2016 Tesla Model X Recalls
NHTSA lists 12 recall campaigns for the 2016 Tesla Model X. A recall applies only to vehicles built within the affected range, so check your own VIN at nhtsa.gov/recalls. Repairs for recalls are free at a franchised dealer.
- Structure › BodyCovers: Tesla Model X 2016
Reported issue: Tesla, Inc. (Tesla) is recalling certain 2016 Model X vehicles. The front and center roof cosmetic trim pieces may be adhered to the vehicle without primer. As a result, one or both pieces of trim may separate from the vehicle.
Possible consequence: Trim that separates from the vehicle during use can create a road hazard and increase the risk of a crash.
Remedy: Tesla service will test the roof trim adhesion and reattach the trim pieces as necessary, free of charge. Owner notification letters were mailed October 14, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-12-008. Vehicles previously repaired under recall…
- Seat belts › Front › Warning light/devicesCovers: Tesla Model X 2015–2024, Model S 2012–2024, Model 3 2017–2023 +1 more
Reported issue: Tesla, Inc. (Tesla) is recalling certain 2012-2024 Model S, 2015-2024 Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles. In the event of an unbelted driver, the seat belt warning light and audible chime may not activate as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Possible consequence: A seat belt warning system that fails to alert occupants of an unbelted seat belt can increase the risk of injury during a crash.
Remedy: Tesla will release an over-the-air (OTA) software update. Owner notification letters were mailed July 26, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-008.
- Electrical system › Instrument cluster/panelCovers: Tesla Model X 2016–2024, Model S 2012–2023, Model 3 2017–2023 +2 more
Reported issue: Tesla, Inc. (Tesla) is recalling certain 2012-2023 Model S, 2016-2024 Model X, 2017-2023 Model 3, 2019-2024 Model Y, and 2024 Cybertruck vehicles. An incorrect font size is displayed on the instrument panel for the Brake, Park, and Antilock Brake System (ABS) warning lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 105, "Hydraulic and Electric…
Possible consequence: Warning lights with a smaller font size can make critical safety information on the instrument panel difficult to read, increasing the risk of a crash.
Remedy: Tesla began releasing an over-the-air (OTA) software update, free of charge. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-003.
- Electrical system › Adas › Driver monitoring › SoftwareCovers: Tesla Model X 2016–2023, Model S 2012–2023, Model 3 2017–2023 +1 more
Reported issue: Tesla, Inc. (Tesla) is recalling 2012-2023 Model S, 2016-2023 Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles equipped with all versions of Autosteer leading up to the version(s) that contains the recall remedy. In certain circumstances when Autosteer is engaged, the prominence and scope of the feature's controls may not be sufficient to prevent driver misuse of the SAE Level 2 advanced driver-assistance…
Possible consequence: In certain circumstances when Autosteer is engaged, and the driver does not maintain responsibility for vehicle operation and is unprepared to intervene as necessary or fails to recognize when Autosteer is canceled or not engaged, there may be an increased risk of a crash.
Remedy: Tesla will release an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed February 10, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-00-008.
- Steering › Automated/adaptive steeringCovers: Tesla Model X 2016–2023, Model S 2016–2023, Model 3 2017–2023 +1 more
Reported issue: Tesla, Inc. (Tesla) is recalling certain 2016-2023 Model S, Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles equipped with Full Self-Driving Beta (FSD Beta) software or pending installation. The FSD Beta system may allow the vehicle to act unsafe around intersections, such as traveling straight through an intersection while in a turn-only lane, entering a stop sign-controlled intersection without coming…
Possible consequence: FSD Beta software that allows a vehicle to exceed speed limits or travel through intersections in an unlawful or unpredictable manner increases the risk of a crash.
Remedy: Tesla will release an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed April 15, 2023. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-00-001.
- Steering › Automated/adaptive steeringCovers: Tesla Model X 2016–2022, Model S 2016–2022, Model 3 2017–2022 +1 more
Reported issue: Tesla, Inc. (Tesla) is recalling certain 2016-2022 Model S and Model X, 2017-2022 Model 3, and 2020-2022 Model Y vehicles. The "rolling stop" functionality available as part of the Full Self-Driving (Beta) software may allow the vehicle to travel through an all-way stop intersection without first coming to a stop.
Possible consequence: Failing to stop at a stop sign can increase the risk of a crash.
Remedy: Tesla will perform an over-the-air (OTA) software update that disables the "rolling stop" functionality, free of charge. Owner notification letters were mailed March 28, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-001.
