2010 Toyota Highlander Technical Service Bulletins

331 technical service bulletins (TSBs) are on record for the 2010 Toyota Highlander. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10075792Feb 21, 2013Steering. Summary to be provided on a future date.
• 10133836Feb 20, 2013Transmission and drivetrain. This bulletin contains general vehicle pulling diagnosis and repair procedures along with specific information to help correct pulling complaints.
• 10133835Feb 19, 2013Equipment. Some customers may inquire about the frequency and power output of the Smart Key/Smart Entry systems used on various models. The Smart Key/Smart Entry systems conform to all applicable FCC rules. This bulletin details the applicable specifications for these systems.
• 10061549Feb 19, 2013Electrical system. Summary to be provided on a future date.
• 10133867Feb 7, 2013Equipment. SSTs are key elements to provide your customers with swift and accurate repairs resulting in superior customer satisfaction.
• 10133928Jan 29, 2013Equipment. This communication pertains to a current safety recall being conducted by the Southeast Toyota Distributors LLC (SET). TMS is sending this communication for informational purposes in the event you are contacted by a customer covered by this recall.
• 10133901Jan 29, 2013Equipment. This bulletin is now obsolete. Please see T-SB-0012-13.
• 10133897Jan 29, 2013Electrical system. Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Bulletins. This bulletin details the Techstream ECU flash reprogramming process and outlines use of the TIS and the CUW.
• 10133917Jan 10, 2013Electrical system. technicians should confirm the following key points to minimize the potential for future MIL "ON" concerns after HV Battery Replacement.
• 10133915Jan 3, 2013Air bags. Toyota vehicles are equipped with SRS, including various airbags and in some models, seat belt pre-tensioners, to help reduce the risk of injury in a collision. If a customer expresses any concerns that the SRS airbags or pretensioner devices did not perform as expected, please follow the steps in the recommendations section below.
• 10133878Jan 2, 2013Electrical system. Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Bulletins. This bulletin details the Techstream ECU flash reprogramming process and outlines use of the Technical Information System (TIS) and the Calibration Update Wizard (CUW). Flash calibration updates…
• 10133964Dec 21, 2012Engine. Starting with the 2010 MY, Toyota began a gradual transition to the use of synthetic 0w-20 viscosity engine oil.
• 10133962Dec 7, 2012Engine. Starting with the 2010 MY, Toyota began a gradual transition to the use of synthetic 0w-20 viscosity engine oil.
• 10062011Nov 7, 2012Equipment. Summary to be provided on a future date.
• 10133998Oct 22, 2012Body and structure. Some 2008-2012 model year Highlander and Highlander HV vehicles may exhibit a condition where the Power Back Door does no close properly. The Back Door may get to the fully closed position and then reverse to the open position. In cases where the Power Back Door does not close, a pop or clunk noise may also be heard when the back door latch reaches the striker during the power close function.
• 10133974Oct 4, 2012Body and structure. Toyota vehicles are equipped with either conventional or run-flat tires. Sometimes punctures may occur as a result of contact with road debris or other hazards. If a puncture occurs, it may be possible to repair the tire and return it to service. With a conventional tire it is not possible to drive for an extended amount of time with the tire at low pressures as damage to the tire may occur.
• 10061649Oct 4, 2012Tires. Summary to be provided on a future date.
• 10075922Jun 21, 2012Body and structure. Summary to be provided on a future date.
• 10061594Jun 21, 2012Body and structure. Summary to be provided on a future date.
• 10045140Jun 13, 2012Vehicle speed control. Toyota: accelerator pedal sensor assembly information regarding the inspection, removal, and installation, if lubrication or oil, is applied.
• 10042892Dec 21, 2011Engine cooling. Toyota: on some vehicles, the engine oil cooler pipes may exhibit an oil seepage. Information has been provided regarding this issue.
• 10061633Oct 14, 2011Body and structure. Summary to be provided on a future date.
• 10042555Sep 6, 2011Air bags, Seats. Toyota: information provided for replacing the seat covers for vehicles equipped with side airbags.
• 10041651Aug 23, 2011Body and structure. Toyota: the rear lift glass hatch exhibits a possible condition whereby it fails close properly.
• 10038978Apr 27, 2011Transmission and drivetrain. Toyota: 2008-2011 highlander. There may be an oil leak in the front gears due to a manufacturing process.
• 10038958Apr 7, 2011Fuel system. Toyota: the charcoal cansiter is updated to fix a malfunction light that is on with a stored trouble code.
• 10037962Feb 10, 2011Visibility (wipers, defrost, mirrors). Toyota: when operating the front side window glass there may be a rattle or popping noise. The window may also be inoperative due to damaged window mounting tabs. 2008-2010 highlander. *rm updated 8/10/12.
• 10034924Jun 9, 2010Engine cooling. Toyota: brief engine knock/rattle noise cold startup. Immediately following a cold soak startup, some model vehicles equipped with the 1ar-fe and 2ar-fe engines may exhibit a brief knock/rattle noise from the engine compartment for approximately one second. *pe updated 9/28/11.
• 10034284Feb 4, 2010Engine cooling. Toyota: techstream ecu flash reprogramming procedure. Flash reprogramming allows the ecu software to be updated without replacing the ecu. Flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service bulletins. Model years from 2001-2011.
• 10197476May 4, 2001Equipment. Replacement vin plates.
• 10197473Jan 18, 1991Equipment. Product general information.

← All problems reported for the 2010 Toyota Highlander