2010 Volkswagen CC Technical Service Bulletins

794 technical service bulletins (TSBs) are on record for the 2010 Volkswagen CC. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10241333Jul 1, 2013Engine cooling. Oil Consumption Measurement
• 10125726Jul 1, 2013Engine cooling. Technical Bulletin (Oil Consumption Measurement): Customer states oil consumption is higher than the Volkswagen oil consumption standard of up to 0.5 quarts per 600 miles, or 0.5 liters per 1000 km. In order to provide effective lubrication and cooling of internal engine components, all internal combustion engines consume a certain amount of engine oil. Oil consumption varies from engine to engine and may change…
• 10240678Jun 28, 2013Fuel system. Install Misfueling Guard
• 10125837Jun 28, 2013Engine cooling. Tech Tips (Equipped with Turbocharged Engine Turbocharger Replacement Tip): If mechanical damage is found to the turbocharger (e.g. damaged compression wheel, loose or broken shaft), it is not enough to just replace the turbocharger. This document informs the procedure of checks for damage.
• 10242398Jun 24, 2013Fuel system, Equipment, Electrical system, Suspension. VW Elsa Newsletter
• 10125832Jun 21, 2013Transmission and drivetrain. Tech Tips (Measure Value Block Request): If a request has been made for several MVBs from a DSG transmission, the test plan "Read measured values for obligation to report" can be selected. This function will retrieve all of the MVBs from the transmission which can be attached to a VTA ticket. This selection is available under Guided Functions or GFF when using VAS-PC, an example is shown below.
• 10239411Jun 18, 2013Engine cooling. Activated Charcoal Filter System, Solenoid Valve 1 -N80- (Canister Purge Valve) Diagnosis
• 10238566Jun 18, 2013Brakes. If mechanical damage is found to the turbocharger (e.g. damaged compression wheel, loose or broken shaft), it is not enough to just replace the turbocharger.
• 10125822Jun 14, 2013Fuel system. Technical Bulletin (High Pressure Fuel Pump Diagnosis): Completing the GFF high pressure pump function test is essential to diagnose proper pump operation and to avoid unnecessary replacements. This document informs how to perform the diagnostic. This document discusses the "Fault Codes" necessary to diagnosis, and potential remedy of the issue. The fault codes for checking warranty coverage for servicing the…
• 10052670Jun 14, 2013Fuel system. Volkswagen: on some vehicles, low fuel stored in ecm pressure, engine would crank but not start long periods without driving, may run rough and/or mil on. All models 2008-2013.
• 10241700Jun 13, 2013Equipment. Perfect Delivery Inspection (PDI) - Technician and Detailer Inspections
• 10125852Jun 13, 2013Equipment. CC Perfect Delivery Inspection (PDI) - Technician and Detailer Inspections: A checklist to insure a customer receives a wonderful delivery of a vehicle that looks, feels, and meets the expectations of a new vehicle that he/she has purchased
• 10237994Jun 10, 2013Transmission and drivetrain. Automatic Transmission Fluid Requirements
• 10125819Jun 10, 2013Transmission and drivetrain. Technical Bulletin (Automatic Transmission Fluid Requirements): At this time, Volkswagen Group of America, Volkswagen Canada do not support or warranty any use of aftermarket universal automatic transmission fluids or the machines used to flush the transmissions. This applies to all standard automatic and DSG transmissions.
• 10253205Jun 7, 2013Other or unknown, Visibility (wipers, defrost, mirrors). Wiper Blade Inspection for Proper Warranty Coding
• 10239582Jun 7, 2013Visibility (wipers, defrost, mirrors). Wiper Blade Inspection for Proper Warranty Coding
• 10125813Jun 7, 2013Visibility (wipers, defrost, mirrors). Technical Bulletin (Wiper Blade Inspection for Proper Warranty Coding): Wiper blade inspection guidelines for wear and tear, outside influence or a factory issue. This document informs what is under coverage for wiper blade issues.
• 10240650Jun 5, 2013Equipment. We would like to inform you that the FAQ for Service Action 20T8 has been revised to include additional information for dealers to share with customers about the misfueling guard.
• 10243068May 28, 2013Equipment. VW Elsa Newsletter
• 10242406May 28, 2013Other or unknown. VW Elsa Newsletter
• 10252932May 24, 2013Steering, Electrical system. Cruise Control Inoperative, Fault B115411 ?Cruise Control Switch Short Circuit to Ground? after J527 Steering Column Control Module Replacement
• 10067115May 24, 2013Vehicle speed control. Summary to be provided on a future date.
