2010 Volkswagen CC Technical Service Bulletins

794 technical service bulletins (TSBs) are on record for the 2010 Volkswagen CC. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10124302Mar 26, 2014Engine. Technical Bulletin The use of contaminated gasoline, seasonal fuel changes (summer/winter fuel) or gasoline with a low content of deposit control additives may result in one or more of the following conditions: -Excessive accumulation of deposits on intake valves, intake manifold, fuel injectors and combustion chambers. -Engine runs rough after cold start. -Excessive engine cranking time. -Stumbles while driving…
• 10241342Mar 25, 2014Electrical system, Engine cooling. Electric Coolant Fans Continue to Run after Ignition is OFF
• 10241329Mar 21, 2014Engine. Proper Removal of Engine Cover to Avoid Breakage
• 10124299Mar 21, 2014Engine. Technical Bulletin (Proper Removal of Engine Cover to Avoid Breakage): Pulling on the engine cover in some areas can cause damage. This document informs on the procedure to remove the engine cover.
• 10239818Mar 20, 2014Electrical system. MIL ON, No Start, or Rough Running with DTCs P0087, P0088 or P0191 Stored in ECM Fault Memory (TDI ONLY)
• 10241310Mar 18, 2014Electrical system, Other or unknown. Software Version Management
• 10124303Mar 18, 2014Electrical system. Technical Bulletin This Technical Bulletin details the general process for carrying out a Software Version Management (SVM) software update for any Technical Bulletin (TSB) / Required Vehicle Update (RVU).
• 10055439Mar 18, 2014Steering. Volkswagen: some consumers may complain that the steering is stiff. The yellow and red power steering warning light is illuminated. There may be insufficient steering assistance.
• 10253214Mar 8, 2014Other or unknown, Exterior lighting. Exterior Lights, Moisture Accumulation
• 10239817Mar 7, 2014Electrical system. MIL ON, No Start, or Rough Running with DTCs P0087, P0088 or P0191 Stored in ECM Fault Memory (TDI ONLY)
• 10055769Mar 7, 2014Fuel system. When diagnosing the condition on rail diesel vehicles if no cause is found it may be necessary to check for particles in the pump.
• 10239591Mar 6, 2014Exterior lighting. Exterior Lights, Moisture Accumulation
• 10124287Mar 6, 2014Exterior lighting. Technical Bulletin (Exterior Lights, Moisture Accumulation): Exterior light assemblies (headlights, taillights, fog lights, turn signals) are vented and may collect moisture on their inner surfaces, depending on humidity and other climatic changes. This document discusses necessary to diagnosis, and potential remedy of the issue.
• 10243008Mar 3, 2014Engine cooling, Electrical system. VW Elsa Newsletter
• 10241264Feb 25, 2014Engine cooling, Fuel system. Fuel Additive to Help Prevent Sporadic Misfire Faults
• 10239202Feb 25, 2014Other or unknown. Quick Reference Update Guide
• 10238034Feb 19, 2014Equipment, Steering. Insufficient Steering Assistance- Warning Light ON
• 10252937Feb 14, 2014Electrical system. Vehicles equipped with Immobilizer 4 (Download) ? Adapting Keys after Vehicle Lock Set Replacement
• 10237761Feb 14, 2014Electrical system, Equipment. When replacing the complete vehicle lock set (all vehicle keys and lock cylinders) for any reason, be aware that the ?Adapt keys? test plan will not allow the new keys to adapt to the vehicle. Instead, perform the test plan for ?New identity?. During this test plan, make the appropriate selection to indicate only the lock set has been replaced, as shown below in figures 1 and 2.
• 10239841Feb 6, 2014Transmission and drivetrain. DTC P2711 Implausible Transmission Shift Sequence Stored in the Transmission Control Module
• 10055442Feb 6, 2014Transmission and drivetrain. Volkswagen: some vehicles may experience an implausible transmission shift sequence stored in the transmission control module. There may be a lack of mobility upon start up and shifting complications. Stored dtc p2711. Also included jetta wagon model year 2009 and jetta sportwagen/golfwagon model years 2010-2012.
• 10241265Jan 27, 2014Engine cooling, Fuel system. Fuel Additive to Help Prevent Sporadic Misfire Faults
• 10239789Jan 24, 2014Electrical system, Visibility (wipers, defrost, mirrors), Other or unknown. To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. The check must be performed with the engine running and heated rear window switched on. Switch OFF the ignition and visually locate the damage. Proceed with checking any other lines as necessary. Once the damaged line is identified, repair utilizing the Repair kit by Permatex® ITEM…
• 10238937Jan 24, 2014Transmission and drivetrain, Engine cooling. Install a vacuum gauge on the dipstick tube and check crankcase vacuum at idle. Compare to a known good vehicle. If the vacuum reading is lower than the comparison vehicle, visually inspect for oil leaks between the engine and the transmission. Smoke test the crankcase by connecting the EVAP smoke machine to the dipstick tube and inspect for leaks at the rear main seal (this will limit pressure to 2 PSI). DO NOT…
• 10122240Jan 24, 2014Visibility (wipers, defrost, mirrors). Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. This document informs of how to diagnose the issue and tips on servicing the issue
• 10122237Jan 24, 2014Equipment, Fuel system. Tech Tips (Lean Fuel Trim Readings): This document informs on the procedure to diagnose for issues with excess fuel trim, and what needs to be serviced
• 10121563Jan 24, 2014Transmission and drivetrain. Tech Tips (Lean Fuel Trim Readings): This document informs to recheck the crankcase vacuum at idle. If low, check for additional oil leaks and verify crankcase breather operation (repairing as necessary). Erase the faults and road test 10 miles to recheck operation.
