2014 MINI Cooper Technical Service Bulletins

431 technical service bulletins (TSBs) are on record for the 2014 MINI Cooper. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10143573May 1, 2018Engine, Transmission and drivetrain. JCW ENGINE TUNING KIT - ENGINE LOSS OF POWER IN STOP-AND-GO DRIVING: The engine may lose power if the vehicle is decelerated, in gear, to a near stop and then accelerated again.
• 10138422Apr 1, 2018Equipment. HEAD UNIT HIGH 2 RESET WHILE BLUETOOTH IS CONNECTED: The following event may cause an unexpected reset of the Head Unit High 2 (NBT EVO) when:
• 10138421Apr 1, 2018Equipment, Electrical system. IPHONE: CALL LIST MISSING AFTER RESTART: The call list from iPhone 8 or iPhone X, that is displayed, is missing after cycling the ignition.
• 10138420Apr 1, 2018Electrical system, Equipment. CHECK CONTROL STATES REMOTE KEY IS MISSING WHEN THE KEY IS LOCATED IN THE VEHICLE: Only vehicles that have been programmed with ISTA 4.10.1x and I-level 18-03-511 or 18-03-512.
• 10138419Apr 1, 2018Electrical system. INSTRUMENT CLUSTER OUTSIDE TEMPERATURE DISPLAY IMPLAUSIBLE: In the Instrument Cluster (Kombi) display you may observe an implausible outside temperature reading.
• 10138418Apr 1, 2018Electrical system, Equipment. HORN DOES NOT WORK: Horn operation is difficult or impossible.
• 10138416Apr 1, 2018Body and structure. WATER LEAK IN REAR HATCH: Water is found in trunk area.
• 10138414Apr 1, 2018Engine cooling. DME FAULT CODE 1B8004 ENVIRONMENTAL AIR CATALYST (EAC) SENSOR: During a service or vehicle test, the DME has the following fault code stored but the Malfunction Indicator Lamp (MIL) light is not illuminated:
• 10136310Mar 1, 2018Equipment, Electrical system. NBT-EVO NEXT GENERATION NAVIGATION PROFESSIONAL: HEAD UNIT CANNOT BE SWAPPED BETWEEN VEHICLES FOR TESTING. COMPONENT PROTECTION ACTIVE: If either the NBT-EVO head unit or Body Domain Controller (BDC) are swapped into a different vehicle they will cause the head unit NBT-EVO to enter a locked mode once it recognizes a different VIN.
• 10136309Mar 1, 2018Electrical system. SERVICE ACTION: REPLACE THE LIGHT ELECTRONICS CONTROL MODULES ON BOTH SIDES: The FLE (Front Light Electronic) module on both sides malfunctions.
• 10136308Mar 1, 2018Electrical system. SERVICE ACTION: REPLACE THE LEFT FRONT LIGHT ELECTRONICS CONTROL MODULE: The FLE_L (Front Light Electronic _ Left) module - left side malfunctions.
• 10136005Mar 1, 2018Engine cooling. ROUGH RUNNING WITH VARIOUS VANOS FAULTS: The check engine light is illuminated and the vehicle may run rough.
• 10136003Mar 1, 2018Engine cooling, Back-over prevention (rear camera). NOISE COMING FROM OIL FILTER AREA AFTER A COLD START: repeating fizzing noise may be heard from the engine oil filter area after a cold start.
• 10136002Mar 1, 2018Engine cooling, Back-over prevention (rear camera). BUZZING NOISE FROM VALVETRONIC MOTOR BEFORE OR AFTER ENGINE OPERATION: Buzzing noise may be heard from the Valvetronic motor when the vehicle is unlocked, before the engine is started, or after engine is turned off.
• 10154765Feb 1, 2018Air bags. Airbag indicator light remains on after seat occupancy mat replacement.
• 10154761Feb 1, 2018Engine. ENGINE VIBRATIONS OR NOISE. One of the following complaints may be reported: The engine runs erratically; The engine causes vibrations when running; Grinding noise from the engine compartment when engine is running.
• 10135059Feb 1, 2018Engine cooling. BUZZING NOISE FROM VALVETRONIC MOTOR BEFORE OR AFTER ENGINE OPERATION: Buzzing noise may be heard from the Valvetronic motor when the vehicle is unlocked, before the engine is started, or after engine is turned off.
• 10135000Feb 1, 2018Equipment. Head unit high resets with connection of iphone 8, iphone 8 plus or iphone x
• 10134998Feb 1, 2018Fuel system. FUEL GAUGE ERRONEOUS DISPLAY: Vehicle runs out of fuel but the instrument cluster still displays fuel remaining in the tank.
