2023 Lincoln Nautilus Technical Service Bulletins

58 technical service bulletins (TSBs) are on record for the 2023 Lincoln Nautilus. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 11038617Oct 14, 2026Other or unknown, Electrical system. This bulletin supersedes 26-2297. Reason for update: Add 2022-2025 Transit vehicles. Some of the vehicles listed in the model statement above equipped with SYNC4 may experience a blank center display screen or black center display screen after welcome animation. The rear-view camera will still function when shifting the vehicle to reverse under these conditions.
• 11037678Sep 22, 2026Body and structure, Other or unknown. This article supersedes TSB 25-2466 to add Bronco Sport, Escape, Maverick and Corsair, as well as removing Expedition and Navigator. One time use parts for Corsair and Bronco Sport were also added to the parts list. Some of the vehicles listed in the Model statement above may exhibit a headliner rattle or sagging condition around the roof opening panel. This may be due to the adhesive separating from the headliner…
• 11037661Sep 17, 2026Other or unknown, Transmission and drivetrain. This bulletin supersedes 26-2171. Reasons for update: update the Parts list to add a note to clarify the application of the part numbers W520102-S442 and 4S4Z-3N324-AA "FWD Only".
• 11035269Jul 23, 2026Fuel system, Electrical system, Other or unknown. Some 2021-2026 Ford/Lincoln vehicles may exhibit various symptoms including but not limited to the auto start/stop system not operating as intended with a "Check Charging System" message in the instrument panel cluster (IPC) while the charging system is operating properly with no charging related diagnostic trouble codes (DTC) stored.
• 11035231Jul 23, 2026Transmission and drivetrain, Other or unknown. This bulletin supersedes 26-2171. Reasons for update: update the Parts list to add a note to clarify the application of the part numbers W520102-S442 and 4S4Z-3N324-AA "FWD Only".
• 11035099Jul 15, 2026Transmission and drivetrain, Other or unknown. This bulletin supersedes 26-2194. Reason for update: update the Parts list to correct a part description " Loctite 638", update the claim quantity for the drain/fill plug, update the claim quantity of the wheel hub bolts (Corsair) and limited the parts list for Edge/Nautilus to only the rear drive unit fluid.
• 11035255Jul 8, 2026Other or unknown, Electrical system. Quality improvements include: - Enhanced system performance, disk usage limits and memory monitoring
• 11034134Jun 24, 2026Other or unknown, Electrical system. Some of the vehicles listed in the model statement above equipped with SYNC4 may experience a blank center display screen or black center display after welcome animation. The rear-view camera will still function when shifting the vehicle to reverse under these conditions.
• 11033762Jun 3, 2026Transmission and drivetrain. This bulletin supersedes 26-2140. Reason for update: update the Parts list to correct the part description of the part number JM5Z-7N473-C, correct the part number XY-75W85QL to XY-75W85-QL and add a description note "Transfer Case Fluid, All markets", and update the Service Procedure (Steps 5, 7 and 8) to correct the WSM procedure steps.
• 11031619Apr 26, 2026Transmission and drivetrain. This bulletin supersedes 25-2627. Reason for update: To add a Step to reprogram the all-wheel drive (AWD) module for Bronco Sport vehicles. Some of the vehicles listed in the Model statement above may exhibit all of the following conditions:  Shudder chatter condition, most noticeable at low speeds turning  No relevant diagnostic trouble codes (DTCs) present This may be due to internal rear drive unit (RDU) fluid…
• 11031632Apr 24, 2026Other or unknown, Electrical system. Some 2021-2023 Nautilus vehicles may exhibit inoperative phone as a key and no communication with the remote function actuator (RFA) module. There may also be diagnostic trouble code (DTC) U0214 stored in various modules for loss of communication with the RFA module. To correct the condition, remove the RFA fuse (F19) located in the body control module (BCM). After one minute, reinstall the fuse to re-establish…
• 11031609Apr 21, 2026Transmission and drivetrain. Some of the vehicles listed in the Model statement above may exhibit at least one of the following conditions: * Intermittent or permanent no reverse engagement. * Illuminated malfunction indicator lamp (MIL) with diagnostic trouble code (DTC) P0767 stored in the powertrain control module (PCM). In addition to the required conditions, the vehicle may also exhibit a harsh reverse engagement, DTC P0766 and/or P2703.