• 10241350May 16, 2013Brakes, Fuel system. High Pressure Fuel Pump Diagnosis
• 10052337May 16, 2013Fuel system. Volkswagen: some vehicles may run rough, experience engine crank, or no start. Also included model beetle convertible model years 2008-2013
• 10240677May 15, 2013Engine cooling. Install Misfueling Guard
• 10243066May 13, 2013Equipment. VW Elsa Newsletter
• 10242404May 13, 2013Other or unknown. VW Elsa Newsletter
• 10238961May 10, 2013Equipment, Fuel system. Be aware that fuel lines are color coded on vehicles with return fuel pressure lines. The black line is for fuel pressure supply and the blue line is for fuel pressure return. To verify correct line installation, remove the metal cover exposing the fuel pump flange assembly (generally under the rear seat). Refer to the ELSA Repair Manual for specific location. Check for raised arrows on the flange housing.
• 10238594May 10, 2013Electrical system. When diagnosing a generator charging concern, it is recommended to verify operation of the one way clutch located in the generator pulley (if equipped) before replacing generator assembly. To check the one way clutch, remove the belt from the generator pulley and use a trim removal tool to hold fan blades inside generator, as shown below. When attempting to turn pulley by hand with fan blades held, pulley should…
• 10241286May 9, 2013Engine cooling. Engine, Misfire Diagnostic Aid
• 10052336May 9, 2013Engine. Volkswagen: some vehicles may experience a misfire and/or reduced engine performance.
• 10243065May 6, 2013Equipment. VW Elsa Newsletter
• 10242403May 6, 2013Other or unknown. VW Elsa Newsletter
• 10239213May 6, 2013Equipment. RNS 315 Retrofit
• 10052354May 3, 2013Steering. Volkswagen: steering rack. After replacing the steering rack the fault code 01309 008 is set in abs/esp module. Also included model gti my 2013, model tiguan my 2005-2007, model rabbit my 2005/2011-2013, model eos my 2005/2013, model cc my 2005-2008
• 10243050Apr 22, 2013Equipment. VW Elsa Newsletter
• 10242388Apr 22, 2013Equipment. VW Elsa Newsletter
• 10241349Apr 15, 2013Fuel system, Brakes. High Pressure Fuel Pump Diagnosis
• 10051639Apr 15, 2013Fuel system. Volkswagen: high pressure fuel pump diagnosis. Engine crank, no start after long periods without driving. Engine may run rough, and or mil-on with dtc p0087-low fuel pressure stored in ecm fault memory. Also included model eos year 2013, model git year 2013, model beetle covertible year 2009-2013. *js updated 7/10/13.
• 10252907Apr 12, 2013Equipment. Radio Navigation Unit Security Label
• 10238968Apr 12, 2013Electrical system, Brakes. If fault code 03200 or 16352 is present in the Electromechanical Parking Brake (EPB) module, it may be due to the switch and module not being synchronized.
• 10237731Apr 12, 2013Equipment. When replacing a radio navigation unit, inspect the security labels on both the new and replacement units for damage. If damage is found to a label on either unit, be sure to note this on the repair order along with the reason the radio is being replaced.
• 10238960Apr 8, 2013Other or unknown, Fuel system, Engine cooling. To clear static ECM fault P1250 ?Fuel Level Too Low?, add fuel to vehicle and complete a road test of at least 10 miles. Simply adding fuel without completing a road test may not allow fault to clear.
• 10238959Apr 8, 2013Other or unknown, Fuel system, Engine cooling. To clear static ECM fault P1250 ?Fuel Level Too Low?, add fuel to vehicle and complete a road test of at least 10 miles. Simply adding fuel without completing a road test may not allow fault to clear.
• 10252906Apr 5, 2013Equipment. RNS 510 ? Radio Preset Display
• 10237730Apr 5, 2013Equipment. Be aware that the 24 RNS-510 radio presets are not band dependent, and can be programmed to any mix of AM, FM, or satellite stations. The presets shown on the display will not change when switching between bands.
• 10252900Mar 29, 2013Equipment. GPS Antenna Concerns
• 10252225Mar 29, 2013Equipment. Vehicles Equipped with Bluetooth Hands-Free Phone ? Pairing of Android Phones
• 10237721Mar 29, 2013Equipment. When pairing an Android phone to the Bluetooth system, a few extra steps may be necessary. Follow the instructions below to pair the phone:
• 10253177Mar 27, 2013Other or unknown. Satellite Radio Overview

← All problems reported for the 2010 Volkswagen CC