2022 Ram 3500 Technical Service Bulletins

583 technical service bulletins (TSBs) are on record for the 2022 Ram 3500. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10236873Apr 22, 2023Electrical system. Ambient Air Temperature Missing, Malfunction Indicator Lamp (MIL) Lamp On, Diagnostic Trouble Code (DTC) P0070-15 Ambient Air Temperature Sensor Circuit-Circuit Short to Battery or Open, P0073 Ambient Air Temperature Sensor Circuit High
• 10236871Apr 20, 2023Electrical system. Ambient Temperature Sensor Servicing.
• 10236804Apr 20, 2023Equipment. 3.5 INCH - SPEAKER ASSY P2 Before ordering a speaker part for crackles or rattling noises make sure to take the following steps: 1. Check for electrical harness routing too close to speaker's rear moving parts, improper connection, and/or harness pinch or damage. 2. Ensure no loose components, including trim grilles, fasteners, surrounding IP parts, etc. were found when removing the speaker. 3. Try "bad" speaker at…
• 10236942Apr 19, 2023Electrical system, Equipment. Radio S26.17 USB Software Update The customer may describe one or more of the following: ? **Blank screen (Rear view camera is not affected and will still function normally). ? Battery drain. ? Radio resets (Rear view camera will still function normally). ? Wireless connectivity device disconnect. ? CarPlayT icon does not appear in device manager. ? Climate icon missing. ? Audio disruptions. ? SXMT inoperative. ?…
• 10236869Apr 19, 2023Transmission and drivetrain, Engine cooling. Ratchet Type Click, Clicking Noise Heard In Four Wheel Drive (4WD) While Turning.
• 10236935Apr 15, 2023Electrical system. Diesel Exhaust Fluid (DEF) Fluid Freezing Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find the following Diagnostic Trouble Code (DTC) has been set: ? P203E-00 - Reductant Level Sensor 1 Circuit Intermittent-Erratic. This bulletin involves replacing the urea delivery module and grade vent valve and updating the Dosing Control Unit (DCU)…
• 10236933Apr 15, 2023Engine cooling, Equipment. wiTECH Small Leak Verification Test (SLVT) - P0456-EVAP SYSTEM SMALL LEAK
• 10236906Apr 7, 2023Equipment. UPD UFD UBD UED UBC UEC Radio Enhancements None available at this time.
• 10236857Apr 7, 2023Electrical system. Uconnect Box Error Message With Active Or Stored Diagnostic Trouble Codes (DTC) B22A9-96, B1570-93, B1E21-96
• 10236967Apr 5, 2023Equipment. Fca caribbean warranty operations newsletter
• 10236903Apr 4, 2023Equipment, Electrical system. Radio Over The Air Uconnect R1L Radio Software Update to R160 Customers may experience one or more of the following: ? Media source changes to AM after the theme mode is changed (ex. headlights on - dark mode). ? Audio cuts out at volume levels 30 or above. ? System switches to Wireless after key cycle, profile change, or theme mode change. ? Wireless phone interface freezes after user accepts incoming call when in…
• 10236856Apr 4, 2023Equipment, Electrical system. Intermittent Blank Radio Screen
• 10236799Apr 4, 2023Visibility (wipers, defrost, mirrors), Electrical system. Power Window 1 Gang Before Replacing the Switch, please verify the following: 1- Check the switch internal resistance to verify the values are within specification stated in the service procedures. 2- Swap the switch with the issue with the other side. This switch is used in both rear doors. If after the swap the issue is now present at the other door and the original door position no longer has the issue, replace…
• 10247955Feb 16, 2023Back-over prevention (rear camera). Uconnect Box Require Service Message
• 10234428Feb 16, 2023Electrical system. Uconnect Box Require Service Message
• 10234426Feb 16, 2023Electrical system. Radio Home Screen Not Loading
• 10247953Feb 15, 2023Electrical system. Radio Remained On After Ignition Is Switched Off, Dead Battery From Excessive Radio Current Draw
• 10248019Feb 14, 2023Brakes, Wheels, Back-over prevention (rear camera), Other or unknown…. Radio Over The Air S24.13 and S24.18 Updating to S26.17 Software Version Customers may experience one or more of the following: ? **Blank screen (Rear view camera is not affected and will still function normally).** ? Battery drain. ? Radio resets (Rear view camera will still function normally). ? Wireless connectivity device disconnect. ? CarPlayT icon does not appear in device manager. ? Climate icon missing. ?…
• 10247951Feb 14, 2023Equipment. Audio Cuts Out When Volume Level Is At 30 Or Above
• 10247950Feb 14, 2023Electrical system. FM/AM/SXM Presets Lost After Ignition Cycle