• 11031490Apr 17, 2026Engine. This article updates TSB 25-2154. Reasons for update: *Parts List *Service Procedure to replace the output planetary carrier assembly *Added 2023-2024 model year vehicles Some of the vehicles listed in the Model statement above may exhibit all of the following conditions:  Shudder condition, most noticeable at speeds below 60 mph (100 km/h)  No relevant diagnostic trouble codes (DTC) present  Traceable shudder…
• 11030580Mar 13, 2026Electrical system, Visibility (wipers, defrost, mirrors), Other or unknown. "25S49 Recall Remedy: -Infotainment software update to address frozen screens"
• 11029921Mar 9, 2026Other or unknown. This article supersedes TSB 25-2466 to add Bronco Sport, Escape, Maverick and Corsair, as well as removing Expedition and Navigator. One time use parts for Corsair and Bronco Sport were also added to the parts list. Some of the vehicles listed in the Model statement above may exhibit a headliner rattle or sagging condition around the roof opening panel. This may be due to the adhesive separating from the headliner…
• 11028804Feb 9, 2026Transmission and drivetrain. This article supersedes TSB 25-2552 to update the Parts List Some of the vehicles listed in the Model statement above may exhibit all of the following conditions:  Shudder chatter condition, most noticeable at low speeds turning  No diagnostic trouble codes DTCs present This may be due to rear drive unit internal (RDU) fluid contamination.
• 11028797Feb 6, 2026Electrical system, Other or unknown, Body and structure. Some 2020-2022-Corsair, 2021-2023 Nautilus, 2020-2024 Navigator/Aviator, and 2021-2024 Mustang Mach-E vehicles equipped with phone-as-a-key may exhibit various phone-as-a-key concerns with diagnostic trouble codes (DTC) U200D:15, U200E:15, U200F:15, B1589:31/49 through B1598:31/49, B1A56:31/49, B1D55:31/49, and/or B15A5:56 stored in the remote function actuator (RFA) module.
• 11028293Jan 22, 2026Electrical system, Other or unknown, Visibility (wipers, defrost, mirrors). "Quality Improvements Include: - Bug Fixing and Feature improvements. - Resolves black screen issue caused when there is no SiriusXM disk space."
• 11025530Nov 10, 2025Transmission and drivetrain. This article supersedes TSB 25-2351 to update the Service Procedure Some of the vehicles listed in the Model statement above may exhibit all of the following conditions:  Shudder chatter condition, most noticeable at low speeds turning  No diagnostic trouble codes DTCs present This may be due to rear drive unit internal (RDU) fluid contamination.
• 11024271Oct 7, 2025Engine. Some 2021-2023 Explorer vehicles equipped with a 3.0L EcoBoost engine, 2021-2023 Aviator vehicles equipped with a 3.0L EcoBoost or 3.0L plug-in hybrid electric vehicle (PHEV) engine, 2021-2023 Edge/Nautilus vehicles equipped with a 2.7L EcoBoost, 2021-2024 F-150 vehicles equipped with a 2.7L EcoBoost, and 2021-2024 Bronco and 2024 Ranger vehicles equipped with a 2.7L or 3.0L EcoBoost engine may exhibit a…
• 11024199Oct 1, 2025Body and structure, Other or unknown. Some of the vehicles listed in the Model statement above may exhibit a headliner rattle or sagging condition around the roof opening panel. This may be due to the adhesive separating from the headliner substrate.
• 11021975Aug 14, 2025Visibility (wipers, defrost, mirrors), Other or unknown. Various 2021-2025 Ford and Lincoln vehicles equipped with the rear camera on demand feature may exhibit "Please Check Surroundings For Safety" or "Full View Not Available" messages when the rear camera button is pressed and the vehicle is not in reverse. Inform customers this condition is considered normal operation and does not affect vehicle durability because the full rear view camera image can only be shown…
• 11022047Aug 7, 2025Other or unknown, Electrical system. "Quality improvements include: -Customers will now be required to confirm the submission of their In Vehicle Voice Feedback using the SYNC screen"
• 11021358Jul 29, 2025Electrical system. Some 2021-2025 Ford and Lincoln vehicles equipped with SYNC4/Digital Experience may exhibit an unsuccessful telematics control unit module (TCU) software update or software activation during a universal serial bus (USB) update. This may be due to the vehicle connectivity setting being disabled.