• 10243001Jan 20, 2014Steering, Engine cooling. VW Elsa Newsletter
• 10242339Jan 20, 2014Equipment. VW Elsa Newsletter
• 10238033Jan 15, 2014Steering, Equipment. Insufficient Steering Assistance- Warning Light ON
• 10122249Jan 15, 2014Steering. Technical Bulletin (Insufficient Steering Assistance): A Customer may comment about the following concerns: ? Steering is stiff. ? Yellow and red power steering warning lights on. This document discusses the "Fault Codes" necessary to diagnosis, and potential remedy of the issue. The fault codes for checking warranty coverage for servicing the vehicle are also available.
• 10243029Dec 23, 2013Equipment. VW Elsa Newsletter
• 10242367Dec 23, 2013Electrical system, Equipment, Transmission and drivetrain. VW Elsa Newsletter
• 10209320Dec 23, 2013Engine cooling. VW Elsa Newsletter.
• 10244073Dec 18, 2013Transmission and drivetrain. DTC P2711 Implausible Transmission Shift Sequence Stored in the Transmission Control Module
• 10239840Dec 18, 2013Transmission and drivetrain. DTC P2711 Implausible Transmission Shift Sequence Stored in the Transmission Control Module
• 10157544Dec 18, 2013Transmission and drivetrain. Technical Bulletin (Implausible Transmission Shift Sequence Stored in the Transmission Control Module): Debris in the clutch assembly causing too much drag torque from the multiple clutch. DTC as described may cause shifting concerns and/or a lack of mobility upon initial startup. The production solution to this issue was an updated clutch installed as of March 12, 2010. This document discusses the "Fault Codes"…
• 10155953Dec 18, 2013Transmission and drivetrain. Technical Bulletin (Implausible Transmission Shift Sequence Stored in the Transmission Control Module): Debris in the clutch assembly causing too much drag torque from the multiple clutch. DTC as described may cause shifting concerns and/or a lack of mobility upon initial startup. The production solution to this issue was an updated clutch installed as of March 12, 2010. This document discusses the "Fault Codes"…
• 10244045Dec 9, 2013Electrical system, Other or unknown. Volkswagen Elsa Newsletter
• 10242365Dec 9, 2013Equipment. VW Elsa Newsletter
• 10244072Dec 3, 2013Engine cooling. Rattling Noises from Engine Compartment Area or Exhaust System
• 10239808Dec 3, 2013Back-over prevention (rear camera). Customers may complain of a rattling noise from engine or exhaust area while accelerating from 1800-3000 RPM.
• 10209346Dec 3, 2013Engine. Rattling noises from engine compartmen area or exhaust system.
• 10157543Dec 3, 2013Engine cooling. Technical Bulletin (Rattling Noises from Engine Compartment Area or Exhaust System): Customers may complain of a rattling noise from engine or exhaust area while accelerating from 1800-3000 RPM. In order to complete proper diagnosis and ensure that the noise is coming from the turbocharger use the procedure in this document.
• 10155952Dec 3, 2013Engine cooling. Technical Bulletin (Rattling Noises from Engine Compartment Area or Exhaust System): Customers may complain of a rattling noise from engine or exhaust area while accelerating from 1800-3000 RPM. In order to complete proper diagnosis and ensure that the noise is coming from the turbocharger use the procedure in this document.
• 10242375Nov 25, 2013Equipment, Steering, Visibility (wipers, defrost, mirrors), Engine. VW Elsa Newsletter
• 10238932Nov 15, 2013Equipment. If a needed service part is on back order, upgrade the daily order to a red order and check the ?Car Down? box to escalate the order. If parts assistance is needed, please call 800-767-6552 to speak with a VWGoA Parts Specialist.
• 10238931Nov 15, 2013Equipment. If a needed service part is on back order, upgrade the daily order to a red order and check the ?Car Down? box to escalate the order. If parts assistance is needed, please call 800-767-6552 to speak with a VWGoA Parts Specialist.
• 10212722Nov 15, 2013Equipment. Part ordering
• 10157603Nov 15, 2013Equipment. Tech Tips (All Models 2000-2014 - Part ordering): If a needed service part is on back order, upgrade the daily order to a red order and check the ?Car Down? box to escalate the order. This document informs how to contact VWGoA Parts Specialist for help.

← All problems reported for the 2010 Volkswagen CC