2015 Ram 1500 Technical Service Bulletins

590 technical service bulletins (TSBs) are on record for the 2015 Ram 1500. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10223855Sep 7, 2016Visibility (wipers, defrost, mirrors). Washer Fluid Level Sensor Prior to replacing this part due to "Low Washer Fluid" tell tale light on the dash and the washer fluid bottle is full, please perform the this inspection. Inspect the sensor for a fluid coating on the sensor pins. Orange colored rain repellant can cause this fluid build-up. Clean the pins, drain the reservoir, and fill with Mopar approved washer fluid. Check to determine if the issue has…
• 10223854Sep 7, 2016Engine cooling. Service - Four Piece Oil Pan Gasket All Cummins Equipped Vehicles ONLY - The replacement oil pan gasket can be a four piece gasket rather than a single piece gasket. This applies to Cummins 5.9L and 6.7L engines only. Installation: 1. Clean the oil pan T-joints.~ 2. Fill the T-joint between the pan rail/gear housing and pan rail/rear seal retainer with sealant. Use Mopar® Silicone Rubber Adhesive Sealant or…
• 10226283Aug 24, 2016Body and structure, Equipment. Center Console.
• 10224862Aug 24, 2016Equipment. Foil Patch If you are replacing the headliner for a 2014 or 2015 Ram 1500, you must also order patch kit PN 68315885AA to replace the foil patch for recall R47.
• 10130083Aug 24, 2016Body and structure. Foil Patch If you are replacing the headliner for a 2014 or 2015 Ram 1500, you must also order patch kit PN 68315885AA to replace the foil patch for recall R47.
• 10130082Aug 24, 2016Body and structure. Center Console If vehicle comes in for squeaking, clicking, or binding of the center console lid, verify the complaint by cycling the upper console lid. Check for a green dot sticker on the back of the console behind the rear panel by the hinge. ~ If the above complaint is verified and the console DOES NOT have a green dot sticker near the hinge (behind the back panel), order kit PN 68315574AA and install per the…
• 10217744Aug 19, 2016Body and structure. Tailgate Contacting Pickup Box Panel When Closing This bulletin involves adjusting the passenger side outer box flange. The customer may describe the tailgate making contact with the passenger side outer box panel.
• 10135120Aug 19, 2016Engine cooling. Tailgate Contacting Pickup Box Panel When Closing This bulletin involves adjusting the passenger side outer box flange. The customer may describe the tailgate making contact with the passenger side outer box panel.
• 10129035Aug 19, 2016Equipment. Tailgate Contacting Pickup Box Panel When Closing This bulletin involves adjusting the passenger side outer box flange. The customer may describe the tailgate making contact with the passenger side outer box panel.
• 10140210Aug 10, 2016Vehicle speed control. P/N 68111384AB: Inspect &Return: Switch - Speed Control You have been identified as either having stock, or have stock in transit to your dealership. Please return parts which have a pacakging date code of July 20th 2016. Reference pictures attached for suspect part identification. Please return parts backto your facing depot using Return Code 02, before 31 August, 2016.
• 10140209Aug 10, 2016Engine cooling, Engine. 05187880AC - Inspect and Return: Relay Assy - Heater Intake Air You have been identified as either having stock, or have stock in transit to your dealership. Please return suspect stock of part number 05187880AC. See attachments for identifying suspect stock. Please return suspect parts back to your facing depot using Return Code 02, before 31st August, 2016.
• 10140207Aug 10, 2016Exterior lighting. Inspect and Return: Lamp Assy - Tail Light Rt/L You have been identified as either having stock, or have stock in transit to your dealership. Please return suspect stock of following part numbers: 68110016AC, 68110016AD, 68110016AE, 68110017AD, 68236104AC, 68236105AB. See attachments for identifying suspect stock. Please return suspect parts back to your facing depot using Return Code 02, before 31 August, 2016.
• 10140206Aug 8, 2016Engine cooling. P/N 04573460 - Inspect &Return: Rocker Assy - Intake Valve RT You have been identified as either having stock, or have stock in transit to your dealership. Please return part number 04573460 which have a packaging date of 2016-06-13. Reference attached picture for reference. Please return suspect parts back to your facing depot using Return Code 02, before 29 August, 2016.
• 10140205Aug 6, 2016Equipment. 68103256AGReturn: Line Assy - A/C Suction and Liquid You have been identified as either having stock, or have stock in transit to your dealership. Please return stock of part number 68103256AG packaged before 2016/08/01. Please return suspect parts back to your facing depot using Return Code 02, before 29 August, 2016.
