2014 Mazda MAZDA6 Technical Service Bulletins

757 technical service bulletins (TSBs) are on record for the 2014 Mazda MAZDA6. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10059438Jun 14, 2013Vehicle speed control. Summary to be provided on a future date.
• 10097394Jun 4, 2013Equipment. Some customers may complain that the ambient temperature display is not accurate, or it takes too long for the display to show actual temperature. When you encounter a customer with this concern, first verify the condition when the customer noticed this symptom.
• 10097393Jun 4, 2013Equipment. Beginning with the newer models (cx-5 and mazda6), grip type front and rear stabilizer bushings (a) have been incorporated for noise prevention purposes. If any type of grease or lubrication is applied to the bushings, it may create noise due to bushing slippage (cx-5 front bushings shown below).
• 10059475Jun 4, 2013Equipment. Summary to be provided on a future date.
• 10097383May 24, 2013Equipment. Some customers may complain of a check engine light and a/t warning light on when starting the engine. At the same time, an engine inspection required message is displayed on the lcd. Dtc p0722:00 is stored in the transmission control module (tcm) memory. •dtc p0722:00 (open circuit in output speed shaft circuit)the tcm control logic has been changed to eliminate this concern.
• 10059501May 24, 2013Electrical system. Summary to be provided on a future date.
• 10097385May 7, 2013Equipment. The navigation system support for diagnostics, parts authorization, and parts exchange require contacting the proper source.•tomtom navigation help desk at 866-486-6866 from 7am-11pm (m-f) and 9am-8pm (sat) eastern stan-dard time.note:one of the first steps for troubleshooting the navigation system is for the customer to call tomtom. If the tomtom call center cannot solve the customer’s problem, they will provide a…
• 10060489May 7, 2013Equipment. Summary to be provided on a future date.
• 10097387May 3, 2013Visibility (wipers, defrost, mirrors). Some customers may experience a water leak from the sunroof after washing the vehicle with a high-pressure car wash system. High pressure water from the car wash may drip from the drip rail and leak into the cabin.
• 10097375Apr 17, 2013Equipment. Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. Mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner’s manual. Services performed outside of mazda’s factory scheduled maintenance are not recommended. These services are unnecessary and create unneeded expenses for your customers.
• 10097374Apr 17, 2013Equipment. On certain subject vehicles, the malfunction indicator light (mil) may illuminate with dtc p0126:00 (thermostat stuck open) stored in the powertrain control module (pcm) memory.
• 10059434Apr 17, 2013Transmission and drivetrain. Summary to be provided on a future date.
• 10097379Apr 2, 2013Equipment. On certain subject vehicles, the malfunction indicator light (mil) may illuminate with dtc p0126:00 (thermostat stuck open) stored in the powertrain control module (pcm) memory.
• 10059433Apr 2, 2013Transmission and drivetrain. Summary to be provided on a future date.
• 10097336Mar 28, 2013Equipment. Some vehicles may exhibit a clicking type noise when the trunk lid is fully opened or just before the fully open position. The twisting motion of the trunk lid balance springs (a) may cause the clip fixing the balance springs to move and scrape against the rear package tray panel.
• 10060462Mar 28, 2013Latches, locks and linkages. Summary to be provided on a future date.
• 10097339Mar 21, 2013Equipment. Some vehicles may exhibit a rattle type noise from the passenger side dashboard when driving on a rough road. This noise may be caused by the passenger-side air bag module bracket (c) contacting the bracket holder (b) when driving on a rough road.
• 10060472Mar 21, 2013Equipment. Summary to be provided on a future date.
• 10097341Mar 13, 2013Latches, locks and linkages. Some vehicles may exhibit a clicking type noise when the trunk lid is fully opened or just before the fully open position. The twisting motion of the trunk lid balance springs (a) may cause the clip fixing the balance springs to move and scrape against the rear package tray panel.
• 10060463Mar 13, 2013Body and structure. Summary to be provided on a future date.
• 10097343Mar 11, 2013Equipment. This service bulletin provides information regarding the proper use of the driver’s floor mat to avoid any poten-tial interference with the foot pedals. The following are possible causes of floor mat interference, which can be avoided with proper usage.•floor mat moves forward due to improper installation.•inappropriate floor mat (such as aftermarket, non-factory-equipped, or non-genuine) is used.•floor mat is…
• 10052155Mar 11, 2013Equipment. Mazda: on some vehicles, to avoid potential interference of foot placed on pedals, information is provided regarding proper use, and placement, of driver's floor mat. Various models and model years.
• 10097369Mar 4, 2013Equipment. When dealing with customer complaints of excessive condensation and/or water within the headlamp unit, first determine if all the bulb sockets are present and correctly installed. In most cases you will find that the bulb seal no. 1 (a) or hid bulb seal no. 1 (b) and bulb seal no.
