2004 Toyota 4RUNNER Technical Service Bulletins

213 technical service bulletins (TSBs) are on record for the 2004 Toyota 4RUNNER. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10133722Mar 31, 2014Vehicle speed control. On July 24, 2013, the settlement of claims for Economic Loss arising from allegations of unintended acceleration was approved. As part of the settlement Toyota will be launching the third phase of a Limited Service Campaign to install Smart Stop technology on March 31, 2014., for the following models:
• 10133716Mar 31, 2014Brakes, Vehicle speed control. As part of the settlement described above, Toyota will install Smart Stop Technology on the above listed model and model year vehicles. This feature will cut engine power in case of simultaneous application of both the accelerator and brake pedal at certain speeds and in certain driving conditions.
• 10131928Feb 5, 2014Equipment, Brakes. A key part to maintain the proper function and safe operation of the vehicle's braking system is to perform a visual inspection when installing brake pads, calipers, and discs. The following recommendations are intended to provide general tips for the inspection and/or installation of Toyota Complete Maintenance Care (TCMC) front brake pads and discs. Always refer to the model specific Repair manual and TIS…
• 10131951Jan 23, 2014Tires. Toyota vehicles are equipped with either conventional or run-flat tires. Sometimes punctures may occur as a result of contact with road debris or other hazards. If a puncture occurs, it may be possible to repair the tire and return it to service. With a conventional tire it is not possible to drive for an extended amount of time with the tire at low pressures as damage to the tire may occur.
• 10131961Jan 14, 2014Air bags. Toyota vehicles are equipped with Supplemental Restraint Systems (SRS), including various airbags and in some models, seat belt pre-tensioners, to help reduce the risk of injury in a collision. If a customer expresses any concerns that the SRS airbags or pre-tensioner devices did not perform as expected (including an unintended deployment event), please follow the steps in the recommendations section below.
• 10131993Dec 19, 2013Visibility (wipers, defrost, mirrors). This bulletin is now obsolete. Please see T-SB-0185-13.
• 10131988Dec 19, 2013Visibility (wipers, defrost, mirrors). The following procedures are recommended during routine maintenance or in the event of a customer concern for wiper performance.
• 10132055Nov 4, 2013Seats, Air bags, Equipment. Beginning in 1998, Toyota introduced side airbags as optional equipment. Toyota does NOT recommend replacement of original seat covers with non-Toyota leather or other seat cover materials on vehicles due to the following: Seat covers NOT recommended by Toyota may affect side airbag performance, in general or in part, during an accident. Modifications that negatively affect side airbag performance can result in…
• 10132136Oct 23, 2013Visibility (wipers, defrost, mirrors). The appearance of spots in tempered glass (when viewed at certain angles) is the result of the heat treating and quick quenching process during manufacturing.
• 10132084Oct 1, 2013Transmission and drivetrain. The purpose of this service bulletin is to provide precautions to follow when installing an automatic transmission/transaxle assembly to avoid MIL ?ON,? shifting issues, and/or transmission damage. Use the information in this bulletin when installing an automatic transmission/transaxle assembly
• 10062013Sep 13, 2013Equipment. Summary to be provided on a future date.
• 10131985Sep 12, 2013Equipment. Some 2004 ? 2014 model year Toyota vehicles may exhibit odors naturally occurring from the HVAC system and/or related environmental factors. Although there is no way to eliminate these odors, follow the General Procedure in this bulletin to minimize the odors experienced.
• 10061622Sep 12, 2013Equipment. Summary to be provided on a future date.
• 10131984Sep 9, 2013Equipment, Brakes. A new Special Service Tool (SST 09709-00002) has been introduced to aid in the inspection procedure for certain vehicles equipped with a floor pedal-type parking brake system. This bulletin references the correct method for installing the Brake Pedal Force Gauge. Refer to the appropriate Repair Manual for parking brake pedal travel inspection and adjustment specification.
• 10061620Sep 9, 2013Brakes. Summary to be provided on a future date.
• 10062051Aug 1, 2013Equipment. Summary to be provided on a future date.
• 10132295Apr 23, 2013Equipment. This bulletin is now obsolete. Please see T-SB-0054-13.
• 10132287Apr 23, 2013Equipment. California (CA), Federal (FED), and 50 State Certified emission control underhood labels (emission labels) may be obtained through your dealership?s Parts Department utilizing standard replacement parts ordering procedures. Follow the guidelines outlined in this bulletin to ensure proper label application.
• 10061567Apr 23, 2013Engine cooling. Summary to be provided on a future date.
• 10132281Apr 4, 2013Body and structure, Back-over prevention (rear camera). If a creak, tick, or rattle noise is heard at the top or bottom of the windshield, or at the top of the rear glass, the source of the noise may be the two stoppers bonded to the top of the windshield/rear glass, or the windshield retainers bonded to the lower edge of the windshield. This bulletin provides the recommended repair procedure to eliminate these types of noises from the windshield/rear glass area.