• 10140203Aug 5, 2016Latches, locks and linkages, Body and structure. 68160775AB: Inspect and Return: Switch - Outside Door Handle You have been identified as either having stock, or have stock in transit to your dealership. Please return suspect stock of part number 68160775AB. See attachments for identifying suspect stock. Please return suspect parts back to your facing depot using Return Code 02, before 26 August, 2016.
• 10221559Jul 27, 2016Body and structure. Tailgate controller If the vehicle is in for tailgate issue on all RAMs 2014, 2015, 2016 MY, FCA is looking to gather information prior to repairing the vehicle. Please contact Jim Smith via Cell Phone (248) 765-8972 If the dealership is within the Metro Detroit Area, Jim would like to analyze the vehicle in person prior to repair.
• 10136541Jul 27, 2016Body and structure. Tailgate controller If the vehicle is in for tailgate issue on all RAMs 2014, 2015, 2016 MY, FCA is looking to gather information prior to repairing the vehicle. Please contact Jim Smith via Cell Phone (248) 765-8972 If the dealership is within the Metro Detroit Area, Jim would like to analyze the vehicle in person prior to repair.
• 10121688Jul 20, 2016Fuel system, Engine cooling. TANK, Diesel Exhaust Fluid, Part Includes Temp Sensor and Level Sensor For DS and WK vehicles ONLY; If the urea tank is being replaced due to P249C or P203E on a 2014-2016 model year 3.0L Turbo Diesel (EXF) on DS or WK, please call Indra Djutrisno at cell (248) 892-3473. If no response is received within 15 minutes, please continue with repair.~
• 10121686Jul 20, 2016Equipment. Bumper Step Pad Customer may notice the center section of the step pad is not sitting flat. It will appear raised either left or right of center. Please photograph the condition, measure the gap between the bumper and step pad. Then contact Mihaela Colfescu via cell (248) 841-5736 with this information. We may want to have the whole bumper assembly returned for study. ~ If the dealership is within the Metro Detroit…
• 10121683Jul 20, 2016Engine cooling. 3.2L - 3.6L Cylinder Head Assy Multiple cylinder head replacement. If cylinder head is replaced on a vehicle more than 1 time for any reason, please call any of the following people.~ First: Ron Dallison ? Cell (248) 292-9510 [email protected] ~ Second: Joe Lovell - Cell (734) 309-6467 [email protected]~ If a response is not received within 15 mins, then proceed with the necessary repair.
• 10121649Jul 8, 2016Electrical system. RG3 RG4 RJ3 RJ4 Radio EnhancementsThis bulletin involves inspecting and if required, updating the radio software.A small number of customers may experience one or more of the following: · Blind Spot module beep or chime sound may be heard continuously (KL Only). · Radio may keep the CAN bus network awake, causing a battery drain.
• 10121658Jul 6, 2016Latches, locks and linkages, Seats. Rear seat fold latches If the rear seat is difficult to fold or binds, please contact Trevor Trudell at cell (248) 420-7340 before making any repair. If no response within 15 minutes please proceed with the repair.
• 10121656Jul 6, 2016Seats. Front Seat Adjuster Assemblies If the seat has a squeak or rattle, and it is reproducible, please call Trevor Trudell at cell (248) 420-7340 before any work is performed. If no response within 15 minutes please proceed with repair.
• 10121655Jul 6, 2016Brakes. Brake Pedal Sensor For DS, WD & WK bodies ONLY; Prior to replacing the brake sensor; Please call Salma Al Ryahi at cell (519) 992-7293. If you are unable to get a response within 15 minutes, please take a picture that shows the sensor side together with the plunger and continue with normal repair procedure.
• 10121654Jul 6, 2016Equipment, Visibility (wipers, defrost, mirrors). Actuator- A/C Heater Before replacing this actuator call Matt Sasina at cell (248) 464-4982. If no response in 15 minutes, continue with repair.
• 10218268Jun 22, 2016Electrical system, Brakes. Anti-Lock Brake Module (ABS) For 2015 and 2016 DS ONLY; Before replacing the ABS module, please call Brittany Potton at cell (248) 494-1087. If you don't receive response within 15 minutes, please continue with normal repair procedure.
• 10140135Jun 22, 2016Brakes, Electrical system. Anti-Lock Brake Module (ABS) For 2015 and 2016 DS ONLY; Before replacing the ABS module, please call Brittany Potton at cell (248) 494-1087. If you don't receive response within 15 minutes, please continue with normal repair procedure.