• 10134996Feb 1, 2018Electrical system. HORN DOES NOT WORK: Horn operation is difficult or impossible.
• 10134994Feb 1, 2018Transmission and drivetrain. Aisin automatic transmisison: right side output shaft seal replacement
• 10142950Jan 1, 2018Equipment. NO AUDIO PLAYBACK AFTER REPLACING THE HEAD UNIT HIGH 2 (HU-H2): After replacing the Head Unit High (HU-H2) and performing ISTA4 programming there is no audio playback.
• 10142949Jan 1, 2018Engine cooling. CREAKING NOISE FROM THE LOWER ENGINE AREA: During load reversal or taking off from a stop there is a creaking or droning noise heard from the lower engine area
• 10142947Jan 1, 2018Electrical system. SERVICE ACTION: PROGRAM CONTROL UNITS (DME): DME software error may cause an erroneous overcurrent detection.
• 10142946Jan 1, 2018Engine cooling. FAULT 118002 - MIXTURE TOO RICH SETS DURING WINTER WITH COLD AMBIENT TEMPERATURES: The Service Engine Soon (MIL) light is on with the following fault stored in the DME.
• 10136750Dec 1, 2017Electrical system. TRUNK OPEN MESSAGE ON CLUSTER: Check Control Message (CCM) ÒTrunk OpenÓ message is displayed.
• 10136749Dec 1, 2017Body and structure. PAINT ON THE B-PILLAR IS SCRATCHED/DAMAGED: The paint finish on the B-pillar (above the door striker) is scratched due to the inner door cavity window seal.
• 10136747Dec 1, 2017Steering. EPS INTERMITTENT ASSIST FAILURE, FC 4823FA: The steering assistance fails after several, consecutive parking maneuvers or sustained hold at the end stop.
• 10136746Dec 1, 2017Engine cooling, Electrical system. THE ENGINE STARTER INTERMITTENTLY DOES NOT CRANK OVER: The engine will not start, either consistently or intermittently.
• 10136752Nov 1, 2017Electrical system. EMERGENCY START FUNCTION DOES NOT WORK WITH DEAD REMOTE BATTERY: Remote battery is dead.
• 10146776Sep 1, 2017Equipment. "NAVIGATION PRO (NBT EVO) MAP UPDATE NOT POSSIBLE, NAVIGATION DOES NOT START. A. Navigation system will not start at all or the ""Navigation system starts"" message is permanently displayed. B. While attempting to update the Navigation system's map, it will not update. Subfolder on internal Hard Disk Drive (HDD) is missing."
• 10146775Sep 1, 2017Equipment. AIR CONDITIONING COOLING IS INSUFFICIENT. * With option code SA 530 air conditioning or SA 534 Automatic air conditioning Produced from 2/1/2016 through 9/30/2016. * A/C system contains little or no A/C refrigerant. Contaminants under O-ring seals have allowed refrigerant loss.
• 10146774Sep 1, 2017Wheels. CAVITY PROTECTION WAX LEAKING OUT OF HOOD. Cavity protection applied to underside of hood is leaking out onto wheel arch trim and grille. Improper application of Cavity Protection Wax.
• 10146752Aug 1, 2017Equipment. Automatic Deactivation of Recirculation Mode. The customer states the recirculation display goes out, even though the recirculation button was switched on. CAUSE The automatic recirculation air deactivation feature was introduced in July 2012. Note: If the customer dislikes this feature, it can be deactivated by using the following steps.
• 10146751Aug 1, 2017Electrical system. ERRONEOUS SERVICE INCLUSIVE CBS DISPLAY. After pre-delivery check or after instrument cluster exchange, MINI Service Inclusive is displayed although the vehicle does not feature the optional Service Inclusive coverage. Instrument Cluster display error
• 10146749Aug 1, 2017Tires. CHECK CONTROL MESSAGE: TIRE PRESSURE MONITOR (RDCI) FAILURE. A Check Control Message states Tire Pressure Monitor (RDCi) has failed CAUSE Hardware failure in the remote control unit (FBD3 antenna).
• 10146687Aug 1, 2017Electrical system. SERVICE ACTION:PROGRAM CONTROL UNITS (DME). During certain driving situations, there could be an uncomfortable transition when slowing or decelerating and then reaccelerating. CAUSE Unfavorable DME software
• 10146727Jun 1, 2017Engine cooling. KNOCKING NOISE FROM THE ENGINE COMPARTMENT. There is a knocking noise coming from the engine compartment or the engine shakes during: z Engine start z When driving off from a stop z When applying brakes CAUSE Damage to the right side engine mount. The damage may be subtle (1st picture) or obvious (2nd picture). Inspect the right engine mount and replace if necessary.
