2023 Jeep Wrangler Technical Service Bulletins

498 technical service bulletins (TSBs) are on record for the 2023 Jeep Wrangler. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 11023168Sep 12, 2025Suspension. Shock And Strut Diagnosis And Replacement Guidelines Leaking, noisy, or weak shocks or struts.
• 11022011Aug 16, 2025Body and structure. Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges or other exterior surface areas of the hinges, doors, fenders, swing gates or liftgates.
• 11022012Aug 14, 2025Body and structure. Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges or other exterior surface areas of the hinges, doors, fenders, swing gates or liftgates.
• 11022003Aug 13, 2025Body and structure. Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges or other exterior surface areas of the hinges, doors, fenders, swing gates or liftgates
• 11021557Jul 31, 2025Electrical system. Flash: Radio Frequency Hub Module (RFHM) Updates Customers must experience the following: ● Customers may be concerned about vehicle theft due to ability of key FOBs to be programmed through RFHM. Software enhancement includes: ● Update to the RFHM software to prevent unauthorized keyfob programming. ● This is intended to deter an unwanted drive off of the vehicle without the customer's knowledge. This bulletin…
• 11021583Jul 29, 2025Steering. Damper - steering
• 11021582Jul 29, 2025Steering. Damper - steering
• 11021043Jul 26, 2025Engine. Engine Rattle Noise
• 11021029Jul 24, 2025Body and structure. Windshield Wiper Blade Maintenance Customers may experience one or more of the following: ● Wiper blades that chatter/streak/jump/skip/smear or make noise while traveling across the windshield.
• 11021039Jul 23, 2025Electrical system. Tire Pressure Monitor (TPM) Service Information. TPM Lamp On.
• 11020832Jul 16, 2025Engine. Engine Cylinder Block Porosity Inspection - Engine Cold Start Rough Idle Customers may experience the following: ● Rough engine idle when cold starting the engine. ● Low coolant level in coolant recovery bottle.
• 11020858Jul 15, 2025Engine. Module - engine controller
• 11020855Jul 14, 2025Transmission and drivetrain. To inform dealers about the 850RE valve body PN: R8348504A connector: the original 16-pin connector included six pins that were not used in this application. To simplify the design, the connector has been optimized and updated to a 10-pin configuration.
• 11020767Jul 8, 2025Engine. Verify Reman part number availability. Order the "R" part number for all orders:
• 11020636Jul 4, 2025Transmission and drivetrain. 850RE D Clutch Repair Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must have at least 11,265 km (7,000 mi.) and exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● P0733-00 - Gear 3 Shift Incorrect Ratio. ● P1DA8-00 - Incorrect Gear Ratio Clutch A B or D Defective. ● P1D92-00 - Incorrect Gear Ratio - Clutch 4 Defective. Customers may also comment…
• 11020600Jul 4, 2025Electrical system. Decreased Remote Start And RKE Range. Tire Pressure Sensors Values Are Not Displayed
• 11020608Jul 3, 2025Engine. When replacing a camshaft and parts kit (P/N 68661146xx and/or 68661147xx), it is NOT necessary to order the roller-finger followers (rocker arms) separately, as these are included in the camshaft parts kit.
• 11020108Jun 24, 2025Fuel system. Frequent Repairs Of Fuel System Components Such As Fuel Filters Numerous Stellantis vehicles having fuel line components replaced such as diesel fuel filters. Occasionally, components are replaced before their standard life expectancy or when not contaminated with debris.
• 11020090Jun 24, 2025Body and structure. RAIL - REAR
• 11020089Jun 24, 2025Other or unknown. VALVE - CHECK
• 11019773Jun 18, 2025Engine. ADJUSTER Valve Lash Customer's complaint may include a ticking noise coming from the engine. Technician's observations can refer to spongy or stuck hydraulic lash adjusters. Exhaust lash adjusters found with a "spongy" condition (compressible plunger) leading to the assumption of being defective/malfunctioning. EXHAUST lash adjusters are designed to be COMPRESSIBLE by hand.
