2023 Rivian R1S Technical Service Bulletins

48 technical service bulletins (TSBs) are on record for the 2023 Rivian R1S. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 11036008Jul 24, 2026Other or unknown. Rivian is launching a technical service bulletin for some model year 2022-2026 R1T and R1S vehicles that might have an audible rattle originating from the B-pillar area when driving on rough road surfaces. Upon customer complaint, Rivian will apply anti-rattle tape near both 1st row seat belt retractors to prevent rattling.
• 11036009Jul 23, 2026Body and structure. Rivian is launching a technical service bulletin for some model year 2022-2024 R1T and R1S vehicles that might have bubbles in the painted surfaces below the exterior door handles. On these vehicles, adhesive that secures an inner door reinforcement could allow contaminants to corrode the inner surface of the door over time, affecting the visual appearance of the door surface. Upon customer complaint, Rivian will…
• 11036007Jul 23, 2026Body and structure. Rivian is launching a technical service bulletin for some model year 2022-2024 R1T and R1S vehicles that could have inadequate adhesion between the outer door panel and an internal reinforcement. On affected doors, the exterior door handle might not sit flush with the outer door panel or might move slightly when the handle is operated. Upon customer complaint, Rivian will apply new adhesive between the…
• 11033439May 19, 2026Electrical system. Rivian is launching a technical service bulletin for some model year 2022-2024 R1 vehicles that may have ultrasonic sensors detached from the front fascia mounting area. After detachment, the ultrasonic sensor may become dislodged and hang inside the front fascia, causing customer notifications for sensor issues and potential sensor damage. Upon ultrasonic sensor detachment, Rivian will perform an ultrasonic sensor…
• 11033438May 15, 2026Visibility (wipers, defrost, mirrors). Rivian is launching a technical service bulletin for some model year 2022-2024 R1T and R1S vehicles that may be susceptible to water ingress in the front HVAC assembly. This may result in damp or soggy carpets in the front of the vehicle. Upon customer complaint of wet carpet in the front of the vehicle, Rivian will inspect the component and replace any damaged parts, and reseal the case to prevent further water…
• 11032388Apr 17, 2026Other or unknown. Rivian is launching a technical service bulletin for some model year 2022-2026 R1T and R1S vehicles that may be prone to noise and/or vibration from the door areas, particularly buzzing and rattling sounds. This results in a perceived quality issue. Upon customer complaint of noise from any door trim panel, Rivian will modify several door trim panel components to alleviate the condition.
• 11029593Feb 17, 2026Electrical system. SMS Reminder sent to customers who had still open potential 12-volt failures.
• 11029592Feb 9, 2026Electrical system. SMS sent to customers with potential 12-volt failure and advising need for replacement to avoid drivability interruptions.
• 11029590Feb 4, 2026Body and structure. Rivian is launching a technical service bulletin for some model year 2022-2024 R1T and R1S vehicles that could have inadequate adhesion between the outer door panel and an internal reinforcement. On affected doors, the exterior door handle might not sit flush with the outer door panel or might move slightly when the handle is operated. Upon customer complaint, Rivian will apply new adhesive between the…
• 11026108Nov 21, 2025Fuel system. Rivian is initiating a customer satisfaction campaign for some model year 2022-2024 R1T and R1S vehicles. These vehicles may have HV battery connectors that are susceptible to corrosion in some climates. If corrosion occurs, the vehicle may enter into a reduced performance safe-state mode and a fault indicator light will illuminate on the driver display alerting the driver to have service performed on their…
• 11026109Nov 20, 2025Body and structure. Rivian is launching a technical service bulletin for some model year 2022-2024 R1T and R1S vehicles that might have bubbles in the painted surfaces below the exterior door handles. On these vehicles, adhesive that secures an inner door reinforcement could allow contaminants to corrode the inner surface of the door over time, affecting the visual appearance of the door surface. Upon customer complaint, Rivian will…
• 11026105Nov 14, 2025Suspension. Email requesting customers to have service performed on their vehicle.