• 10234492Feb 14, 2023Back-over prevention (rear camera), Wheels, Brakes, Steering, Other or…. Radio Over The Air S24.13 and S24.18 Updating to S26.17 Software Version Customers may experience one or more of the following: ? **Blank screen (Rear view camera is not affected and will still function normally).** ? Battery drain. ? Radio resets (Rear view camera will still function normally). ? Wireless connectivity device disconnect. ? CarPlayT icon does not appear in device manager. ? Climate icon missing. ?…
• 10234422Feb 14, 2023Equipment, Electrical system. FM/AM/SXM Presets Lost After Ignition Cycle
• 10234420Feb 14, 2023Electrical system. Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC) Inaccurate, Battery Charging Message, Presence of IBS related Diagnostic Trouble Codes (DTCs), or Battery Warning Lamp On
• 10247947Feb 10, 2023Body and structure, Electrical system. Radio Loss Of Communication To Body Control Module (BCM) Diagnostic trouble Code (DTC) U0140-00
• 10234419Feb 10, 2023Electrical system, Body and structure. Radio Loss Of Communication To Body Control Module (BCM) Diagnostic trouble Code (DTC) U0140-00
• 10248008Feb 9, 2023Back-over prevention (rear camera), Electrical system. Flash: Powertrain Control Module (PCM) Updates Customer or technician may experience the following: ? **Power Take Off (PTO) disable to high engine oil temperature (DD and DP Cab Chassis only)**. ? Customer may complain of slow PTO idle ramp up. ? Message will appear ?Hot Oil? and exit high idle or PTO mode, when in high idle or PTO mode and running between 10-30 minutes (no load). ? High frequency exhaust noise at…
• 10234481Feb 9, 2023Engine cooling, Transmission and drivetrain. Flash: Powertrain Control Module (PCM) Updates Customer or technician may experience the following: ? **Power Take Off (PTO) disable to high engine oil temperature (DD and DP Cab Chassis only)**. ? Customer may complain of slow PTO idle ramp up. ? Message will appear ?Hot Oil? and exit high idle or PTO mode, when in high idle or PTO mode and running between 10-30 minutes (no load). ? High frequency exhaust noise at…
• 10247938Feb 2, 2023Back-over prevention (rear camera), Wheels. Ratchet Type Click Noise Heard In Four Wheel Drive (4WD) While Turning.
• 10247981Feb 1, 2023Back-over prevention (rear camera), Vehicle speed control, Equipment, Air…. Radio Over The Air R141.01.12, 139.01.53, 136.10.04 to R145.00.15 Software Version Updates Customers may experience one or more of the following: ? **Intermittent Blue Screen (rear view camera still operable).** ? Radio wireless connectivity Inoperative. ? Screen Lockup, Slow Response (rear view camera still operable). ? Caller cannot hear the driver and/or driver cannot hear the caller. ? Cannot switch stations…
• 10247969Feb 1, 2023Electrical system. Warranty Bulletin D-22-07 Part Order Restriction Program ? Engine Control Module (ECM) ? Select 2022 and 2023 Ram 2500 Pickup (DJ), 2022 and 2023 Ram 3500 Pickup (D2), 2022 and 2023 Ram 3500 Cab Chassis (DD) and 2022 and 2023 4500/5500 Ram Cab Chassis (DP) (Rev. B)
• 10234454Feb 1, 2023Visibility (wipers, defrost, mirrors), Back-over prevention (rear camera)…. Radio Over The Air R141.01.12, 139.01.53, 136.10.04 to R145.00.15 Software Version Updates Customers may experience one or more of the following: ? **Intermittent Blue Screen (rear view camera still operable).** ? Radio wireless connectivity Inoperative. ? Screen Lockup, Slow Response (rear view camera still operable). ? Caller cannot hear the driver and/or driver cannot hear the caller. ? Cannot switch stations…
• 10234442Feb 1, 2023Electrical system. Warranty Bulletin D-22-07 Part Order Restriction Program ? Engine Control Module (ECM) ? Select 2022 and 2023 Ram 2500 Pickup (DJ), 2022 and 2023 Ram 3500 Pickup (D2), 2022 and 2023 Ram 3500 Cab Chassis (DD) and 2022 and 2023 4500/5500 Ram Cab Chassis (DP) (Rev. B)
• 10231807Jan 26, 2023Back-over prevention (rear camera). Radio Over The Air Updating to S26.17 Software Version Battery drain on vehicle after connecting wiTECH to vehicle. This bulletin provides information regarding the latest Firmware Over The Air (FOTA) update and provides the service technician an overview of the steps a customer will need to take to complete the update. The radio software will be updated from S26.15 to S26.17. NOTE: National launch for this FOTA…
• 10231806Jan 26, 2023Equipment. RCA Amplifier Drone Noise Audible drone after initial startup or during idle. This bulletin involves replacing the amplifier.