• 10080241Jun 22, 2016Brakes. "anti-lock brake module (abs) for 2015 and 2016 ds only; before replacing the abs module, please call brittany potton at cell (248) 494-1087. If you don't receive response within 15 minutes, please continue with normal repair procedure."
• 10140103Jun 17, 2016Equipment. You have been identified as either having stock, or have stock in transit to your dealership. Please return suspect stock of part number 68143886AA. See attachments for identifying suspect stock. Please return suspect parts back to your facing depot using Return Code 02, before 11 July, 2016. Return any open orders in process too. Direct all questions via email to [email protected].
• 10140102Jun 17, 2016Exterior lighting, Equipment. You have been identified as either having stock, or have stock in transit to your dealership. Please return suspect stock of part number 68174065AE. See attachments for identifying suspect stock. Please return suspect parts back to your facing depot using Return Code 02, before 11 July, 2016. Return any open orders in process too. Direct all questions via email to [email protected].
• 10140101Jun 17, 2016Equipment, Electrical system. You have been identified as either having stock, or have stock in transit to your dealership. Please return suspect stock of part number 04685719AI. See attachments for identifying suspect stock. Please return suspect parts back to your facing depot using Return Code 02, before 11 July, 2016. Return any open orders in process too. Direct all questions via email to [email protected].
• 10217357Jun 15, 2016Transmission and drivetrain, Equipment. Axle Assembly, Axle Carrier, Axle Ring and Pinion Engineering is currently investigating concerns with pinion seals on the 2014-15 MY Ram 1500 Pick-up with a rear axle manufactured within the October to November 2014 calendar year. Please contact Ridhan Riyal at cell (810) 513-3832 for further instruction.
• 10140107Jun 15, 2016Transmission and drivetrain. Axle Assembly, Axle Carrier, Axle Ring and Pinion Engineering is currently investigating concerns with pinion seals on the 2014-15 MY Ram 1500 Pick-up with a rear axle manufactured within the October to November 2014 calendar year. Please contact Ridhan Riyal at cell (810) 513-3832 for further instruction.
• 10140100Jun 15, 2016Equipment. You have been identified as either having stock, or have stock in transit to your dealership. Please return all stock of following part numbers: 68141880AH, 68141881AH, 68145625AI, 68145626AI, 68189480AF and replacement part numbers are 68141880AI, 68141881AI, 68145625AJ, 68145626AJ & 68189480AG respectively,which arein stockand available. Please return suspect parts back to your facing depot using Return Code 02…
• 10140099Jun 15, 2016Equipment. You have been identified as either having stock, or have stock in transit to your dealership. Please return all stock of following part number: 05278632AF and replacement part number is 52030379AA which isin stockand available. Please return suspect parts back to your facing depot using Return Code 02, before 05 July, 2016. Return any open orders in process too. Direct all questions via email to…
• 10140098Jun 15, 2016Equipment. You have been identified as either having stock, or have stock in transit to your dealership. Please return all stock of following part numbers: 1YG06JSCAC, 1YG06KEPAC, 1YG 06KFSAC, 1YG 06KGZAC, 1YG 06KBUAC and replacement part numbers are 1YG 1YG06KFSAD, 1YG 06KG ZAD, 1YG 06KBUAE respectively,which arein stockand available. Please return suspect parts back to your facing depot using Return Code 02, before 05 July…
• 10140097Jun 15, 2016Equipment. You have been identified as either having stock, or have stock in transit to your dealership. Please return all stock of following part number: 68188889AE and replacement part number is 68188889AF which isin stockand available. Please return suspect parts back to your facing depot using Return Code 02, before 05 July, 2016. Return any open orders in process too. Direct all questions via email to…
• 10140094Jun 15, 2016Engine, Engine cooling. Return: ALTERNATOR - ENGINE You have been identified as either having stock, or have stock in transit to your dealership. Please return all stock of following part numbers: R4801313AC replacement part number are 04801313AD respectively which are in stock and available. Please return suspect parts back to your facing depot using Return Code 02, before 8 July, 2016. Return any open orders in process too. Direct all…
• 10080202Jun 15, 2016Transmission and drivetrain. "axle assembly, axle carrier, axle ring and pinion engineering is currently investigating concerns with pinion seals on the 2014-15 my ram 1500 pick-up with a rear axle manufactured within the october to november 2014 calendar year. Please contact ridhan riyal at cell (810) 513-3832 for further instruction.