• 11022483Aug 29, 2025Transmission and drivetrain. Rivian is initiating a customer satisfaction campaign for some model year 2023-2025 R1T and R1S vehicles that were built with a front NVH/ting washer that may damage the nearby wheel speed sensor, resulting in the vehicle entering into a reduced performance safe-state mode and a fault indicator light illuminating on the driver display alerting the driver to have service performed on their vehicle. Rivian will…
• 11022482Aug 1, 2025Suspension. Rivian is initiating a customer satisfaction campaign for some model year 2023-2024 R1T and R1S vehicles. On these vehicles, the wheel hub to knuckle joint may have been assembled with an updated fastener using a torque value intended for the previously-used fastener. A fastener torqued to the previously-used lower value may cause an audible noise while driving at low speeds but will not impact vehicle performance…
• 11021781Jul 24, 2025Other or unknown. FSAM-1476: Rivian is initiating a customer satisfaction campaign for some model year 2022-2023 R1T and R1S vehicles that were manufactured with a certification label that has the incorrect manufacturing date. Rivian will install an updated certification label. Rivian is launching this campaign for customer satisfaction and to ensure the quality of Rivian vehicles.
• 11021782Jul 9, 2025Transmission and drivetrain. FSAM-1608: Rivian is initiating a customer satisfaction campaign for some model year 2023-2024 R1T and R1S vehicles. On these vehicles, the wheel hub to knuckle joint may have been serviced with a torque value that was too low. A fastener torqued to the lower value may cause an audible noise while driving at low speeds but will not impact vehicle performance. Rivian will retorque the affected fasteners and replace…
• 11019107May 6, 2025Electrical system. Rivian is initiating a customer satisfaction campaign for some model year 2023-2025 R1T and R1S vehicles. These vehicles may have been built with an improperly formatted solid state drive (SSD) for storing camera recordings. This improper formatting prevents video recording of driving incidents and Motion Cam, which is part of the vehicle's Gear Guard system. Rivian will properly format the SSD.
• 11016388Mar 22, 2025Suspension, Electrical system, Other or unknown. Bulk SMS - Service Campaign Awareness
• 11015128Feb 21, 2025Electrical system, Suspension, Transmission and drivetrain. We’re reaching out about your <<<R1T,R1S>>> (VIN: <<insert VIN here>>). We need to <<<replace the 12V battery>><<,>> << and>> swap the HVAC drain plug <<,>> << and>> <<inspect the wheel hub bolt torque>>> on your <<<R1T,R1S>>>. You’ve got options — schedule an appointment at your local Rivian Service Center or with one of our qualified third-party providers. Either way, these services are covered under warranty at…
• 11015126Feb 21, 2025Electrical system, Suspension, Transmission and drivetrain. Rivian Internal Hi <customer name>, We’re reaching out about your Rivian. We identified a need to inspect your vehicle for a potential issue that could result in being unable to access or drive your vehicle—and may even require a tow. Schedule an appointment with your local Rivian Service Center or with one of our qualified third-party providers. Both options are covered under warranty at no cost to you. Whichever…
• 11015124Feb 21, 2025Transmission and drivetrain. We’ve identified your R1T/R1S as needing a service appointment related to its Drain Plug. Please bring your vehicle in to prevent any issues, which could impact your HVAC system. Contact our Service Operations Center now at 1-855-RIVIAN-5 / 1-855-748-4265 to schedule an expedited appointment. Act fast to avoid unexpected issues!
• 11015123Feb 21, 2025Suspension. We’ve identified your R1T/R1S as needing a service appointment to inspect and potentially adjust the torque for fasteners on your vehicle’s wheel hubs. Failing to inspect this could result in a tow. Contact our Service Operations Center now at 1-855-RIVIAN-5 / 1-855-748-4265 to schedule an expedited appointment. Act fast to avoid issues!
• 11015122Feb 21, 2025Electrical system. We’ve identified your R1T/R1S as needing a service appointment related to its 12V battery. Please bring your vehicle in to prevent a 12-Volt Failure, which could leave you unable to access or drive your vehicle—and may even require a tow. Contact our Service Operations Center now at 1-855-RIVIAN-5 / 1-855-748-4265 to schedule an expedited appointment. Act fast to avoid issues!
