2016 Ram 5500 Wheels Problems

“We have sent this in for recall repairs and Dodge either did not have the parts or said it would be weeks before they got the parts and we, as a company have had three dodge ram 5500's in the last week that have broken all the wheel studs off, snapped a single stud, or the the lug nuts have gotten loose even after torquing them to the newly recommended 129ft/lbs. We have 30 plus of these trucks and we are worried that if dodge does not get this fixed that there will be an injury.”

“The contact owns a 2016 Ram 5500. The contact stated that the front driver's side wheel bearing fractured and detached from the vehicle. The failure occurred without warning. The vehicle was towed to texan dodge chrysler jeep Ram (18555 eastex fwy, humble, tx) where the failure was confirmed. The vehicle was repaired. The manufacturer was notified. The failure mileage was 46,610.”

“The contact owns a 2016 Ram 5500. The contact stated that while driving at approximately 15 MPH the driver's side rear outer wheel suddenly detached from the vehicle. Upon inspection, it was discovered that all ten lug nuts securing the wheel had sheared off causing the failure to occur. The vehicle was taken to the local dealer who serviced the vehicle under the NHTSA recall campaign number: 21V398000(Wheels). The lug nuts were replaced and the recall was completed. Approximately 3 months later the same failure occurred on the front driver's side wheel. …”

“The contact owns a 2016 Ram 5500. The contact stated while driving approximately 15 MPH and making a left turn the dual left rear tires had separated from the vehicle and the vehicle landed on the axle. The contact stated no warning light was illuminated. The contact stated that he had the vehicle towed to a dealer who determined that the studs had sheared from the wheel and found that his vehicle had NHTSA Campaign Number: 21V398000 (Wheels) associated with the VIN. The vehicle had been repaired. However, the vehicle suffered a similar tire separation on the front driver's side tire. …”

“The contact owns a 2016 Ram 5500. The contact stated that on two separate occasions while his driver was driving at an undisclosed speed, the vehicle started to shake violently when all four tires detached from the vehicle. As a result, the contact’s driver was able to navigate the vehicle to safety. The vehicle was towed to an auto repair shop where it was diagnosed that the wheels studs had detached from the wheels and needed to be replaced. The vehicle was repaired however the failure recurred. The contact then received notification of the NHTSA Campaign Number: 21V398000 (Wheels). …”