2007 Mercedes-Benz S600 Technical Service Bulletins

94 technical service bulletins (TSBs) are on record for the 2007 Mercedes-Benz S600. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10166976Feb 3, 2014Equipment. Message in instrument cluster "DISTRONIC PLUSCurrently Unavailable - See Owner's Manual"
• 10166991Jan 31, 2014Suspension. Creaking noises from the area of the air suspension strut on the front axle when driving over bumps with the steering turned. Topic only reported from outer wheel until now.
• 10167554Jul 10, 2013Engine cooling. Engine diagnosis warning lamp activated. Fault code P045600 "Very fine leak" or P044200 "Fine leak" stored in engine control unit.
• 10167572Jul 3, 2013Electrical system. If it is necessary to replace an HV battery, the return will only be accepted with the filled-out ?Analysis Sheet for Transportability of High-Voltage Batteries Form? accompanied by: , the removed part, the quick test printout, the BMS control unit log printout, the repair documentation and with all required documentation listed in Section E of the Form.
• 10037918Oct 2, 2012Brakes. Mercedes-benz: esp malfunction or bas malfunction light shows up in the instrument panel because of a wheel speed sensor problem. *rm updated 2/15/13.
• 10028685May 6, 2011Suspension. Mercedes: vehicle does not lower and/or airmatic visit workshop display in instrument cluster. Model 220. Model years unknown. *pe updated 7/13/11.
• 10037917Jan 20, 2011Engine cooling. Mercedes-benze: there is a leakage at the press-fit sleeve of a pulsation damper. This is caused by high heat entering the system or tension in the line.
• 10037986Dec 8, 2010Electrical system, Equipment. Mercedes benz- when doing a software update the update fails and the tuner goes to boot mode.
• 10037408Nov 19, 2010Suspension. Mercedes-benz: shock absorber procedure.
• 10034151Jun 7, 2010Engine cooling, Electrical system. Mercedes: engine start/stop, engine starts up at random or 12 v on board electrical system voltage too low. The resistance of the electrical line from dc/dc converter control unit n83/1 to ground point w3/9 is too high in the dc/dc converter control unit.
• 10036741May 17, 2010Electrical system. Mercedes: mounting bolt of hv connection to hv battery broken during installation. The mounting bolt shears off when retightened at the hv connection to the hv battery. Excessive stress on mounting bolt due to failure to comply with tightening torque of 5nm. Models 221.095/221.195(hybrid). No model years listed.
• 10034609Feb 18, 2010Steering. Mercedes: rattling or dull knocking noise coming from the area of the steering system when driving over rough road.
• 10033070Dec 16, 2009Engine cooling, Electrical system. Xentry (mercedes): engine warning lamp is currently on or was on and a delay fault of the camshaft adjust to current or stored in the engine control unit. Models 171, 203, 209, 211, 219, 221, 216, 230, 164, 251, and 403. No model years listed.
• 10032727Sep 17, 2009Suspension. Mercedes: following fault codes are entered in the control unit and displayed-fc5320 drain valve:open circuit or insufficient valve current in models series 211, 219; fc5260 drain valve open circuit or insufficient valve current in model 221; fc5250 drain open circuit or insufficient valve current in model series 251, 164. Defective connecting cables to drain valve at airmatic compressor. This results in the…
• 10032724Sep 8, 2009Seats. Daimler: the weight sensing system (wss) or the right front seat adjuster with wss which necessitate the replacement of the seat adjuster. The seat adjuster with integrated wss sensors (pen system) installed up is no longer available up to model year 09. Only the new generation of wss system (bladder system) is now available as in model 216. Conversion to new generation of wss system.
• 10030929Jun 15, 2009Brakes. Mercedes: corrosion protection coatings for brake components and hardware may be damaged and or stripped away if highly concentrated acid based cleaners are used. Once the corrosion protection is damaged or removed the brake components and or hardware can begin to corrode. Include all models and model years.
• 10028686May 6, 2009Electrical system. Mercedes: air matic visit workshop displayed within instrument cluster. Models 164, 211, 219, 221 and 251. Included 4matic, amg (compressor) amg, bluetec and wagon. Model years unknown. *pe updated 9/18/09.
• 10028604May 1, 2009Tires. Mercedes vehicles: check for spare tire well cover, install if necessary. The spare tire well cover may not have been installed on subject vehicles. Model 221, model years 2007 and 2008. *pe updated 9/18/09.