• 10097366Mar 4, 2013Transmission and drivetrain. The new skyactiv-drive fw6a-el at uses “automatic transmission fluid (atf) type: fz”. Only use “atf-fz” to fill or top off the fluid level. Atf-fz is specially designed for use in the skyactiv-drive series at. It is a low viscosity formula with less friction for better fuel economy.note:atf-fz is colored blue for easy identification.to check the fluid level, remove the bolt, then remove the dipstick. The dipstick…
• 10059498Mar 4, 2013Transmission and drivetrain. Summary to be provided on a future date.
• 10052160Mar 4, 2013Exterior lighting. Mazda: on various model years and model vehicles, the headlamp assembly would have excessive condensation or water within and should be checked and replaced, if necessary for correct installation.
• 10097370Mar 1, 2013Equipment. On certain subject vehicles, the malfunction indicator light (mil) may illuminate with dtc p0126:00 (thermostat stuck open) stored in the powertrain control module (pcm) memory.
• 10059432Mar 1, 2013Transmission and drivetrain. Summary to be provided on a future date.
• 10097318Feb 26, 2013Equipment. This service bulletin illustrates the conditions when a tpms warning light may illuminate, why it illuminated and how to properly initialize the system.the tire pressure monitoring system (tpms) monitors the tire pressure of all four tires indirectly using the data sent from the abs wheel speed sensors.
• 10059464Feb 26, 2013Equipment. Summary to be provided on a future date.
• 10097320Feb 19, 2013Steering. Some customers may complain that the steering wheel is off center more than 3° even when driving straight on a flat road.
• 10097324Feb 13, 2013Engine. Some customers may complain about an unusual noise coming from the engine compartment for about 20 sec-onds after a cold engine start. This noise is a normal engine operation for improved exhaust gas emissions. The noise does not indicate a malfunction.
• 10059430Feb 13, 2013Engine. Summary to be provided on a future date.
• 10097326Feb 6, 2013Equipment. This service bulletin illustrates the conditions when a tpms warning light may illuminate, why it illuminated and how to properly initialize the system.the tire pressure monitoring system (tpms) monitors the tire pressure of all four tires indirectly using the data sent from the abs wheel speed sensors.
• 10059463Feb 6, 2013Equipment. Summary to be provided on a future date.
• 10097283Jan 16, 2013Engine. Some vehicles may experience mil illumination with dtc p2610 (instrument cluster internal engine off timer performance problem) stored in memory after engine start and room fuse 15a (a) removed.
• 10059419Jan 16, 2013Electrical system. Summary to be provided on a future date.
• 10059418Jan 16, 2013Electrical system. Summary to be provided on a future date.
• 10097295Jan 15, 2013Equipment. Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. Mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner’s manual. Services performed outside of mazda’s factory scheduled maintenance are not recommended. These services are unnecessary and create unneeded expenses for your customers.
• 10097300Jan 14, 2013Equipment. Some customers may complain of signs of oil on the struts or shock absorbers. In most cases the oil that is present is normal, and a result of the oil that remains on the shaft during the normal sweeping process of the shaft seal. Follow the inspection guidelines to determine if the condition is a result of the normal sweeping process or a failure of the shaft seal.
• 10097302Jan 7, 2013Equipment. Some vehicles may experience mil illumination with dtc p2610 (instrument cluster internal engine off timer performance problem) stored in memory after engine start and room fuse 15a (a) removed.
• 10097941Dec 21, 2012Exterior lighting. Some customers may complain of condensation/fog inside the front or rear combination lights. The recent new models have been fitted with a clear lens which can cause the symptom to be more noticeable, however, it does not affect the performance of the light. This condensation/fog is a natural henomenon that occurs when there is a fairly large temperature difference between the inside and the outside of the light…
• 10097942Dec 19, 2012Equipment. Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. Mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner’s manual. Services performed outside of mazda’s factory scheduled maintenance are not recommended. These services are unnecessary and create unneeded expenses for your customers.
• 10059870Dec 19, 2012Engine, Equipment. Summary to be provided on a future date.
• 10097948Dec 14, 2012Tires. This service bulletin illustrates the conditions when a tpms warning light may illuminate, why it illuminated and how to properly initialize the system. The tire pressure monitoring system (tpms) monitors the tire pressure of all four tires indirectly using the data sent from the abs wheel speed sensors.
• 10097946Dec 14, 2012Equipment. In support of the new 2014 mazda6 and the 2014 cx-5, mazda will ship to all dealers one (1) new special service tool (sst). The sst will be shipped automatically by mazda’s tool vendor, spx during january 2013. The following sst is the latest addition to the mazda required tool (mrt) list.
• 10075776Dec 14, 2012Equipment. Summary to be provided on a future date.
• 10061490Dec 14, 2012Equipment. Summary to be provided on a future date.
• 10059466Dec 14, 2012Electrical system. Summary to be provided on a future date.
• 10097950Dec 11, 2012Tires. Customer complaints have been reported where the tpms warning light is unnecessarily illuminated because the tpms initialization was not performed correctly before customer delivery.

← All problems reported for the 2014 Mazda MAZDA6