2006 Mercedes-Benz CLS550 Technical Service Bulletins

69 technical service bulletins (TSBs) are on record for the 2006 Mercedes-Benz CLS550. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 11038186Sep 22, 2026Brakes. Complaint Repeat workshop visit for vehicle vibration while braking from 60MPH. NOTE: Although the symptom is similar to a tire or wheel vibration, it is usually readily noticeable that it is distinctly different if it happens at all times or only while braking. Cause Although the cause of the vibration is most likely due to excessive lateral runout on the rotor or hub/wheel bearing, the system as a whole needs to…
• 11038217Sep 14, 2026Body and structure. Complaint Clanking noise from the area of the speakers in the doors. Cause Under analysis. Remedy To narrow down the cause, first of all remove the door trim. • If the noise continues to occur even with the door trim removed, then continue the diagnosis working towards the speaker and if necessary, create a TIPS case with an informative video as an attachment.
• 11036101Aug 6, 2026Body and structure. Complaint Clanking noise from the area of the speakers in the doors. Cause Under analysis. Remedy To narrow down the cause, first of all remove the door trim. • If the noise continues to occur even with the door trim removed, then continue the diagnosis working towards the speaker and if necessary, create a TIPS case with an informative video as an attachment.
• 11035005Jul 14, 2026Transmission and drivetrain. Single throttle lift-off clunking noise from the side shaft when moving off (audible at the outboard end). The noise is heard once in each instance when changing direction of travel. Note: Sound file in attachment Cause If the complaint is eliminated by experimentally loosening the outboard collar nut (by 1 turn), the problem is due to cracking of the microweld between the wheel bearing inner race and the joint…
• 11032875May 19, 2026Visibility (wipers, defrost, mirrors). Complaint There are several types of complaint about noises or poor windshield wiper wiping performance: A: Wiper blades squeaking, chattering, shuddering B: The windshield is not wiped completely (streaking) C: During the downward movement water is pulled back onto the windshield from the A-pillar (Figure 1) D: After windshield cleaning, water keeps spraying onto the windshield for several wipe cycles (Figure 2)…
• 11031580Apr 16, 2026Exterior lighting. Complaint Headlamp, front fog lamp leaky or fogged. Cause Fogging of the headlamps is a natural phenomenon, which can occur under certain climatic conditions. It does not lead to any technical impairment of the headlamp. If a pressure compensation diaphragm is fitted in the housing cover, then the lamp unit is a "closed system". Remedy Headlamp: Remedy 1 Clearing fogged/condensed LED headlamps: 1.
• 11029959Mar 9, 2026Exterior lighting. Complaint Headlamp, front fog lamp leaky or fogged Cause Fogging of the headlamps is a natural phenomenon, which can occur under certain climatic conditions. It does not lead to any technical impairment of the headlamp. If a pressure compensation diaphragm is fitted in the housing cover, then the lamp unit is a "closed system". Remedy Headlamp: Remedy 1 Clearing fogged/condensed LED headlamps: 1.
• 11019018May 21, 2025Transmission and drivetrain. Complaint Single throttle lift-off clunking noise from the side shaft when moving off (audible at the outboard end). The clunk is heard once when changing from forward to reverse (and vice versa). Note: Sound file in attachment Cause If the complaint is eliminated by experimentally loosening the outboard collar nut (by 1 turn), the problem is due to micromovement in the connection between the wheel bearing inner…
• 11017500Apr 28, 2025Exterior lighting. Complaint Headlamps leaking or fogged Cause The fogging of the headlamp is a natural phenomenon which can occur under certain climatic conditions. In contrast to a leaky headlamp, physical fogging does not result in a technical impairment of the headlamp. A leak test must be performed to determine if physical fogging exists or if the headlamp is leaky. Remedy Check for external damage: You can identify a damaged…
• 11017496Apr 28, 2025Exterior lighting. Complaint Headlamp, front fog lamp leaky or fogged Cause Fogging of the headlamps is a natural phenomenon, which can occur under certain climatic conditions. It does not lead to any technical impairment of the headlamp. Remedy NOTE: If a pressure compensation diaphragm is fitted in the housing cover, then the lamp unit is a "closed system". Headlamp: Remedy 1 Clearing fogged/condensed LED headlamps and LED rear…
• 11017039Apr 1, 2025Engine. Complaint Vehicle with atypical reduced heat output. Cause Silicate granulate may have escaped from a damaged bag in the expansion reservoir (not visible), reducing the coolant flow in the heater heat exchanger (see picture). Remedy With the aforementioned complaint, make sure that the cooling circuit is inspected for silicate residues after all standard tests are completed. The silicate residues tend to accumulate…
• 11015640Mar 5, 2025Electrical system. Complaint During a phone call, the called party has difficulty understanding/cannot understand the driver, or interference/background noises are audible to the called party during a call. It becomes increasingly difficult to understand as the speed rises. Cause A. Seating of the microphones in the headliner. Side edges are covered by the textile cover (see picture "1") B. Assembly of microphones (B25/20 or B25/21)…