• 11012364Dec 19, 2024Transmission and drivetrain. Rivian is initiating a customer satisfaction campaign for some model year 2023-2024 R1T and R1S vehicles. On these vehicles, the wheel hub to knuckle joint may have been assembled with an updated fastener using a torque value intended for the previously-used fastener. A fastener torqued to the previously-used lower value may cause an audible noise while driving at low speeds but will not impact vehicle performance…
• 11011343Nov 15, 2024Electrical system, Other or unknown, Transmission and drivetrain. Text message sent to customers to encourage them to call and schedule service.
• 11011346Nov 14, 2024Other or unknown. Rivian is initiating a customer satisfaction campaign for some model year 2022-2024 vehicles that were built with a front HVAC assembly drain valve that can become clogged after continued use of certain interior cleaning products. This clogging may cause condensation from the evaporator to build up and overflow, causing the carpet in the driver and passenger footwell areas to become wet. Rivian will replace the…
• 11008360Oct 20, 2024Electrical system. Rivian is initiating a customer satisfaction campaign for some model year 2022-2024 R1T and R1S vehicles that may have been built with the incorrect interior audio amplifier. On these vehicles, a firmware update may cause the audio system to stop working. Rivian will replace the interior audio amplifier. Rivian is launching this campaign for customer satisfaction and to ensure the quality of Rivian vehicles.
• 11010149Oct 1, 2024Other or unknown. Rivian is launching a technical service bulletin for some model year 2022-2024 R1T and R1S vehicles that are prone to excessive cabin noise and vibration from the A/C compressor. While the vehicle is safely functioning as designed, some customers might be unaccustomed to the noise of the A/C compressor in an electric vehicle; such noise is usually not noticeable in vehicles powered by an internal combustion engine.
• 11008362Sep 20, 2024Suspension. Rivian is initiating a customer satisfaction campaign for some model year 2023-2024 R1T and R1S vehicles. On these vehicles, the wheel hub to knuckle joint may have been assembled with an updated fastener using a torque value intended for the previously-used fastener. A fastener torqued to the previously-used lower value may cause an audible noise while driving at low speeds but will not impact vehicle performance…
• 11008358Sep 20, 2024Other or unknown. Rivian is initiating a customer satisfaction campaign for some model year 2022-2023 R1T and R1S vehicles that may have been delivered with a tire service kit that is missing some handle extension components, referenced in the owner's guide. Customers should be aware, based on the owner's guide, that without the handle extension components, it will be more difficult to raise and lower the vehicle with the supplied…
• 11007059Aug 31, 2024Other or unknown. Rivian is launching a technical service bulletin for some model year 2022-2024 R1T and R1S vehicles that are prone to excessive cabin noise and vibration from the A/C compressor. While the vehicle is safely functioning as designed, some customers might be unaccustomed to the noise of the A/C compressor in an electric vehicle; such noise is usually not noticeable in vehicles powered by an internal combustion engine.
• 11006035Jul 3, 2024Suspension. Rivian is initiating a technical service bulletin for some 2022-2024 R1T and R1S vehicles. In some situations, the driver may notice a squeaking or chirping noise coming from the front of the vehicle when driving on uneven surfaces below 32 km/h (20 mph). This condition does not affect vehicle performance. Upon customer complaint of this squeaking or chirping noise, Rivian will replace the front hydraulic jounce…
• 11001111May 9, 2024Other or unknown. Rivian is initiating a customer satisfaction campaign for portable chargers that were supplied with some model year 2022 and 2023 R1T and R1S vehicles. These portable chargers may be susceptible to corrosion on the charging pins, preventing the portable charger from charging the vehicle. Rivian will test the portable charger and either replace it or install additional seals to prevent future corrosion.
• 10253832Apr 24, 2024Electrical system. 4/24/2024 Rivian Vehicle Connectivity Outage SMS Renotification Reminder from Rivian. We noticed your vehicle is still offline. To restore connectivity, simply restart your vehicle’s software: - Make sure your vehicle is in Park - Find the two outermost control buttons on the steering wheel - Press both buttons at the same time and hold for 15 seconds. For an illustrated guide, visit our Support Center…
• 10252723Mar 30, 2024Electrical system. On Friday, March 22, 2024, an outage affected Rivian vehicle connectivity. The outage was resolved that same day, but some vehicles may require an infotainment reset to restore full connectivity 3/22/2024 Rivian Vehicle Connectivity Outage SMS Notification After a recent network outage that impacted connectivity on some Rivian vehicles, we noticed your vehicle is still offline.
