gear 3 Shift Incorrect Ratio. ● P1DA8-00 - Incorrect Gear Ratio Clutch A B or D Defective. ● P1D92-00 - Incorrect Gear Ratio - Clutch 4 Defective. Customers may also…
• 11016617Apr 4, 2025Electrical system, Body and structure. Rear Defogger Solder Terminals Detached.
• 11016439Apr 2, 2025Engine. Misfire DTCs, Rough Idle, Valvetrain Noise
• 11016431Apr 2, 2025Body and structure. "Replacement Exterior Mirror Glass Connector Does Not Match For Blind Spot."
• 11016424Apr 2, 2025Body and structure. Exterior Rear View Mirror Stained And Will Not Clean.
• 11016107Apr 1, 2025Engine. Engine Rattle Noise
• 11016061Mar 28, 2025Transmission and drivetrain. "Transmission For transmission concerns related to DTCs P0733-00, P1DA8-00, and/or P1D92-00, a repair is available, and transmission replacement is NOT required. Please reference TSB 21-009-25 Rev. A, for details on D-clutch replacement. Please also note, fluid color/condition/odor is NOT an indicator of transmission health and should not be used as the reason for unit replacement. Complete unit replacements…
• 11016136Mar 18, 2025Other or unknown. TOP KIT - SOFT
• 11015811Mar 17, 2025Transmission and drivetrain. "D Clutch Repair Kit For transmission concerns related to DTCs P0733-00, P1DA8-00, and/or P1D92-00, a repair is available, and transmission replacement is NOT required. Please reference TSB 21-009-25 Rev. A, for details on D-clutch replacement. Please also note, fluid color/condition/odor is NOT an indicator of transmission health and should not be used as the reason for unit replacement. Complete unit replacements…
• 11015810Mar 17, 2025Other or unknown. "CANISTER Vapor -If an issue is detected with the Evaporative System Integrity Module (ESIM) Detector and not the Vapor Canister, only replace the ESIM Detector. -Before replacing the Vapor Canister due to Hard to Fill condition, replicate the condition at the Gas Station.
• 11015797Mar 17, 2025Brakes. Antilock Brake System (ABS) Module Will Not Initialize After Recent Service Replacement.
• 11015598Mar 12, 2025Other or unknown. ID-23-03 Rev. I 2018 - 2024 Jeep Wrangler (JL) and 2020 - 2024 (Current) Jeep Gladiator (JT) - Corrosion Warranty Claim Simplification
• 11015591Mar 12, 2025Other or unknown. D-23-04 Rev. H 2018 - 2024 Jeep Wrangler (JL) and 2020 - 2024 Jeep Gladiator (JT) - Corrosion Warranty Claim Simplification
• 11015297Mar 4, 2025Engine. Engine Noise
• 11015033Feb 28, 2025Body and structure. Replacement Exterior Mirror Glass Connector Does Not Match For Blind Spot.
• 11015065Feb 25, 2025Engine. 3.6L PSU Long Block Misfire DTC codes and/or rough idle and/or valvetrain noise. These conditions may be related to worn intake camshaft high lift lobe(s), and intake rocker arm(s) high lift slider. High mileage failure (10,000-60,000 miles). 1. Remove the valve cover(s) per the released service procedures. The use of a stethoscope or DTC specific cylinder misfire codes can help to locate the condition to the left…
• 11014532Feb 19, 2025Body and structure. Exterior Rear View Mirror Stained And Will Not Clean.
• 11014891Feb 18, 2025Electrical system. Module - battery heater
• 11014408Feb 18, 2025Engine. Engine Rattle Noise
• 11014268Feb 15, 2025Steering. Shimmy Felt In Front End
• 11014266Feb 14, 2025Body and structure, Electrical system. Defogger Is Not Working. Terminal Detached From The Glass.