• 11020999Jul 25, 2025Transmission and drivetrain. This article supersedes TSB 24-2386 to update the Service Procedure and Part List. Some of the vehicles listed in the Model statement above may exhibit all of the following conditions:  Shudder chatter condition, most noticeable at low speeds turning  No diagnostic trouble codes DTCs present Note: Three (3) new Essential Special Service Tools (ESSTs) are required to service the internal clutch pack on vehicles…
• 11020044Jun 25, 2025Transmission and drivetrain, Engine. Some 2021-2024 Edge/Nautilus, 2021-2025 Bronco/Bronco Sport/E-Series/Escape/Corsair/Expedition/Navigator/Explorer/Aviator/F-150/F-Super Duty/Mustang/Ranger, and 2022-2025 Maverick vehicles may require an A/C compressor clutch assembly replacement be performed for various concerns. Workshop Manual (WSM), Section 412-00 Removal and Installation has been updated to eliminate the need to remove and install the A/C…
• 11019702Jun 20, 2025Other or unknown, Electrical system. Some 2021-2025 Ford/ Lincoln vehicles equipped with SYNC4 may not be able to perform an update to the accessory protocol interface module (APIM). This may be due to the software in the APIM. Ford Engineering has de-activated the ability to update these SYNC4 APIM modules as applicable, and the Ford Diagnosis and Repair System (FDRS) will not present an update for the APIM module.
• 11018521May 13, 2025Transmission and drivetrain, Engine. Some 2020 Continental, 2020-2024 Edge/Nautilus, 2020-2025 Explorer/Aviator/Escape/Corsair/F-150/F-Super Duty/Ranger/Transit/E-Series, 2021-2025 Bronco, and 2022-2025 Maverick vehicles may require an engine cooling system flush to be performed for various concerns. Workshop Manual (WSM), Section 303-03 has been updated to eliminate the need to remove and install the radiator assembly to perform a radiator flush.
• 11015546Mar 7, 2025Other or unknown. Some 2019-2024 Edge and 2019-2023 Nautilus vehicles equipped with a 2.0L engine may exhibit a repeat block heater failure.
• 11015514Mar 4, 2025Other or unknown. Some 2021-2024 Bronco Sport, 2020-2024 Escape/Corsair/Edge/Nautilus/Transit Connect and 2022-2024 Maverick vehicles may exhibit erratic shifting and/or a transmission fluid venting condition. If during the preliminary inspection the transmission fluid is found to be a foamy pink color, this may indicate possible cross contamination of engine coolant and transmission fluid due to an internally leaking transmission…
• 11013814Jan 11, 2025Other or unknown. "Quality improvements include: -Enhanced center sceen stability -Digital Owners Manual update"
• 11010950Nov 27, 2024Other or unknown. Various vehicles equipped with a 2.7L or a 3.0L gas engine may require a crankshaft bolt replacement during repairs. Various vehicles equipped with a 2.7L or a 3.0L gas engine may require a crankshaft bolt replacement during repairs.
• 11011009Nov 19, 2024Other or unknown. On your vehicle, the OBD monitoring system for the catalytic converter may not be operating as intended.
• 11011227Nov 15, 2024Other or unknown. "Quality improvements include: -Improved error logging and fault recovery for the Battery Health, Wheel Alignment, Wheel Vibration, and Key off load monitors."
• 11011211Nov 12, 2024Other or unknown. Quality improvements include: -Telematics Control Unit mantains its country code after updates -Ensures factory software image cannot be loaded onto the Telematics Control Unit once a production software has been loaded -Stolen Vehicle Service enhancement
• 11009439Oct 28, 2024Other or unknown. Some vehicles equipped with SYNC4 may exhibit one or more of the following symptoms after all currently available accessory protocol interface module (APIM) software updates have been performed.
• 11009841Oct 25, 2024Other or unknown. Quality improvements include: -ECG minor improvments, not customer facing - Allow vehicle access during OTA update. - Reduction in Key off load battery drain via ECG controlled reset. Networking quality for a better experience with software updates
• 11009445Oct 24, 2024Other or unknown. Some 2018-2024 F150/Edge, 2018 MKX, 2019-2023 Nautilus, 2020-2025 Explorer/Aviator, 2021-2024 Bronco, and 2024 Ranger vehicles equipped with a 2.7L EcoBoost or a 3.0L EcoBoost engine may exhibit an engine oil leak from the crankshaft rear seal with retaining plate.
• 11008948Oct 10, 2024Other or unknown. While performing a transmission repair on some 2012-2024 Ford and Lincoln vehicles, a transmission seal kit may be on backorder due to supply chain interruptions. While performing a transmission repair on some 2012-2024 Ford and Lincoln vehicles, a transmission seal kit may be on backorder due to supply chain interruptions.