• 10252657Mar 14, 2024Fuel system. Rivian is initiating a customer satisfaction campaign for some model year 2023 and 2024 R1T and R1S vehicles that may have been built with suspect battery cells. If one or more cells were not manufactured correctly by the supplier, there is a potential for the cell to short circuit. If there is a cell short circuit, a fault message will illuminate on the driver display and in the mobile phone app alerting the…
• 10249894Jan 24, 2024Suspension. Rivian is initiating a Preliminary Information Notification (PIN) for MY2022/23 R1 vehicles. Under certain driving conditions, at low speeds (under 25 mph), when the vehicle is articulating over bumps and uneven surfaces, a chirp noise can be heard inside the cabin, which might be perceived as a quality issue. But the noise is not an indication of a quality issue and there are no resulting performance issues with…
• 10245651Nov 29, 2023Electrical system. Rivian is initiating a customer satisfaction campaign for some model year 2022 and 2023 R1S and R1T vehicles that may have been built with a suspect auxiliary air compressor control panel. Due to a supplier quality issue, the display may show inaccurate pressure readings of approximately +/- 10%. If the compressor is used to fill the tires, slightly inaccurate pressure readings may result in slightly overinflated…
• 10245657Nov 15, 2023Back-over prevention (rear camera). Customer communication regarding software update 2023.42.
• 10245655Nov 15, 2023Back-over prevention (rear camera). Customer communication regarding software update 2023.42.
• 10245656Nov 14, 2023Back-over prevention (rear camera). Customer communication regarding software update 2023.42.
• 10245654Nov 14, 2023Back-over prevention (rear camera). Customer communication regarding software update 2023.42.
• 10245653Nov 14, 2023Back-over prevention (rear camera). Customer communication regarding software update 2023.42.
• 10241960Aug 9, 2023Electrical system. Rivian is initiating a customer satisfaction campaign for some model year 2023 R1T and R1S vehicles that may have been built with an improperly routed cowl harness. If this harness is improperly routed, there is a potential for this harness to make contact with the windshield wiper mechanism during wiper use. If the harness contacts the windshield wiper mechanism and this condition persists over time, the vehicle…
• 10238719Jun 14, 2023Steering. Rivian is launching a technical service bulletin for some model year 2022 and 2023 R1T and R1S vehicles. In some situations, the driver may notice a slight vibration or oscillation of the steering wheel at 70 mph or above, causing a perceived quality issue. Steering function is not affected. Upon customer complaint of a vibrating steering wheel, Rivian will replace the steering wheel with a version that is less…
• 10237165May 31, 2023Electrical system. Rivian is initiating a customer satisfaction campaign for some model year 2022-2023 R1S and R1T vehicles that may have been built with an onboard charger that cannot charge on alternating current (AC). The part supplier shipped onboard chargers that were built with a faulty component. Though AC charging may be disabled in these vehicles, direct current (DC) fast charging is still functional. Rivian will replace the…
• 10235683Apr 25, 2023Steering. Rivian is initiating a customer satisfaction campaign for some model year 2022 and 2023 R1T and R1S vehicles. On these vehicles, the steering wheel may not be properly aligned to the steering rack. This condition is noticeable to the customer but would not result in any changes in the performance of the vehicle. Rivian will inspect the steering wheel alignment and, if necessary, realign the components.
• 10235545Apr 25, 2023Electrical system. Rivian is initiating a customer satisfaction campaign for some model year 2022 and 2023 R1S vehicles that may have been built with the incorrect interior audio amplifier. This results in reduced audio volume or quality for passengers in the 3rd row seat. Rivian will replace the amplifier on all affected vehicles. Rivian is launching this campaign for customer satisfaction and to ensure the quality of Rivian vehicles.

← All problems reported for the 2023 Rivian R1S