2021 Toyota Avalon Technical Service Bulletins

170 technical service bulletins (TSBs) are on record for the 2021 Toyota Avalon. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10208995Feb 1, 2022Seats. TSB: Some 2010 ? 2022 model year Toyota vehicles may exhibit paint stains after the removal of Rapgard?. The paint stains may appear to be under the clear coat but are usually under wrinkles in the Rapgard?. The wrinkles may trap water and cause the paint to stain from the trapped moisture, especially on horizontal surfaces such as the hood, roof, and trunk. Follow the Repair Procedure in this bulletin to address…
• 10207963Jan 28, 2022Electrical system. TSB This Service Bulletin includes guidelines meant to help determine whether to repair or replace a wire harness assembly based on damage type. This Service Bulletin should be used in conjunction with the applicable model and model year Electronic Wiring Diagram (EWD) and/or Repair Manual.
• 10207958Jan 20, 2022Electrical system. TT: Some customers may experience the inability to activate Remote Connect or Remote Connect becoming inoperative when attempting to send commands to the vehicle. To simplify the diagnosis of this system and prevent the unnecessary replacement of parts, please refer to the procedure below.
• 10207946Jan 12, 2022Wheels, Tires, Equipment. POL: This consolidated Tire Warranty Guide contains the complete warranty terms for all brands of ground and spare tires currently in use by Toyota. This information must be kept near the point of vehicle sale and be available to any customer that requests it. Customers can find this information on the Owner?s section of Toyota.com. Dealers can locate a copy of this guide on the Claims Processing & Resource Center…
• 10206530Dec 20, 2021Electrical system, Equipment. TT: Some 19CY LG DCM equipped vehicles may not be able to complete the firmware update due to not having an active account or waived services during the trial. Follow the steps below to enable ?Temp DCM Activation?.
• 10206528Dec 17, 2021Electrical system, Engine, Equipment. TSB: Some 2018 ? 2022 model year Toyota vehicles equipped with an A25A-FKS, A25A-FXS, or M20A-FKS engine may exhibit one or more of the following conditions: ?Milky/Discolored engine oil. ?An ?Oil Pressure Low? warning message on the Multi-information Display (MID). ?A MIL ON condition with Diagnostic Trouble Codes (DTCs) P05202A (Engine Oil Pressure Sensor/Switch "A" Signal Stuck in Range) and/or P052477 (Engine…
• 10204571Nov 23, 2021Body and structure. TSB: Some 2005 ? 2022 model year Toyota vehicles that have undergone water intrusion may exhibit a condition in which a musty smell is present. Follow the procedures in this bulletin to remediate the odor and address this condition. The purpose of this service bulletin is to provide general guidelines and procedures for odor remediation.
• 10204570Nov 23, 2021Suspension. TT: Vehicle has an abnormal noise condition when going over speed bumps or irregular roads. Noise is coming from front shock absorber
• 10204561Nov 12, 2021Suspension. TT: Vehicle has an abnormal noise condition when going over speed bumps or irregular roads. Noise is coming from front shock absorber
• 10204549Oct 29, 2021Engine cooling. TT: Some 2021-2022 TMMK built vehicles with A25A-FKS/FXS engines may exhibit an oil leak from the No.2 Oil Pan. This issue is currently under investigation.
• 10203559Oct 22, 2021Equipment. TSB: 2022 model year Toyota vehicles are equipped with driver side floor mat retainers to secure the floor mat in the correct position. In addition, some models may also utilize retainers for passenger side and rear seat floor mats. During Pre-Delivery Service (PDS), follow the appropriate Installation Procedure to attach the driver side, and if applicable, the passenger side and rear seat floor mats to the vehicle…
• 10203552Oct 14, 2021Equipment. OBSOLETE NOTICE October 14, 2021: This bulletin is now obsolete. Please see T-SB-0089-21.