• 10231741Jan 25, 2023Back-over prevention (rear camera). Backup Camera Blue Screen After Flat Bed Install
• 10231739Jan 24, 2023Equipment. Diagnostic Trouble Code (DTC) P1400 ? Aftermarket Calibration Detected/Warranty Coverage Confirmation Required, Setting Falsely.
• 10231735Jan 23, 2023Transmission and drivetrain, Brakes, Visibility (wipers, defrost, mirrors)…. Outside Power Fold Rearview Mirror Noise Or Loose At Pivot. Mirror Contacts Door Window Glass In The Folded Position.
• 10231731Jan 20, 2023Back-over prevention (rear camera), Brakes. Rear View Camera Loose Shipped Harness Connector Ends Do Not Mate, Connector Ends Are Different
• 10231722Jan 13, 2023Equipment. Dead Battery Appears To Be Caused By Radio, Excessive Current Draw
• 10231687Jan 13, 2023Transmission and drivetrain. TRANSMISSION KIT For concerns of the transmission not shifting into/out of 1st through 4th gears or DTC P0731 refer to TSB 21-002-23 and do not order a complete transmission.
• 10231776Jan 12, 2023Electronic stability control, Fuel system, Electrical system, Exterior lighting. Flash: Powertrain Control Module (PCM) Updates Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find that one or more of the following Diagnostic Trouble Codes (DTCs) have been set: **P0299 - Turbocharger Underboost.** P026B-00 - Injection Timing Performance. P061B-00 - Internal Control Module Torque Calculation Performance. P1451-00 - Diesel…
• 10231775Jan 11, 2023Transmission and drivetrain, Exterior lighting. K1 Clutch Snap Ring Repair This bulletin involves replacing the K1 clutch drum snap ring and possibly the K1input shaft drum sub-assembly. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation, a technician may find the following DiagnosticTrouble Code (DTC) has been set: P0731-00 - Gear 1 Shift Incorrect Ratio. This DTC will set during a key cycle and shifting into…
• 10231765Jan 6, 2023Electrical system. 6.7L Cummins No Start This bulletin involves replacing the starter nut with the more conductive nut. The customer may experience the following: A long crank with no start, or a no crank, no start. NOTE: This symptom/condition is caused from a poor connection to the starter. Nut (Starter B+ Cable)
• 10231721Jan 6, 2023Equipment. Customer Indicates Heat Is Blowing Warm Not Hot.
• 10231711Jan 6, 2023Equipment. Washer Light On And Will Not Turn Off After Adding Washer Solvent.
• 10231712Jan 5, 2023Back-over prevention (rear camera), Exterior lighting. Malfunction Indicator Lamp (MIL) Illumination. NOx Sensor Diagnostic Trouble Codes (DTCs) Diagnosis Information.
• 10229768Dec 21, 2022Fuel system. Upgrading To A Larger Capacity Fuel Tanks
• 10229762Dec 20, 2022Equipment. Speaker Pop Noise When Opening Door
• 10229759Dec 16, 2022Engine cooling, Fuel system. Suspected Internal Exhaust Gas Recirculation (EGR) Cooler Coolant Leak, Additional Diagnostics.
• 10229811Dec 15, 2022Electrical system, Equipment, Air bags, Vehicle speed control, Back-over…. Radio Over The Air R141.01.12, 139.01.53, 136.10.04 to R145.00.15 Software Version Updates This bulletin provides information regarding the latest Firmware Over The Air (FOTA)update and provides the service technician an overview of the steps a customer will need to take to complete the update. The radio softwarewill be updated from R141.01.12, 139.01.53, 136.10.04 to R145.00.15.The national launch for the FOTA is…

← All problems reported for the 2022 Ram 3500