2007 Toyota Highlander Technical Service Bulletins

171 technical service bulletins (TSBs) are on record for the 2007 Toyota Highlander. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10132281Apr 4, 2013Body and structure, Back-over prevention (rear camera). If a creak, tick, or rattle noise is heard at the top or bottom of the windshield, or at the top of the rear glass, the source of the noise may be the two stoppers bonded to the top of the windshield/rear glass, or the windshield retainers bonded to the lower edge of the windshield. This bulletin provides the recommended repair procedure to eliminate these types of noises from the windshield/rear glass area.
• 10133860Feb 27, 2013Electrical system. The customer is having difficulty changing the multi-display screen from Day Mode. If the multi-display screen is set to Day Mode when the headlights are on, the setting we be memorized when the engine is turned off.
• 10133836Feb 20, 2013Transmission and drivetrain. This bulletin contains general vehicle pulling diagnosis and repair procedures along with specific information to help correct pulling complaints.
• 10133867Feb 7, 2013Equipment. SSTs are key elements to provide your customers with swift and accurate repairs resulting in superior customer satisfaction.
• 10133901Jan 29, 2013Equipment. This bulletin is now obsolete. Please see T-SB-0012-13.
• 10133897Jan 29, 2013Electrical system. Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Bulletins. This bulletin details the Techstream ECU flash reprogramming process and outlines use of the TIS and the CUW.
• 10133917Jan 10, 2013Electrical system. technicians should confirm the following key points to minimize the potential for future MIL "ON" concerns after HV Battery Replacement.
• 10133915Jan 3, 2013Air bags. Toyota vehicles are equipped with SRS, including various airbags and in some models, seat belt pre-tensioners, to help reduce the risk of injury in a collision. If a customer expresses any concerns that the SRS airbags or pretensioner devices did not perform as expected, please follow the steps in the recommendations section below.
• 10133878Jan 2, 2013Electrical system. Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Bulletins. This bulletin details the Techstream ECU flash reprogramming process and outlines use of the Technical Information System (TIS) and the Calibration Update Wizard (CUW). Flash calibration updates…
• 10133974Oct 4, 2012Body and structure. Toyota vehicles are equipped with either conventional or run-flat tires. Sometimes punctures may occur as a result of contact with road debris or other hazards. If a puncture occurs, it may be possible to repair the tire and return it to service. With a conventional tire it is not possible to drive for an extended amount of time with the tire at low pressures as damage to the tire may occur.
• 10061649Oct 4, 2012Tires. Summary to be provided on a future date.
• 10045140Jun 13, 2012Vehicle speed control. Toyota: accelerator pedal sensor assembly information regarding the inspection, removal, and installation, if lubrication or oil, is applied.
• 10042555Sep 6, 2011Air bags, Seats. Toyota: information provided for replacing the seat covers for vehicles equipped with side airbags.
• 10037592Mar 2, 2011Engine cooling. Toyota: there may be damaged cylinder head bolts threads.
• 10034265Apr 19, 2010Engine cooling. Toyota: 2az-fe & 2az-fxe throttle body. Engine control. Provide updated throttle body part number information for certain vehicles. The drain pipe has been eliminated on throttle body service parts.
• 10034284Feb 4, 2010Engine cooling. Toyota: techstream ecu flash reprogramming procedure. Flash reprogramming allows the ecu software to be updated without replacing the ecu. Flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service bulletins. Model years from 2001-2011.
• 10028225May 8, 2009Electrical system. Toyota: multiple warning lights illuminated, vehicle not shifting from park to drive, and other accessories becoming inoperative after vehicle has cold soaked in subfreezing ambient air temperatures. *pe updated 9/23/09.
• 10024893Apr 15, 2008Exterior lighting. Some 2004-07 model year highlander or 2006-07 model year highlander hv vehicles may exhibit a condition where the headlight lens cover and/or headlight bulb is discolored.
• 10022143Apr 26, 2007Other or unknown. Techstream ecu flash reprogramming procedure.
• 10197476May 4, 2001Equipment. Replacement vin plates.
• 10197473Jan 18, 1991Equipment. Product general information.

← All problems reported for the 2007 Toyota Highlander