2022 Thor Motor Coach Magnitude Body and structure Problems

“After driving from California to New York, I saw that screws holding the Front Cap (cab over bunk) had started to back out and delaminated the trim. If the screws continue to back out, it is possible that the entire front cap attached to the Ford Chassis could break apart from the RV and injure the passengers or people on the road. I have reported this issue to Thor and I am awaiting feedback if they are able to repair. There are also many other Thor Magnitude customers reporting this issue online.”

“The primary issue involves the large, full-wall slide-out system on our motorhome. Since new, the front portion of the slide has shifted outward during travel, even while fully retracted. This led to the slide binding and becoming inoperable. The manufacturer attempted to fix the issue twice at their factory service center. Their most recent solution involved providing a makeshift brace—essentially a stick—intended to wedge the front of the slide in place during transit. Since then, the issue has progressed. …”

“Screws that hold the rv body together at the corners are breaking off and /or backing out. If all these screws come out which they are known to the body could fall apart going down the highway. I’ve read forums where everyone that has submitted complaints are experiencing this problem on all Thor Motorcoach models, Omni and Magnitude. Thor is totally aware of this problem. The only way to tell this problem exists is to visually inspect the moldings that cover these screws and the molding will bulge out. bolt JPH”

“The following severe safety defects were found on the motorhome: - The passenger side wall was NOT attached on the bottom to the frame. The mounting locations are missing all mounting hardware from the factory. The wall is breaking away from the roof where it is the only location anchored. If it wasn't discovered, the whole side wall may fall off endangering the occupants and other vehicles on the road. -The front cap is pulling away from the coach due to insufficient mounting screws on both sides, which could cause the front fiberglass cap to fall off on the road, causing an accident. …”