• 10133822Mar 25, 2013Equipment. Toyota will be sending Safety Recall Follow Up Notices to remind owners whose vehicles have not yet had campaign repair completed. Please note the following information for Regional and PD associates.
• 10133821Mar 25, 2013Equipment. Toyota will be sending Safety Recall Follow Up Notices to remind owners whose vehicles have not yet had campaign repair completed. Please note the following information for Regional and PD associates.
• 10133860Feb 27, 2013Electrical system. The customer is having difficulty changing the multi-display screen from Day Mode. If the multi-display screen is set to Day Mode when the headlights are on, the setting we be memorized when the engine is turned off.
• 10133836Feb 20, 2013Transmission and drivetrain. This bulletin contains general vehicle pulling diagnosis and repair procedures along with specific information to help correct pulling complaints.
• 10133867Feb 7, 2013Equipment. SSTs are key elements to provide your customers with swift and accurate repairs resulting in superior customer satisfaction.
• 10133901Jan 29, 2013Equipment. This bulletin is now obsolete. Please see T-SB-0012-13.
• 10133897Jan 29, 2013Electrical system. Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Bulletins. This bulletin details the Techstream ECU flash reprogramming process and outlines use of the TIS and the CUW.
• 10060841Jan 29, 2013Engine. Summary to be provided on a future date.
• 10133878Jan 2, 2013Electrical system. Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Bulletins. This bulletin details the Techstream ECU flash reprogramming process and outlines use of the Technical Information System (TIS) and the Calibration Update Wizard (CUW). Flash calibration updates…
• 10133974Oct 4, 2012Body and structure. Toyota vehicles are equipped with either conventional or run-flat tires. Sometimes punctures may occur as a result of contact with road debris or other hazards. If a puncture occurs, it may be possible to repair the tire and return it to service. With a conventional tire it is not possible to drive for an extended amount of time with the tire at low pressures as damage to the tire may occur.
• 10061649Oct 4, 2012Tires. Summary to be provided on a future date.
• 10060779Oct 4, 2012Tires. Summary to be provided on a future date.
• 10045140Jun 13, 2012Vehicle speed control. Toyota: accelerator pedal sensor assembly information regarding the inspection, removal, and installation, if lubrication or oil, is applied.
• 10061609Sep 6, 2011Equipment. Summary to be provided on a future date.
• 10042555Sep 6, 2011Air bags, Seats. Toyota: information provided for replacing the seat covers for vehicles equipped with side airbags.
• 10039109May 31, 2011Transmission and drivetrain. Toyota: information on installing manual transmission shift lever or park neutral position switch.
• 10034194Feb 12, 2010Engine cooling. Toyota: engine control. Some model vehicles may exhibit a mil on condition with one or more of the following dtcs-p0442, p0455, or p0456.
• 10034284Feb 4, 2010Engine cooling. Toyota: techstream ecu flash reprogramming procedure. Flash reprogramming allows the ecu software to be updated without replacing the ecu. Flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service bulletins. Model years from 2001-2011.
• 10023698Oct 16, 2007Other or unknown. Customer support program - warranty coverage extension on certain 2004 - early 2005 my 4runner, land cruiser and sienna vehicles equipped with the optional rear (back-up) camera.
• 10021712May 18, 2007Equipment. Hvac blower motor ice build up.
• 10022143Apr 26, 2007Other or unknown. Techstream ecu flash reprogramming procedure.
• 10021180Nov 28, 2006Tires. Direct-type tire pressure warning system diagnostic tips.
• 10017317May 9, 2006Engine cooling. No start in sub-freezing ambient air temperatures.
• 10019668Mar 17, 2006Brakes. Inconsistent or unusual brake feeling.
• 10018272Nov 8, 2005Engine cooling. Malfunction indicator lamp on diagnostic trouble code p2742.
• 10017615Sep 26, 2005Tires. Dismounting tires with direct system pressure sensors.
• 10016953Sep 2, 2005Air bags. Diagnostics - supplemental restraint system. Repair manual correction. 00400-rm100-1u1 '03 toyota 4runner. 00400-rm105-9u1 '04 4runner.
• 10017320Aug 3, 2005Equipment. The blower motor speed does not match the hvac display indication.
• 10017081Jul 28, 2005Steering. Steering flutter field-fix procedure. Some customers may experience a steering flutter condition while driving at highway speeds.
• 10016995Jul 25, 2005Tires. Diagnostics - tire pressure warning system. Repair manual correction. 00400-rm116-5u1. *tt my2004. 00400-rm105-9u1.

← All problems reported for the 2004 Toyota 4RUNNER