• 10203549Oct 14, 2021Equipment. TSB: Some 2020 model year Camry, Camry Hybrid, Corolla Hatchback, RAV4, and RAV4 Hybrid vehicles may exhibit one or more of the following conditions: ?Diagnostic Trouble Code (DTC) B15A804 is present in current or history. ?Red SOS LED stays on after bulb check. ?Toyota App does not accept the activation code. ?Toyota App is inoperative. ?SOS call center does not receive the vehicle?s location in a timely manner…
• 10202452Sep 3, 2021Visibility (wipers, defrost, mirrors), Lane departure. TT: When used in conjunction with the Repair Manual, these Blind Spot Monitor, Forward Recognition Camera, and Front Millimeter Wave Radar tips leverage SSTs and readily available tools to support target placement in varying shop environments.
• 10201400Jul 26, 2021Equipment. TSB: Some 2006 ? 2022 model year Toyota vehicles in particular geographic areas may exhibit a condition where the HVAC evaporator drain hose has become obstructed with an insect nest. An insect repellent drain hose tip (ARINIX® Tip) is available to help minimize future occurrences of this environmental condition. For some models, a new drain hose is required to properly fit the ARINIX® Tip. Follow the procedures in…
• 10201352Jul 6, 2021Transmission and drivetrain. TT: Some 2014-2021 model year vehicles equipped with Dynamic Torque Control AWD system may experience a ?Noise? or ?Abnormal Operation? condition from the rear differential front coupling. In some cases, even an ?AWD System Message? with or without a DTC may be present with or without other conditions present.
• 10201351Jul 6, 2021Equipment. TSB: Long-term or off-site storage requires special care to keep vehicles factory fresh and ready for delivery. The following guidelines should be performed to minimize vehicle component/part degradation due to extended vehicle storage conditions. Long-term storage can affect a vehicle?s systems and components. Any problems that are found should be corrected immediately.
• 10198155May 27, 2021Equipment. TSB: 2022 model year Toyota vehicles are equipped with driver side floor mat retainers to secure the floor mat in the correct position. In addition, some models may also utilize retainers for passenger side and rear seat floor mats. During Pre-Delivery Service (PDS), follow the appropriate Installation Procedure to attach the driver side, and if applicable, the passenger side and rear seat floor mats to the vehicle…
• 10198154May 27, 2021Tires, Wheels. TSB During the manufacturing process, tires are mounted on the vehicle as matched sets to help reduce conditions such as pulling or drifting. If the wheels are replaced or refinished before vehicle delivery, it is important that the tires remain on the vehicle in the same location and in the same direction of rotation. Refer to the Tire Positioning Procedure in this bulletin to ensure that the original tires stay…
• 10198150May 24, 2021Equipment. Updates to the 2014-2021 toyota universal flat rate manual
• 10198127May 7, 2021Electrical system, Equipment. TT: To assist with the early detection and early resolution of audio related concerns, it may be requested as part of the remanufactured head unit return to recover MMR data from the head unit. The following steps are instructions on how to retrieve the data from the system and are only to be used when requested by audio suppliers, FTS, and/or FPEs.
• 10198104May 3, 2021Equipment, Electrical system. TSB: Some 2020 ? 2021 model year vehicles equipped with Audio, Audio Plus, or Premium Audio (versions 1784) or earlier may exhibit one or more of the following conditions: ?Intermittent blank screen. ?Navigation map update fails. ?Album art inoperative. ?Pause function intermittently inoperative in CD mode. ?Intermittent DTC B15FE present. ?Abnormal energy flow screen appearance on Hybrid models. ?Abnormal phone…
• 10190461Mar 22, 2021Equipment. TSB: This Service Bulletin provides a procedure to properly perform the Techstream ?Control the Injection Mode? active test in some 2016 ? 2021 model year Toyota vehicles equipped with an FKS engine.
• 10190460Mar 17, 2021Air bags. Toyota Safety Recall and Service Campaign - Technician Certification Requirements
• 10190448Mar 5, 2021Seats. TSB: Some 2010 ? 2021 model year Toyota vehicles may exhibit paint stains after the removal of Rapgard?. The paint stains may appear to be under the clear coat but are usually under wrinkles in the Rapgard?. The wrinkles may trap water and cause the paint to stain from the trapped moisture, especially on horizontal surfaces such as the hood, roof, and trunk. Follow the Repair Procedure in this bulletin to address…
• 10188917Feb 9, 2021Transmission and drivetrain. TSB: Some 2021 model year Avalon, Highlander, and Camry vehicles equipped with UA80E or UA80F transmissions may exhibit a whine or grind noise from the transmission. This condition may be caused by an issue with the front carrier assembly pinion shafts. Follow the Repair Procedure in this bulletin to address this condition.