- Visibility › Defroster/defogger/hvac systemCovers: Tesla Model X 2016–2018, Model S 2012–2018
Reported issue: Tesla, Inc. (Tesla) is recalling certain 2012-2018 Tesla Model S and 2016-2018 Model X vehicles with a center display equipped with a NVIDIA Tegra 3 processor and an 8GB eMMC NAND flash memory device. When the 8GB eMMC NAND flash memory device for the center display reaches lifetime wear, the eMMC controller will no longer be able to maintain the integrity of the filesystem, causing a failure in some of the center…
Possible consequence: The eMMC controller wear-out condition can cause the loss of the rearview camera display, defrost/defog control settings, and exterior turn signal lighting, reducing visibility and increasing the risk of a crash.
Remedy: Owners should ensure their vehicles are operating firmware release 2020.48.48.12 or newer, which will alert owners if the eMMC is approaching lifetime wear. Tesla will notify owners, and will replace the VCM daughterboard with one containing an enhanced eMMC controller, free of charge. The recall began March 29…
- Structure › BodyCovers: Tesla Model X 2016
Reported issue: Tesla, Inc. (Tesla) is recalling certain 2016 Model X vehicles. The front and spine cosmetic roof trim may have been adhered to the vehicle without first using primer. As a result, one or both pieces of trim may separate from the vehicle while moving.
Possible consequence: Trim that separates from the vehicle during use can cause a road hazard and increase the risk of a crash.
Remedy: Tesla will notify owners, and dealers will test the roof trim adhesion, and, as necessary, apply primer, free of charge. The recall began January 15, 2021. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-20-12-005. This recall has been superseded by Recall 24V615…
- Steering › Electric power assist systemCovers: Tesla Model X 2015–2016
Reported issue: Tesla, Inc. (Tesla) is recalling certain 2015-2016 Model X vehicles. The aluminum bolts that attach the power steering gear assist motor to the gear housing may corrode and fracture causing a reduction or complete loss of power steering assist.
Possible consequence: Loss of power steering assist would require a higher steering effort, especially at lower speeds, which may increase the risk of a crash.
Remedy: Tesla will notify owners, and Tesla Service Centers will replace the steering gear mounting bolts with coated steel bolts, and add a corrosion-preventative sealer to the steering gear motor housing and motor connection bolts. If the mounting bolts are found to be broken or break during removal and cannot be removed…
- Seats › Mid/rear assemblyCovers: Tesla Model X 2016–2017
Reported issue: Tesla, Inc. (Tesla) is recalling certain 2016-2017 Model X vehicles. The left-side, second row, reclining seat backs may not fully latch due to having incorrectly adjusted recliner mechanism cables. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 207, "Seating Systems," and 210, "Seat Belt Assembly Anchorages."
Possible consequence: If the seat back moves forward in the event of a crash, it can increase the risk of injury.
Remedy: Tesla will notify owners, and Tesla service technicians will correct the cable adjustment for the left-side, fold-flat, second row, seat recliner mechanism, free of charge. The recall began on November 10, 2017. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-17-13-004.
- Parking brakeCovers: Tesla Model X 2016–2017, Model S 2012–2016
Reported issue: Tesla, Inc. (Tesla) is recalling certain 2016 Model S and Model X vehicles. The electric parking brake calipers have an internal gear that may be improperly manufactured, possibly resulting in the gear fracturing during parking brake application or release.
Possible consequence: If the gear breaks during parking brake release, the vehicle will not be able to be moved. If the gear breaks during parking brake application, the parking brake may not adequately hold the vehicle, potentially resulting in the vehicle rolling, increasing the risk of a crash.
Remedy: Tesla will notify owners, and service centers will replace both the left and right electric parking brake calipers, free of charge. The recall began March 6, 2018. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-17-33-002.
- Seats › Mid/rear assemblyCovers: Tesla Model X 2016
Reported issue: Tesla Motors, Inc. (Tesla) is recalling certain model year 2016 Model X vehicles manufactured September 29, 2015, to March 30, 2016. In the affected vehicles, the third row seat back may move forward under load such as in a frontal collision. As such, the vehicles do not conform to Federal Motor Vehicle Safety Standard (FMVSS) number 207, "Seating Systems."
Possible consequence: If the third row seat does not remain in its adjusted position, there may be an increased risk of injury to an occupant in the event of a crash.
Remedy: Tesla will notify owners, and dealers will replace all affected third row seats, free of charge. The recall began on April 20, 2016. Owners may contact Tesla customer service at 1-844-248-3752 or by email at [email protected]. Tesla's number for this recall is SB-16-13-003
← All problems reported for the 2016 Tesla Model X
About this data. Data from NHTSA (ODI) complaints, recalls, TSBs and investigations, updated Oct 28, 2026. Complaints are unverified consumer reports and may be duplicated or inaccurate.