• 10149273May 1, 2017Equipment. SPORADIC FAILURE OF DIFFERENT AUDIO CHANNELS. Intermittently, different speakers may be inoperative during an entire drive cycle until the vehicle enters sleep mode and the vehicle is restarted. Shut-down of output circuit(s) from pressure variations caused by door shutting during diagnostic self-test. After unlocking the vehicle the Harman/Kardon (HK) Amplifier goes into a speaker self-test mode.
• 10149272May 1, 2017Equipment. FOUL, MUSTY ODOR FROM HVAC: WET FOOTWELL CARPET This Service Information bulletin supersedes SI M64 01 16 dated September 2016 and SI M64 02 14 dated August 2016 are being combined to prevent duplication of effort and streamline the repair. The customer reports one, or both, of the following: ? Damp front foot-well carpet after long period of air conditioning use. ? A foul smell (musty, rotten, and vinegary) when…
• 10149271May 1, 2017Electrical system. HORN DOES NOT WORK. Horn operation is difficult or impossible. Horn may operate: with a delay after actuation only after pressing on switches very firmly. after repeated, forceful actuation. only when using one or two (of the four) switch contact points ? Only F54, F55, F56, F57: Dissimilar metal corrosion between horn switch contacts and airbag unit. All models: routing of the connecting wires on the steering…
• 10149270May 1, 2017Body and structure. CAVITY PROTECTION WAX LEAKING OUT OF HOOD. Cavity protection applied to underside of hood is leaking out onto wheel arch trim and grille. Improper application of Cavity Protection Wax
• 10149268May 1, 2017Body and structure. EDGE CORROSION IN THE DOOR JAMB AREA. Corrosion on inner door panels at the following holes and cavity openings: Door brake (1). Door wiring harness pass-thru (2).
• 10149266May 1, 2017Engine. "?Primarily when vehicle is at altitudes higher than 1500m above sea level, and engine is at operating temperature, the idle is sporadically elevated (up to approx. 1200 rpm). MIL indicator is illuminated. Fault code 1E0001 - ""Idle speed control: Speed too high"" is stored in DME. CAUSE DME software error The DME software improvements come in 2 steps 1. Primary improvements with I-level XXXX-17-03-50x. 2.
• 10146669Apr 1, 2017Equipment. LIST OF AVAILABLE FM RADIO STATIONS TEMPORARILY NOT AVAILABLE. As of 11/2015, all Entry-NAV/Media head units supplied in new vehicles were upgraded for improved noise characteristics and quality. As a part of this upgrade, the hardware updating the sender lists was changed from an "update after every diversity reception interruption or maximum of four minutes" configuration to "regular interval updates (every four…
• 10146664Apr 1, 2017Engine cooling. CREAKING NOISE WHEN CORNERING. A creaking noise is heard from the front end of the vehicle while cornering (predominantly left turns) under the following conditions: Driving In 1st or 2nd gear; While coasting or accelerating; with an Outside ambient temperature that is below 10C (50F); and After engine warm-up, the ambient temperature of engine compartment may exceed 10C (50F) even though the outside temperature is…
• 10146662Apr 1, 2017Transmission and drivetrain. ?SERVICE ACTION: PROGRAM CONTROL UNITS (DME). Due to an error in the OBD diagnostics of the DME software, a marginal catalytic convertor or post catalyst oxygen sensor may not be detected as faulty.
• 10146661Apr 1, 2017Engine. MIL IS ON WITH FAULT CF0486 STORED IN THE EGS MODULE. The Service Engine Soon (MIL) light is on. The following fault is stored in the AISIN EGS module: z CF0486: EGS,PT-CAN2: Line fault/electrical fault It is possible the following Check Control messages could be displayed: z Engine fault! Power loss (CCM ID 29) z Drive faulty! (CCM ID 419) - The transmission is in the emergency program and the engine is running…
• 10146620Mar 1, 2017Electrical system. ? COMFORT ACCESS LOCKING REQUIRES MULTIPLE BUTTON PRESSES . Locking vehicle with CA button requires two presses, with up to 3 second delay between presses. Body Domain Controller (BDC) software
• 10146619Mar 1, 2017Equipment. . INFORMATION Inform the customer that the introduction of these expanded frequencies by the wireless mobile providers may be influencing reception quality. MINI is currently working with the wireless mobile providers in order to improve the quality of reception and help alleviate the issues that are caused by the wireless mobile expanded frequencies. Once we have more information about this situation this service…

← All problems reported for the 2014 MINI Cooper