• 10188913Feb 3, 2021Equipment. TSB: Replacement certification labels (the vinyl label installed on the driver door or door post) and VIN plates (the metal plate riveted to dashboard) (see Figure 1) for most 1979 ? 2021 model year vehicles may be available provided the requests meet the criteria listed in this Service Bulletin. Follow the Procurement Procedure in this bulletin to request a replacement certification label or VIN plate.
• 10187269Jan 25, 2021Electrical system. TSB: Some 2020 model year Camry, Camry Hybrid, Corolla Hatchback, RAV4, and RAV4 Hybrid vehicles may exhibit one or more of the following conditions: ?Diagnostic Trouble Code (DTC) B15A804 is present in current or history. ?Red SOS LED stays on after bulb check. ?Toyota App does not accept the activation code. ?Toyota App is inoperative. ?SOS call center does not receive the vehicle?s location in a timely manner…
• 10187264Jan 20, 2021Back-over prevention (rear camera). TT: Vehicle control apps might not operate as expected at times due to preconditions (normal operating parameters) not being established, vehicle settings and/or network/cellular coverage concerns.
• 10187273Jan 5, 2021Electrical system, Air bags. TSB: Some 2019 ? 2021 model year Avalon and Avalon Hybrid vehicles may exhibit a condition where the driver side and/or passenger side LED parking lights do not fully illuminate when the headlight switch and the engine are on and the vehicle is in reverse. Follow the Repair Procedure in this bulletin to address this condition.
• 10187239Dec 14, 2020Electrical system. TSB: Some 2020 model year Camry, Camry Hybrid, Corolla Hatchback, RAV4, and RAV4 Hybrid vehicles may exhibit one or more of the following conditions: ?Diagnostic Trouble Code (DTC) B15A804 is present in current or history. ?Red SOS LED stays on after bulb check. ?Toyota App does not accept the activation code. ?Toyota App is inoperative. ?SOS call center does not receive the vehicle?s location in a timely manner…
• 10186193Dec 14, 2020Electrical system, Equipment. TSB: Some 2020 model year Camry, Camry Hybrid, Corolla Hatchback, RAV4, and RAV4 Hybrid vehicles may exhibit one or more of the following conditions: ?Diagnostic Trouble Code (DTC) B15A804 is present in current or history. ?Red SOS LED stays on after bulb check. ?Toyota App does not accept the activation code. ?Toyota App is inoperative. ?SOS call center does not receive the vehicle?s location in a timely manner…
• 10184554Nov 19, 2020Electrical system. TSB: Some 2020 ? 2021 model year C-HR, RAV4, RAV4 HV, Sequoia, Tundra and 2021 model year Avalon, Avalon HV, Prius, Prius Prime, and RAV4 Prime vehicles may exhibit inoperative Apple CarPlay® with all iPhone® 12 models. An updated USB port is available to address this condition. Follow the Repair Procedure in this bulletin to address this condition.
• 10184549Nov 13, 2020Equipment, Electrical system. TT: Some vehicles may experience an issue related to the DCM, the following information is consolidating the available diagnostic information in one document.
• 10184539Nov 2, 2020Electrical system, Equipment. TSB: This bulletin includes basic procedures for performing an at battery rescue charge on high voltage (HV) Ni-MH and Li-ion batteries. This bulletin should be used in conjunction with the applicable model and model year Repair Manual while performing the battery rescue charge. The GRX-5100 should be used wherever the Repair Manual references the Toyota Hybrid System (THS) charger.
• 10183286Oct 22, 2020Electrical system, Other or unknown. TT: Some 2020 ? 2021 model year C-HR, RAV4, RAV4 HV, Sequoia, Tundra and 2021 model year Avalon, Avalon HV, Prius, Prius Prime, and RAV4 Prime vehicles may exhibit inoperative Apple CarPlay® with only iPhone® 12 devices (iPhone® 12, iPhone® 12 Max, iPhone® 12 Pro, or iPhone® 12 Pro Max).