• 11001112May 30, 2024Other or unknown. Some vehicles equipped with SYNC4 may exhibit one or more of the following symptoms after all currently available accessory protocol interface module (APIM) software updates have been performed. - General system performance, stability, and intermittent system reboots. - Intermittent Wireless CarPlay or Android Auto function. - Phone related concerns with intermittent No Audio or Static. - Navigation/global…
• 10254334Apr 19, 2024Electrical system. Quality Improvements include: Allow vehicle entry during OTA update. Add secure verification and roll back to Direct Configuration updates.
• 10253552Apr 3, 2024Other or unknown. Various vehicles have had pinpoint tests, guided routines and the Warranty and Policy Manual recentlyupdated for diagnostics and repairs on SYNC generation 3 and later applications. When performingdiagnostics and repairs on SYNC Gen 3 or later, select the diagnostics tab and search for related symptoms,DTCs and keywords. The search results will be shown in the search results pane.
• 10251956Mar 8, 2024Electrical system. Some 2022-2024 various Ford/Lincoln vehicles equipped with SYNC 4 may experience concern where customers are receiving an error message when trying to enroll in connected services. This may be due to the gateway module (GWM) software. To correct the concern, download and run the Transport and Factory Mode Deactivation app: under HS1 modules select BCM > Transport and Factory Mode > Download > Run. When the pop-up…
• 10251952Mar 6, 2024Engine cooling. For 2015-2024 Ford and Lincoln vehicles equipped with turbocharged engines and customer concern of an engine oil leak, refer to Workshop Manual (WSM), Section 303-00 for oil leak inspection and testing methods. Ford has evaluated turbochargers replaced for oil leak symptoms and although oil may collect on the external surface of a turbocharger, it is extremely rare for a turbocharger assembly to be the root cause…
• 10251934Mar 1, 2024Transmission and drivetrain. During service and repair requiring removal and replacement of a crankshaft bolt and/or crankshaft damper, achieving proper torque of the crankshaft pulley bolt is critical. Incorrect torque may allow the bolt to loosen resulting in the timing gear breaking and engine damage. Replacement of the bolt is critical to the repair and accurately following the installation procedure in the Workshop Manual (WSM) Section…
• 10251455Feb 26, 2024Engine cooling. This TSB supersedes TSB 23-2049 to update the parts list. Some 2019-2023 Edge/Nautilus vehicles equipped with a 2.7L EcoBoost engine may exhibit a ticking/tapping or rattle type noise from the top front cover area of the engine on initial start-up after a cold soak of 6 hours or more that may last for 2-5 seconds. This may be due to stuck internal components of the variable cam timing (VCT) unit. To correct the…
• 10247526Dec 12, 2023Back-over prevention (rear camera). Various 2021-2024 Ford and Lincoln vehicles equipped with the rear camera on demand feature may exhibit a Please Check Surroundings For Safety or Full View Not Available message when the rear camera button is pressed and the vehicle is not in reverse. Inform customers this condition is considered normal operation and does not affect vehicle durability because the full rear view camera image can only be shown when…
• 10245357Nov 14, 2023Equipment. Some 2021-2023 Ford and Lincoln vehicles equipped with SYNC 4 may exhibit the navigation feature in the center display screen only displaying imperial (feet and miles) units and not being able to change to metric (meters and kilometers) units. This may be due to the software level of the SYNC module (APIM). To correct this condition, follow the Service Procedure to update the APIM to the latest software level via a…
• 10245258Nov 9, 2023Transmission and drivetrain. Some 2019-2023 Edge/Nautilus and 2022-2023 Maverick vehicles equipped with all wheel drive (AWD) may exhibit chatter/shudder during low speed turning events. This may be due to fluid contamination in the rear drive unit (RDU). Drain and refill the RDU, refer to Workshop Manual Section (WSM) 205-02. Drive for 5 miles (8 km) in stop and go conditions with right and left turns and re-evaluate. If the issue is still…
• 10241982Aug 10, 2023Back-over prevention (rear camera). "Software Update 4 P4 for 2021- 2023 Nautilus vehicles is now available. Quality Improvements include: - Increase number of times the Backup startup password set-up pop-up is displayed after creating a Phone as a Key. - Improved Telematics Control Unit functionality. "

← All problems reported for the 2023 Lincoln Nautilus