2016 Land Rover LR4 Fuel system Problems

“Gas tank dust cover cracked, leaking frank fuel over the tank, onto vehicle components and onto the floor with associated fumes. Vehicle leaked fuel while stationary in the garage, leaking fumes into the house. Vehicle was taken to Land Rover for repairs. Repair team noted this is a known issue and the cover was re-designed. I was charged approximately $800 for the part and labor. This is a known issue with this make and model.”

“• Ask the customer (and document verbatim) what occurred or what the alleged defect is? I attempted multiple times to have Land Rover complete Safety Recall N623 – NHTSA Recall Number 21V-635 on my 2016 Land Rover LR4 -Gasoline Fuel Tank Flange Assembly Crack. A number of the Land Rover dealerships stated that no recall existed. After multiple attempts to confirm this recall was required for my vehicle, I was able to schedule the repair at Land Rover Cary. I reduced driving the vehicle to only minimal driving requirements while I was awaiting the recall requirement. …”

“Formal safety complaint against dealer for recall malpractice and non-compliance with federal safety repair procedures under Campaign 21V635000. During recall service, the service department completely bypassed the mandatory TOPIx Workshop Manual Section 310-01 electronic priming sequence, leaving high-pressure fuel rails completely dry upon reassembly. Bypassing this safety protocol introduced severe air pockets into the high-pressure fuel system. …”

“The contact owns a 2016 Land Rover LR4. The contact stated that while driving at 75 MPH the low coolant warning light was illuminated, the steering wheel became difficult to maneuver, the brake pedal was depressed and traveled to the floorboard without stopping the vehicle. The vehicle was shifted to neutral, and the start/stop button was depressed in order to stop the vehicle. The vehicle was towed to the dealer where it was diagnosed with cracks in the coolant and fuel systems that caused a leak and needed replacement. …”

“The contact owns a 2016 Land Rover LR4. The contact had recently taken the vehicle to a dealer to be repaired under NHTSA Campaign Number: 21V635000 (Fuel System, Gasoline). The contact stated that while attempting to refuel the vehicle, he observed that fuel was puddling underneath the vehicle. The contact stated that he had not refueled the vehicle prior to the recall repair. The contact had the vehicle towed back to the residence. The contact called the dealer and was advised to bring the vehicle back to the dealer to be diagnosed. The vehicle was not repaired. …”