• 10140096Jun 10, 2016Equipment. You have been identified as either having stock, or have stock in transit to your dealership. Please return suspect stock of following part numbers: 68036213AA, 68036230AF, 68158196AC, 68158197AD, & 68158454AD. See attachments for identifying suspect stock. Please return suspect parts back to your facing depot using Return Code 02, before 30 June, 2016. Return any open orders in process too. Direct all questions…
• 10140095Jun 10, 2016Engine cooling. 68085119AE,Inspect and Return: Exhaust Pipe Assy - Frt W/Catalytic Converter You have been identified as either having stock, or have stock in transit to your dealership. Please return suspect stock of part number 68085119AE. See attachments for identifying suspect stock. Please return suspect parts back to your facing depot using Return Code 02, before 30 June, 2016. Return any open orders in process too. Direct…
• 10137047Jun 8, 2016Electrical system. Integrated Center Stack If vehicle is found within 50 mile radius of the Detroit Metro area please hold vehicle and contact:~ Contact one of the following:~ Daniel Acciacca CELL (586) 709-1537~ Michael Savich CELL (248) 214-7270~ Ayed Hadaad CELL (248) 941-8707~ Issue: On a 2015 & 2016MY LA (Challenger), LD(Charger) and LX (300), the Integrated Center Stack (ICS) may experience a lock-up/Inop condition (complete…
• 10137046Jun 8, 2016Equipment. A/C Compressor This applies to 2015 and 2016 UF and PF. Before replacing the AC compressor for noise, leaks , or in-op:~ After these questions have been answered please call one of the individuals below.~ Stev at cell (248) 867-0061~ Mark Briolat at cell (248) 345-0127~ If no response in 15 minutes, please continue with repair.~ 1) Check all AC plumbing connection for leaks with UV light.
• 10137045Jun 8, 2016Electrical system. Hands Free Module - CTM ? Peiker For RT, JK and MK bodies only; Before replacing the Hands Free Module (HFM), please contact Gaurav Saxena at cell (248) 260-0583~ IMPORTANT - do not reset the HFM, clear codes or perform a battery reset before calling. Engineering is currently root causing this issue and your assistance is greatly appreciated. Seeking vehicles with HFM in a locked state, inoperative, or offline.
• 10137044Jun 8, 2016Electrical system. Battery - Transmitter For vehicles within 12 Months in Service which have a "FOB Battery Low" message within Cluster or DTC B1A10 or B1A11 Active or Stored. Engineering is requesting complete FOB returned unopened (ie, battery not removed or FOB housing opened!). ~ All others, follow normal procedures.~ Please ensure Dealer Technicians are aware of this request to allow for gain in FOB Battery depletion…
• 10219814Jun 1, 2016Transmission and drivetrain. 9-spd Transmission: FOR NAFTA Market Only: If you are ordering this transmission please follow all wiTECH pop ups and Warranty Payment Guidelines. If this vehicle contains 1 of the 30 Diagnostic Codes in the 9 Speed Tutorial located on the Service Home Page then please follow the repair steps and submit a Topology report as well as a Vehicle Scan Report with the Warranty Claim.~
• 10219808Jun 1, 2016Visibility (wipers, defrost, mirrors). Power Fold Rearview Mirror Prior to replacing this part for a loose mirror, please first follow this procedure to reset the pivot mechanism. Move the mirror to its full forward position and then to full retract position using the power fold mirror button located on drivers side door panel. Perform this procedure three times.
• 10218250Jun 1, 2016Transmission and drivetrain. 9-spd Transmission: FOR NAFTA Market Only: If you are ordering this transmission please follow all wiTECH pop ups and Warranty Payment Guidelines. If this vehicle contains 1 of the 30 Diagnostic Codes in the 9 Speed Tutorial located on the Service Home Page then please follow the repair steps and submit a Topology report as well as a Vehicle Scan Report with the Warranty Claim.~
• 10218248Jun 1, 2016Engine cooling. Pentastar Oil Filter Adapter: Before replacing this part, please call any one of the following people. Engineering is seeking information regarding this part.~ Dye must be used to determine where the leak is coming from before replacing. Also please check the recently updated Service Bulletin Number 09-008-15.
• 10218244Jun 1, 2016Transmission and drivetrain, Visibility (wipers, defrost, mirrors), Brakes. Power Fold Rearview Mirror Prior to replacing this part for a loose mirror, please first follow this procedure to reset the pivot mechanism. Move the mirror to its full forward position and then to full retract position using the power fold mirror button located on drivers side door panel. Perform this procedure three times.

← All problems reported for the 2015 Ram 1500