• 11013192Jan 24, 2025Body and structure. Complaint Fuel door may require several attempts to open. Please note that if the complaint "Fuel filler flap not opening" occurs, it is important to check the fuel filler flap before replacing the central locking actuator. For gasoline hybrid vehicles where the fuel filler flap fails to open or does so but slowly, observe the document "Fuel filler flap fails to open or does so but slowly on plug-in HYBRID gasoline…
• 11013298Jan 16, 2025Transmission and drivetrain. Complaint Single throttle lift-off clunking noise from the side shaft when moving off (audible at the outboard end). The clunk is heard once when changing from forward to reverse (and vice versa). Cause If the complaint is eliminated by experimentally loosening the outboard collar nut (by 1 turn), the problem is due to micromovement in the connection between the wheel bearing inner race and the joint housing of the…
• 11013332Jan 15, 2025Transmission and drivetrain. Complaint Single throttle lift-off clunking noise from the side shaft when moving off (audible at the outboard end). The noise is heard once in each instance when changing direction of travel. Note: Sound file in attachment Cause If the complaint is eliminated by experimentally loosening the outboard collar nut (by 1 turn), the problem is due to cracking of the microweld between the wheel bearing inner race and the…
• 11009122Oct 23, 2024Visibility (wipers, defrost, mirrors), Body and structure. Complaint Washer fluid system leaks Cause Various possible causes: 1. Washer fluid reservoir itself. 2. Seal on washer fluid pump/washer fluid reservoir. 3. Washer fluid pump. 3.1. Distributor housing leaks. 3.2. Pump fitting leaks. 3.3. Washer fluid hose cannot be snapped into place on pump fitting. 3.4. Washer fluid hose will not stay on pump fitting, although connector OK. 4. Washer fluid line. 4.1 Connector…
• 11008091Sep 28, 2024Electrical system. Complaint During a phone call, the called party has difficulty understanding/cannot understand the driver, or interference/background noises are audible to the called party during a call. It becomes increasingly difficult to understand as the speed rises. Cause A. Seating of the microphones in the headliner. Side edges are covered by the textile cover (see picture "1") B. Assembly of microphones (B25/20 or B25/21)…
• 11007974Sep 21, 2024Exterior lighting. Complaint Headlamps leaking or fogged Cause The fogging of the headlamp is a natural phenomenon which can occur under certain climatic conditions. In contrast to a leaky headlamp, physical fogging does not result in a technical impairment of the headlamp. A leak test must be performed to determine if physical fogging exists or if the headlamp is leaky. Remedy In advance, observe LI82.10-P-078301 "Headlamps or Front…
• 11007753Sep 10, 2024Exterior lighting. Complaint Headlamp or front fog lamp leaky or fogged Cause Fogging of the headlamps is a natural phenomenon, which can occur under certain climatic conditions. It does not lead to any technical impairment of the headlamp. Headlamps comply with all applicable standards. If a pressure compensation diaphragm is fitted in the housing cover, then the lamp unit is a "closed system". Remedy Headlamp: Remedy 1 Clearing…
• 11005294Jul 23, 2024Exterior lighting. Complaint Rear lamps fogged up/not leaktight. Cause Fogging of the rear lamps is a natural phenomenon, which can occur under certain climatic conditions. This does not lead to any technical impairment of the rear lamps. Remedy Rear lamp: Remedy 1: Clearing fogged/condensed rear lamps: 1. Drive the vehicle into the workshop (temperature higher than +18 °C/+64.4 °F) Note: Do not wash the vehicle or subject it to…
• 10252770Mar 12, 2024Body and structure. As previously reported, to enhance the satisfaction of our customers, avoid further costs of litigation and return focus to its core businesses, Mercedes-Benz USA, LLC (MBUSA) has entered into a Settlement regarding claims relating to allegations that the 590 Mars Red paint available as an original, exterior color option for certain models of Mercedes-Benz vehicles may experience peeling, flaking, or bubbling of…
• 10248162Dec 4, 2023Seats. Crease formation on genuine leather seat covers in vehicles with low mileage • Objects left on the seats for extended periods of time (pressure marks). • Objects wedged between the seat backrest and seat cushion (e.g. seat belt buckle). • Light initial creases due to vehicle handling. • Light creases in the outer covers originating from the production process (missing finish). Heat treatment of…
• 10186141Dec 10, 2020Electrical system. NTG5.5: Incorrect time shown on instrument cluster, COMAND display, and analog clock
• 10186135Dec 9, 2020Brakes, Electronic stability control. If the customer brakes sharply from a speed of > 30mph, without ABS intervention, there is a single cracking noise from the area of the ESP hydraulic unit
• 10160730Apr 25, 2019Visibility (wipers, defrost, mirrors), Equipment. Window lifter inoperative
• 10160625Apr 5, 2019Suspension. Thumping noises from rear axle shock absorber
• 10155128Feb 1, 2019Body and structure. Thumping noises from rear axle damper
• 10155126Jan 30, 2019Electrical system. Model series 257: In the Edition 1, the Welcome graphic is not displayed in the instrument cluster with the specific Edition animation.