• 11019600Jun 11, 2025Other or unknown. Warranty Newsletter – Volume 11, Issue 6
• 11019598Jun 11, 2025Other or unknown. FCA Caribbean Warranty Newsletter – Volume 11, Issue 6
• 11019586Jun 10, 2025Electrical system. "Global Telematics Box Module Over The Air Update from 5.39.1 to 5.65 TBM2.0 Software Version (FOTA) Customers may experience one or more of the following: - Error display of ""Uconnect Box Requires Service/Wifi Unavailable"" popups; [ TBM DTC B22A9-96 Internal Performance Failure ]. - Error display of ""Uconnect Box Requires Service"" pop-ups; [ TBM DTCs B1560, B1561, B1562 - Antenna loose connection ]."
• 11019442Jun 6, 2025Body and structure. "Shim - felt GIM # NUSENGCHR24018991: JL JT sun visor center support BSR. Add felt shim 68736674AA - 43MM OD x 10mm ID x 1mm thick. "
• 11019433Jun 6, 2025Fuel system. "Frequent Repairs Of Fuel System Components Such As Fuel Filters Numerous Stellantis vehicles having fuel line components replaced such as fuel filter. Occasionally, components are replaced before their standard life expectancy or when not contaminated with debris "
• 11018867May 30, 2025Electrical system. "Motor Generator Unit (MGU) Replacement Customers **must** experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician **must** find the following Diagnostic Trouble Code (DTC) has been set: ● P1B0F-00 - Drive Motor A Position Sensor Offset Incorrect. Customers may also experience one or more of the following: ● Vehicle goes into limp home mode. ● Vehicle does not start.
• 11018863May 29, 2025Fuel system. "Frequent Repairs Of Fuel Line Components Such As Fuel Filters Numerous Stellantis vehicles having fuel line components replaced such as fuel filter. Occasionally, components are replaced before their standard life expectancy or when not contaminated with debri "
• 11018666May 28, 2025Electrical system. Underhood start/stop safety The customer may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find the following Diagnostic Trouble Code (DTC): - P152E Engine -Hood Switch 2 Circuit High. - DTC P152F Customers may also experience: - Start/Stop system warning light. - Start/Stop inoperable. - Remote start inoperable.
• 11018609May 28, 2025Electrical system. Power Top Switch Unresponsive, Full Retractable Sky Roof Does Not Open or Close Customer Complaint/Technician Observation: The owner complains the top system is inoperative and that by pressing the switches the Power Top does not make any movement. Technician may or may not have Diagnostic Trouble Codes (DTCs). Repair Procedure: Perform the power top calibration prior to any switch or parts replacement.
• 11018810May 27, 2025Electrical system. Bezel & indicator- gear shift indicator
• 11018676May 21, 2025Suspension. "Shock And Strut Diagnosis And Replacement Guidelines Leaking, noisy, or weak shocks or struts. "
• 11018637May 20, 2025Body and structure. Backlite Heated Liftgate Glass Assembly: For rear window defrost inoperative concerns where heated glass electrical tab has become detached, it is not necessary to replace the glass assembly. For loose or detached electrical tab, refer to TSB 23-007-25 for repair procedures on reattaching a loose tab. For burned or discolored gridlines on hard tops, DO NOT change the complete Flipper glass assembly. This…
• 11018482May 18, 2025Engine. "Misfire Diagnostic Trouble Codes (DTCs), Rough Idle, Valvetrain Noise Customers may experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle may exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● P0301 - Cylinder 1 Misfire. ● P0302 - Cylinder 2 Misfire. ● P0303 - Cylinder 3 Misfire. ● P0304 - Cylinder 4 Misfire. ● P0305 - Cylinder 5 Misfire. ● P0306 - Cylinder 6 Misfire…
• 11018450May 17, 2025Electrical system. Universal Garage Door Opener (UGDO) Inoperative, LED Indicator Lamps Not Illuminating
• 11018447May 16, 2025Electrical system. "Washer Light On And Will Not Turn Off After Adding Washer Solvent."
