2004 Suzuki Verona Recalls
NHTSA lists 5 recall campaigns for the 2004 Suzuki Verona. A recall applies only to vehicles built within the affected range, so check your own VIN at nhtsa.gov/recalls. Repairs for recalls are free at a franchised dealer.
- Exterior lighting › HeadlightsCovers: Suzuki Verona 2004–2006
Reported issue: Suzuki Motor of America, Inc. (Suzuki) is recalling certain model year 2004-2006 Verona vehicles manufactured June 2003 to October 2005. In the affected vehicles, there may be heat generated within the DRL module located in the instrument panel, which could melt the DRL module.
Possible consequence: If the DRL module melts due to the heat generation, it could cause a vehicle fire.
Remedy: Suzuki will notify owners, and dealers will replace the DRL module in the instrument panel, free of charge. The recall began on November 5, 2014. Owners can contact Suzuki customer service at 1-800-934-0934. Suzuki's number for this recall is XC.
- Exterior lighting › Brake lights › SwitchCovers: Suzuki Verona 2004, Forenza 2004
Reported issue: On certain passenger vehicles, the brake light switch may become misadjusted if an upward/rearward force is applied to the brake pedal. If this should occur, the brake light switch will not function properly, causing the brake lights, including the high mounted stop lamp, to remain illuminated continuously without brake pedal application, with the ignition switch in the on or off position.
Possible consequence: If the brake lights remain on continuously while driving,a following driver may not know when your brakes have been applied, and a rear-end crash could occur without prior warning. This condition may also discharge the vehicle's battery, and, the automatic transmission torque converter clutch, cruise control and…
Remedy: Dealers will replace the brake light switch free of charge. The recall began on march 16, 2005. Owners may contact suzuki at 1-800-934-0934.
- Fuel system, gasoline › DeliveryCovers: Suzuki Verona 2004
Reported issue: In certain passenger vehicles, a fault in the adaptive fuel control logic can cause some vehicles to use air/fuel ratios during deceleration that are lean enough to cause engine stalling.
Possible consequence: Engine stalling could result in a crash.
Remedy: Dealers will reprogram the electronic control module (ecm) on affected vehicles. The recall began on september 14, 2004. Owners should contact suzuki at 1-800-934-0934.
- Air bags › FrontalCovers: Suzuki Verona 2004, Forenza 2004
Reported issue: On certain passenger cars, the dual stage driver's air bag deploys in an improper sequence.
Possible consequence: If the driver's air bag deploys improperly during a frontal vehicle crash, the driver could be severely injured or killed.
Remedy: Dealers will install an adapting wiring harness. Owner notification began on october 30, 2003, to verona vehicle owners. All forenza vehicles were repaired at the port of entry. There are no owner notifications necessary for the forenza model vehicles. Owners should contact suzuki at 1-800-934-0934.
- Seat belts › Front › Buckle assemblyCovers: Suzuki Verona 2004
Reported issue: Certain passenger vehicles may have a mislocated sensor in the driver's seat belt buckle assembly. This condition can prevent the driver's seat belt tongue from being inserted into the buckle.
Possible consequence: In the event of a crash, a seat occupant may not be properly restrained increasing the risk of injury.
Remedy: Dealers will replace the driver's seat belt buckle assembly. Owner notification began september 4, 2003. Owners should contact suzuki at 1-800-934-0934.
← All problems reported for the 2004 Suzuki Verona
About this data. Data from NHTSA (ODI) complaints, recalls, TSBs and investigations, updated Oct 31, 2026. Complaints are unverified consumer reports and may be duplicated or inaccurate.