• 11014384Feb 13, 2025Electrical system, Body and structure. "Rear Defroster Inoperative Customers may experience one or more of the following: ● Rear window is not defrosting. ● The rear window glass left or right side defrost solder terminal is detached from the defrost grid. This bulletin involves replacing the Electric Backlite (EBL) wire connector repair and re-securing the electrical connector(s) to the rear window"
• 11014337Feb 11, 2025Electrical system. Uconnect Box Error Message, With Active or Stored Cellular Antenna Open or Short Diagnostic Trouble Codes (DTCs)
• 11014264Feb 11, 2025Electrical system. Cluster Warning Lamp is on, Service 4WD Message
• 11014231Feb 10, 2025Engine. "3.6L PSU Long Block Misfire DTC codes and/or rough idle and/or valvetrain noise. These conditions may be related to worn intake camshaft high lift lobe(s), and intake rocker arm(s) high lift slider. High mileage failure (10,000-60,000 miles). 1. Remove the valve cover(s) per the released service procedures. The use of a stethoscope or DTC specific cylinder misfire codes can help to locate the condition to the left…
• 11013597Feb 1, 2025Transmission and drivetrain. "D Clutch Repair Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● P0733-00 - Gear 3 Shift Incorrect Ratio. ● P1DA8-00 - Incorrect Gear Ratio Clutch A B or D Defective. ● P1D92-00 - Incorrect Gear Ratio - Clutch 4 Defective. Customers may also comment on one or more of the following: ●…
• 11013643Jan 30, 2025Engine. THROTTLE BODY
• 11013171Jan 25, 2025Electrical system. Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC) Inaccurate, Battery Charging Message, Presence of IBS Related Diagnostic Trouble Codes (DTCs), or Battery Warning Lamp On
• 11013652Jan 22, 2025Transmission and drivetrain. Transmission - 8 speed
• 11013625Jan 21, 2025Other or unknown. Evaporator - air conditioning
• 11012925Jan 17, 2025Steering. Drag Link Long Socket FOR STEERING SHIMMY DIAGNOSIS, PLEASE REFERENCE S1819000004 Rev. Q AND 19 - Steering / Diagnosis and Testing (IN SERVICE LIBRARY). PLEASE REFER 19 - Steering / Linkage / END, Tie Rod / Diagnosis and Testing IF YOU HAVE BALL JOINT LOOSENESS CONCERN. PLEASE DO NOT REPLACE DRAG LINK AND TIE ROD UNLESS PART HAS VISIABLE DAMAGE OR FREE PLAY EXCEEDS SPECS.
• 11013016Jan 15, 2025Transmission and drivetrain. D Clutch Repair Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● P0733-00 - Gear 3 Shift Incorrect Ratio. ● P1DA8-00 - Incorrect Gear Ratio Clutch A B or D Defective. ● P1D92-00 - Incorrect Gear Ratio - Clutch 4 Defective. **Customers may also comment on one or more of the following: ●…
• 11012875Jan 14, 2025Brakes. Antilock Brake System (ABS) Module Will Not Initialize After Recent Service Replacement.
• 11012777Jan 7, 2025Electrical system. Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC) Inaccurate, Battery Charging Message, Presence of IBS related Diagnostic Trouble Codes (DTCs), or Battery Warning Lamp On
• 11012010Dec 17, 2024Other or unknown. FUEL VAPOR CANISTER FILTER EVAP Fuel Filters are to be checked for restriction / blockage on a regular schedule as indicated in the Owner s Manual. If the Filter is restricted or blocked then replace the part. For customers that drive light duty trucks in extreme dusty and dirty road conditions, please reference information only TSB 25-009-24 for an available MOPAR Dual EVAP Filter kit that is customer paid.
• 11012293Dec 16, 2024Other or unknown. FILTER - AIR
• 11012292Dec 16, 2024Other or unknown. FILTER - AIR
• 11011997Dec 16, 2024Engine. Turbocharger Kit Please note many parts of the Turbo Assembly can be serviced separately and complete turbo replacement may not be necessary. If the Turbo is being replaced for a noise or a rattle, inspect the wastegate for binding. The actuator kit is serviced separately. If the turbo is being replaced for an oil leak concern, please inspect the area around the turbo oil feed oring for a leak. The o-ring is…
• 11011921Dec 14, 2024Transmission and drivetrain. "D Clutch Repair Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● P0733-00 - Gear 3 Shift Incorrect Ratio. ● P1DA8-00 - Incorrect Gear Ratio Clutch A B or D Defective. ● P1D92-00 - Incorrect Gear Ratio - Clutch 4 Defective. This bulletin involves replacing the D clutch"
• 11011901Dec 11, 2024Other or unknown. Warranty Bulletin ID-23-03 Rev. H 2018 - 2024 Jeep Wrangler (JL) and 2020 - 2024 (Current) Jeep Gladiator (JT) - Corrosion Warranty Claim Simplification
• 11011898Dec 11, 2024Other or unknown. Warranty Bulletin D-23-04 Rev. G 2018 - 2024 Jeep Wrangler (JL) and 2020 - 2024 Jeep Gladiator (JT) - Corrosion Warranty Claim Simplification
• 11011505Dec 4, 2024Body and structure. Buzz Squeak Rattle (BSR) From Speaker Sound Bar At High Volume Level.
• 11011504Dec 4, 2024Body and structure. Buzz Squeak Rattle (BSR) From Sound Bar Or Sport Bar Area.
• 11011150Nov 20, 2024Body and structure. COVER KIT - HOOD
• 11011171Nov 12, 2024Steering. DAMPER - NONE

← All problems reported for the 2020 Jeep Wrangler