• 10154023Jan 25, 2019Brakes. ESP, BAS, PRE-SAFE - Fault message in instrument cluster
• 10154018Jan 25, 2019Engine, Brakes. ESP, BAS, PRE-SAFE - Fault message in instrument cluster
• 11031585Aug 17, 2018Brakes. The warranty on the SBC Hydraulic Unit for MY 2003-2006 Model 211, MY 2006 Model 219, and Model Year 2003-2012 Model 230 was extended from the original 4 years/50,000 miles to 25 years with no mileage limitation. The SBC Hydraulic Unit extended warranty applies to all conditions that justify the replacement of the SBC Hydraulic Unit and specific listed components under the standard New Vehicle Limited Warranty…
• 10151959Jul 23, 2018Seat belts. Seat belt extender toothed rack sluggish or makes noises
• 10151941Jul 12, 2018Equipment. Inductive charging: iPhone is not reliably charged
• 10151926Jul 3, 2018Electrical system, Lane departure, Brakes. Warnings without obvious cause from front parking sensors in vehicles with AMG Styling Package (SA code 772)
• 10144131May 11, 2018Body and structure. Trunk lid cannot be closed
• 10158329Oct 9, 2017Engine. Oil in engine wiring harness
• 10205147Nov 14, 2016Engine cooling. Ticking or pulsing noise from high-pressure pump and/or fuel injectors.
• 11031629Oct 30, 2015Engine. To enhance the satisfaction of our customers, avoid further costs of litigation and return focus to its core businesses, Mercedes-Benz USA, LLC (MBUSA) entered into a settlement regarding claims relating to the replacement of sintered steel balance shaft sprockets and idle gears in certain—but not all—2005-2007 model year vehicles with M272 & M273 engines.
• 10058130Jun 10, 2015Fuel system. Mercedes-benz model years 2003-2009 model 211, model years 2006-2011 model 219: fuel odor in the area of the fuel tank . Warranty extension has been issued on fuel tank components for certain vehicles. *lj updated 10/6/15.
• 11031595Jan 10, 2015Fuel system. In our continuing efforts to enhance the satisfaction of our customers, Mercedes-Benz USA, LLC (MBUSA) has decided to extend the warranty for certain fuel tank components in certain Mercedes-Benz vehicles. Which Vehicles:  gasoline-fueled, non-PZEV certified ( i.e.
• 10135628Oct 14, 2014Equipment. iPhone mobile phone: Various complaints after software update to iOS8
• 10166092Jul 12, 2014Seats. Dynamic seat control is not functioning correctly and/or air cushions do not inflate fully.
• 10166103Jul 10, 2014Seats. The controls on the partially electric seat adjustment switch stick or are loose or broken.
• 10166099Jul 10, 2014Seats. Pneumatic comfort systems with insufficient performance, entirely inoperative or leaky.
• 10136016Jun 12, 2014Body and structure. Clearcoat peeling / flaking / bubbling
• 10167525Mar 3, 2014Equipment. Apple products (iPhone or iPod) are not charged via the serial USB interface of the COMAND Online control unit (A40/3) in the stowage compartment of the center console.
• 10167510Feb 28, 2014Transmission and drivetrain, Electrical system. The vehicle cannot be started The vehicle may start by itself shortly after the startup attempt with a delay, as the relay can be late closing. and/or The gear selection is displayed, but no gear is engaged. Gear selection is not possible. and/or Rear window wiper inoperative. and/or Various fault codes concerning disrupted communication paths are stored and/or the corresponding control units are not displayed in…
• 10167007Feb 25, 2014Electrical system. Engine diagnosis warning lamp active. Fault code 20BE1B and/or 20BD1B (The heating element of the AdBlue tank has a malfunction) is logged in the Blue-Tec control unit.
• 10167000Feb 18, 2014Steering. Surface damage on steering wheel trim
• 10167006Feb 12, 2014Electrical system. Engine diagnosis warning lamp active. Fault code 20BE1B and/or 20BD1B (The heating element of the AdBlue tank has a malfunction) is logged in the Blue-Tec control unit.

← All problems reported for the 2006 Mercedes-Benz CLS550