• 10183284Oct 22, 2020Electrical system. TSB: An initialization procedure is required to activate the Entune? 3.0 App Suite Connect for Audio, Audio Plus, and Premium Audio head units before they are used for the first time on new vehicles. The initialization procedure may also be performed under other circumstances, such as following a head unit replacement or after the customer?s personal settings are erased.
• 10183283Oct 22, 2020Wheels, Other or unknown. TSB: During the manufacturing process, tires are mounted on the vehicle as matched sets to help reduce conditions such as pulling or drifting. If the wheels are replaced or refinished before vehicle delivery, it is important that the tires remain on the vehicle in the same location and in the same direction of rotation. Refer to the Tire Positioning Procedure in this bulletin to ensure that the original tires stay…
• 10183282Oct 22, 2020Equipment. TSB: A battery in a stored vehicle is subject to conditions that can reduce its performance and service life. These conditions include storage period, temperature, parasitic drain, and battery load. Because of these factors, battery inspection and maintenance are required in order to ensure proper operation and optimal battery life. As a matter of policy, Toyota does not provide battery warranty coverage for…
• 10183281Oct 21, 2020Engine cooling. TT: HVAC drain tube is found to be blocked/clogged.
• 10183280Oct 21, 2020Back-over prevention (rear camera). TT: During recent discharged battery cases on vehicles equipped with LG DCM, there was confusion if a DCM update was available. Technicians are relying on the Techstream Healthcheck to determine if an update is possible.
• 10183273Oct 20, 2020Equipment. TSB: Long-term or off-site storage requires special care to keep vehicles factory fresh and ready for delivery. The following guidelines should be performed to minimize vehicle component/part degradation due to extended vehicle storage conditions. Long-term storage can affect a vehicle?s systems and components. Any problems that are found should be corrected immediately.
• 10183188Oct 16, 2020Equipment, Engine cooling. TSB: This Service Bulletin provides updated non-electric water pump leak inspection and diagnostic tips for some 2008 ? 2021 model year Toyota vehicles.
• 10182981Oct 9, 2020Equipment. TSB: 2021 model year Toyota vehicles are equipped with driver side floor mat retainers to secure the floor mat in the correct position. In addition, some models may also utilize retainers for passenger side and rear seat floor mats. During Pre-Delivery Service (PDS), follow the appropriate Installation Procedure to attach the driver side, and if applicable, the passenger side and rear seat floor mats to the vehicle…
• 10179702Aug 7, 2020Engine. TT: The Toyota Quality group is looking to better understand our customers expectation regarding vehicle drivability. Specifically, we are looking at vehicle surge/hesitation condition (inconsistent acceleration) and would like to recover detailed customer voice and vehicle data.
• 10179606Aug 7, 2020Engine, Equipment. TT: The Toyota Quality group is looking to better understand our customers expectation regarding vehicle drivability. Specifically, we are looking at vehicle surge/hesitation condition (inconsistent acceleration) and would like to recover detailed customer voice and vehicle data.
• 10179699Aug 5, 2020Body and structure, Equipment, Electrical system. TSB: Pre-Delivery Service (PDS) is a critical step in satisfying our new car customers. Customer feedback indicates the following areas deserve special attention when performing PDS: ?Careful inspection for paint chips/scratches and body dents/dings. ?Proper operation of electrical accessories (including interior light, clock, and radio reset). ?Interior cleanliness. ?Proper function of mechanical systems.
• 10179603Aug 5, 2020Body and structure, Electrical system, Equipment. TSB: Pre-Delivery Service (PDS) is a critical step in satisfying our new car customers. Customer feedback indicates the following areas deserve special attention when performing PDS: ?Careful inspection for paint chips/scratches and body dents/dings. ?Proper operation of electrical accessories (including interior light, clock, and radio reset). ?Interior cleanliness. ?Proper function of mechanical systems.
• 10179690Aug 3, 2020Equipment. TSB: OBSOLETE NOTICE August 3, 2020: This bulletin is no longer applicable and is now obsolete.
• 10179594Aug 3, 2020Equipment. TSB: OBSOLETE NOTICE August 3, 2020: This bulletin is no longer applicable and is now obsolete.

← All problems reported for the 2021 Toyota Avalon