• 11018500May 15, 2025Fuel system. Tube - fuel injector supply & gasket - none
• 11018408May 14, 2025Fuel system. Tube - fuel injector supply & gasket - none
• 11018453May 12, 2025Transmission and drivetrain. "Transmission Fluid Please note fluid color/condition/odor is NOT an indicator of transmission health and should not be used as the reason for unit replacement. Visible ""glitter"" or debris in the pan does not justify complete unit replacements."
• 11018452May 12, 2025Transmission and drivetrain. Transmission "Transmission For transmission concerns related to DTCs P0733-00, P1DA8-00, and/or P1D92-00, a repair is available, and transmission replacement is NOT required. Please reference TSB 21-009-25 Rev. A, for details on D-clutch replacement. Please also note, visible ""glitter"" or debris in the pan and fluid color/condition/odor is NOT an indicator of transmission health and should not be used as the…
• 11018451May 12, 2025Engine. 3.6L PSU Long Block Misfire DTC codes and/or rough idle and/or valvetrain noise. Refer to SOL # S2509000004. It is also important to confirm that the vehicle being repaired has the latest calibration/software update for oil pump operation mode (high pressure mode) during engine start up. RU, VF, WL & WD vehicles already include the latest oil pump mode in all 25MY and beyond. 24MY service releases are also available.
• 11018260May 11, 2025Electrical system. "Global Telematics Box Module (TBM) Firmware Over The Air (FOTA) Update 2023 - 2025 (JL) Jeep Wrangler 2023 - 2025 (JT) Jeep Gladiator This bulletin applies to vehicles built on or before May 05, 2025 (MDH 0505XX) equipped with Global Telematics Box Module (TBM) (Sales Code RDG). This bulletin provides information regarding the latest Firmware Over The Air (FOTA) update and provides the service technician an…
• 11017401Apr 29, 2025Engine. "No Start, Stop Start Inoperative, Battery or Check Engine Light (CEL) Illuminated"
• 11017092Apr 17, 2025Electrical system. AM Radio Static, With No Active or Stored Radio Antenna Diagnostic Trouble Codes (DTC).
• 11017073Apr 16, 2025Steering. "Drag Link Long Socket FOR STEERING SHIMMY DIAGNOSIS, PLEASE REFERENCE S1819000004 Rev. Q AND 19 - Steering / Diagnosis and Testing (IN SERVICE LIBRARY). PLEASE REFER 19 - Steering / Linkage / END, Tie Rod / Diagnosis and Testing IF YOU HAVE BALL JOINT LOOSENESS CONCERN. PLEASE DO NOT REPLACE DRAG LINK AND TIE ROD UNLESS PART HAS VISIABLE DAMAGE OR FREE PLAY EXCEEDS SPECS."
• 11017070Apr 14, 2025Electrical system. "Telematics Box Module Verify Z part number availability. Order a Z part number for all Exchange Orders: warranty, Mopar, customer pay and service contract. Order regular part number for New unsold units only."
• 11016951Apr 11, 2025Other or unknown. FCA Caribbean Warranty Newsletter – Volume 11, Issue 4
• 11016939Apr 9, 2025Other or unknown. Warranty Newsletter – Volume 11, Issue 4
• 11016879Apr 5, 2025Transmission and drivetrain. "850RE D Clutch Repair **Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must have at least 11,265 km (7,000 mi.) and exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs):** ● P0733-00 - Gear 3 Shift Incorrect Ratio. ● P1DA8-00 - Incorrect Gear Ratio Clutch A B or D Defective. ● P1D92-00 - Incorrect Gear Ratio - Clutch 4 Defective. Customers may also…
• 11016867Apr 4, 2025Electrical system, Engine. "Camshaft Sensor DTC Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set the following Diagnostic Trouble Code (DTC): ● P0341 - Camshaft Position Sensor - Performance Bank 1 - Sensor 1. This bulletin involves repairing the cam sensor harness and re-routing the generator wiring."

← All problems reported for the 2023 Jeep Wrangler