2022 Thor Motor Coach Windsport Problems
- Complaints
- 5filed with NHTSA
- Median mileage
- 14,000miles, 1 complaints with mileage
- Recalls
- 1campaigns on record
- Trend
- Not enough dataFewer than 15 complaints, too few for a reliable trend.
Sources: NHTSA records for the 2022 Thor Motor Coach Windsport (complaints, recalls, investigations). Report an error
NHTSA recorded 5 consumer complaints for the 2022 Thor Motor Coach Windsport. The part named most often is other or unknown, with 3 complaints (60% of the total), followed by body and structure (2) and equipment (1). 1 of the complaints include a mileage, and 100% of those were filed for vehicles with under 50,000 miles; the median is 14,000 miles. NHTSA lists 1 recall campaign and 4 technical service bulletins for this model year. Body and structure complaints overlap with 1 recall campaign covering the step/ladder and 1 technical service bulletin filed under the same part.
This model year has fewer than 25 complaints on record, so the numbers below can change a lot with a few new reports.
Which parts are reported most
Complaints can name more than one part, so the counts add up to more than the total. Select a part to see its complaints, recalls and bulletins.
- Other or unknown3 60%
- Body and structure2 40%
- Equipment1 20%
Example complaints
Other or unknown: “The propane heater on our motorhome has been cycling on the high limit switch since new. This is due to insufficient airflow across the heat exchanger. It is also the source of intermittent carbon monoxide alarms being activated. We have had this unsuccessfully repaired under warranty. The cycling continues. If other units of this model series were built the same way, I suspect this is a problem common to all. This also creates a fire risk should the high limit switch be operated enough times for it to fail. …”
NHTSA complaint #11590874, filed 2024-05Body and structure: “While driving on a crowded freeway a wooden structure fell from the ceiling of my motorhome and landed on the dashboard inches from my steering wheel. If it had hit my steering wheel or my hands, I would have been involved in a multiple vehicle collision. Thank God, I was able to safely pull over to the shoulder to check for damage. The beam was too heavy for me to move it. I drove it to a Camping World repair facility. The repair technician inspected the damage. He told me the support structure fell because it was held up by only one screw. …”
NHTSA complaint #11627339, filed 2024-11Equipment: “I’m concerned about the bbq propane compartment getting hairline cracks and the brass shut off valve that’s made of brass and dropping down to the road and getting road rash till it grinds through the shut off valve. I just read on a Thor Facebook forum that this happened to a 2016 Thor Windsport 34P. I have the pictures he posted. I asked AI Gemini, apparently this is a known and well documented safety issue. I can forward the link to the AI report. Will link here if this works. The pictures are mine (intact) and the other two are his 2016 motorhome. …”
NHTSA complaint #11743055, filed 2026-06Mileage when problems were reported
100% of the 1 complaints with a mileage were filed for vehicles with under 50,000 miles; the middle half falls between 14,000 and 14,000 miles.
Complaints by year filed
Fewer than 15 complaints, too few for a reliable trend.
Recalls and investigations
- 22V076000Feb 10, 2022Structure › Body › Step/ladderCovers: Thor Motor Coach Windsport 2022, Ace 2022, Freedom Traveler 2022 +1 more
Thor Motor Coach (TMC) is recalling certain 2022 ACE, Freedom Traveler, Hurricane, and Windsport motorhomes. The rear ladder may have been installed on the wrong side of the motorhome.
Recall details for the 2022 Thor Motor Coach Windsport → · Check a VIN at nhtsa.gov/recalls
Technical service bulletins
TSBs are manufacturer notes to dealers about known repair procedures. They are not recalls and do not by themselves mean a vehicle has a fault. 4 on record; the latest 4 are shown.
- 10220385Sep 22, 2022Body and structure, Equipment. Wood stiles are delaminating due to the vendor changing the glue used for the wrapped stiles.
- 10196978Jun 9, 2021Electrical system. During production, the FM antenna was not included on the new 32â Connex Entertainment TVs (TMC Part # 484102). These TVs have a built in radio tuner, and the reception will be poor without the…
- 10197977May 19, 2021Transmission and drivetrain, Engine cooling. On your vehicle, the rear axle may contain an inadequate volume of lubricating oil. An inadequate volume of rear axle lubricant may result in rear wheel bearing damage potentially leading to bearing…
- 10197965Feb 18, 2021Engine cooling. On your vehicle, it may be possible that the engine cover insulation does not fully extend to the perimeter of the factory engine cover. In addition, vehicles built on a Ford chassis may have higher…
Other model years of the Thor Motor Coach Windsport
| Year | Complaints | Median mi | Recalls | Crash ★ | MPG | Score (50 = typical) | Trend |
|---|---|---|---|---|---|---|---|
| 2022 | 5 | 14,000 | 1 | — | — | — | Not enough data |
| 2018 | 6 | 9,854 | 5 | — | — | — | Not enough data |
| 2016 | 9 | 14,000 | 8 | — | — | — | Not enough data |
| 2015 | 7 | 8,000 | 7 | — | — | — | Not enough data |
All Thor Motor Coach Windsport model years
Frequently asked questions
How many NHTSA complaints does the 2022 Thor Motor Coach Windsport have?
NHTSA recorded 5 consumer complaints for the 2022 Thor Motor Coach Windsport as of Oct 31, 2026. Complaints are unverified consumer reports and may be duplicated or inaccurate.
What part of the 2022 Thor Motor Coach Windsport is reported most often?
Other or unknown is named most often, in 3 complaints (60% of the total), followed by body and structure with 2.
Has the 2022 Thor Motor Coach Windsport been recalled?
NHTSA lists 1 recall campaign for this model year. To check a specific vehicle, enter its VIN at nhtsa.gov/recalls.
At what mileage are problems with the 2022 Thor Motor Coach Windsport reported?
Among the 1 complaints that include a mileage, the median is 14,000 miles and the middle half falls between 14,000 and 14,000 miles; 100% were filed for vehicles with under 50,000 miles.
About this data. Data from NHTSA (ODI) complaints, recalls, TSBs and investigations, updated Oct 31, 2026. Complaints are unverified consumer reports and may be duplicated or inaccurate.
Complaint counts come from NHTSA’s public complaint database; we count each complaint once. The source records for this vehicle are on nhtsa.gov. Scores and trends are our own summaries of that data, described in the methodology. This page is not legal, safety or repair advice: for a specific vehicle, check its VIN at nhtsa.gov/recalls and ask a qualified mechanic. See an error? Tell us.