• 10016670May 1, 2009Fuel system. Mercedes: the fuel level indicated in the instrument cluster does not match the actual fill level. This may be caused by a fault in the fuel level sensor function chain: hydraulic and electrical lines and their connections, rear sam or instrument cluster. *tt updated 2/23/09. *pe updated 9/18/09. Model years unknown.
• 10016687Mar 31, 2009Electrical system. Abc visit workshop displayed in instrument cluster and hydraulic fluid leakage. *tt updated 5/14/09. Models 215, 220 and 230. Model years unknown.
• 10028684Mar 20, 2009Brakes. Mercedes: esp service required displayed in instrument cluster. Also includes 4matics, bi turbos and kompressors. Models 215 and 220. Model years unknown.
• 10028587Feb 27, 2009Steering. Mercedes: leaks at steering gear control head connection to high or low pressure lines or leaks at internal steering lines of control head connection to steering gear housing. Models 171, 203, 204, 209, 211, 215, 216, 219, 220, 221, and 230. Model years unknown.
• 10029504Feb 1, 2009Transmission and drivetrain. Mercedes: replace transfer case on affected vehicles optimized transfer cases will reduce vibrations when cornering or when parking. Models 203, 211, 220.
• 10028665Jan 7, 2009Electrical system. Mercedes: warning message right low beam- check bulb; or left low beam-check bulb in instrument cluster. Due to the fact that the xenon burner may not be ignited on first attempt due to tolerances in ignition voltage. Model years unknown.
• 10028627Dec 15, 2008Suspension, Electrical system, Engine cooling. Mercedes: display in instrument cluster "air suspension" or "abc service required" is displayed in the instrument cluster, the engine wiring harness may have been damaged by the wiper linkage. Models 215.3 and 220. Model years unknown.
• 10027905Oct 1, 2008Transmission and drivetrain. Mercedes benz: check auxiliary transmission oil cooler thermostat for leaks, replace o rings if necessary.
• 10028026Aug 1, 2008Engine cooling. Mercedes: replace v belt upper guide pulley. The v belt upper guide pulley optimized for noise reduction is available. The dealer will replace upper guide pulley at the next workshop visit.
• 10021246Aug 1, 2008Other or unknown. Install software for navigation system. *kb updated 3/5/09.
• 10025901Jun 2, 2008Steering. Mercedes-benz: multifunction steering wheel being inoperative, this may be due to the electronics of the steering wheel being defective.
• 10025664Mar 26, 2008Brakes. Park assist does not function. All model 221 (221.171, 176, 179, 186, 177) vehicles, equipped with sa code 233 (distronic plus) and 806 (modification year 2006). Model years unknown.
• 10028626Feb 22, 2008Suspension. Mercedes: the vehicle's suspension level randomly lowering while driving and/or rapid sporadic level changes shortly after stopping the vehicle, replace the body acceleration sensors. Models 215.3, 220, and 230. Model years unknown.
• 10023782Dec 1, 2007Electrical system. Models cl600, cl65 & s600, s65 with engine 275 my2007 -- check engine control module software and update if necessary.
• 10023779Nov 1, 2007Equipment. Model s550, s600, s65, s63 my 2007 - check tire inflation pressure label and replace if necessary.
• 10023494Oct 26, 2007Brakes. Mercedes-benz - parking brake cannot be operated. Models s63, s65, s550, s600. Model year unknown.
• 10023376Sep 28, 2007Latches, locks and linkages. Mercedes-benz - model s63, s65, s550, s600 - outside door handle sticks in pulled position. Model year unknown.
• 10023373Sep 1, 2007Seats. Mercedes-benz - install software for dynamic and/or multicontour seat control modules.
• 10023374Aug 1, 2007Seats. Mercedes-benz - update software for dynamic/multi-contour seat control modules.
• 10022555Jun 1, 2007Electrical system. Check starter wiring harness routing and re-route if necessary (m273 engine).
• 10021576Apr 1, 2007Transmission and drivetrain. Replace transmission pilot bushing at electrohydraulic control module.
• 10022322Dec 1, 2006Engine cooling. Replace abc high-pressure line; inspect coolant hose and replace if necessary.
• 10021243Sep 1, 2006Equipment. Replace air conditioning condenser service valve.
• 10021244Aug 1, 2006Other or unknown. Install software for navigation system.
• 10020284May 1, 2006Engine cooling. Check engine control unit software and update if necessary.
• 10020285Apr 1, 2006Body and structure. The rocker panel water drain grommets may not drain water properly.

← All problems reported for the 2007 Mercedes-Benz S600