2010 Volkswagen Golf Technical Service Bulletins

1,129 technical service bulletins (TSBs) are on record for the 2010 Volkswagen Golf. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10239789Jan 24, 2014Electrical system, Visibility (wipers, defrost, mirrors), Other or unknown. To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. The check must be performed with the engine running and heated rear window switched on. Switch OFF the ignition and visually locate the damage. Proceed with checking any other lines as necessary. Once the damaged line is identified, repair utilizing the Repair kit by Permatex® ITEM…
• 10238937Jan 24, 2014Transmission and drivetrain, Engine cooling. Install a vacuum gauge on the dipstick tube and check crankcase vacuum at idle. Compare to a known good vehicle. If the vacuum reading is lower than the comparison vehicle, visually inspect for oil leaks between the engine and the transmission. Smoke test the crankcase by connecting the EVAP smoke machine to the dipstick tube and inspect for leaks at the rear main seal (this will limit pressure to 2 PSI). DO NOT…
• 10122240Jan 24, 2014Visibility (wipers, defrost, mirrors). Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. This document informs of how to diagnose the issue and tips on servicing the issue
• 10122237Jan 24, 2014Equipment, Fuel system. Tech Tips (Lean Fuel Trim Readings): This document informs on the procedure to diagnose for issues with excess fuel trim, and what needs to be serviced
• 10121563Jan 24, 2014Transmission and drivetrain. Tech Tips (Lean Fuel Trim Readings): This document informs to recheck the crankcase vacuum at idle. If low, check for additional oil leaks and verify crankcase breather operation (repairing as necessary). Erase the faults and road test 10 miles to recheck operation.
• 10243001Jan 20, 2014Steering, Engine cooling. VW Elsa Newsletter
• 10121243Jan 20, 2014Equipment. Technical Bulletin (Frozen Charge Air Cooler ? Engine Will Not Start): Document discusses diagnosis Codes necessary to diagnosis, and potential remedy of engine issue. The diagnosis codes for checking warranty coverage for servicing the vehicle are also available
• 10240861Jan 14, 2014Equipment. Please contact VW Helpline before attempting repair
• 10127718Jan 14, 2014Transmission and drivetrain. On-car analysis list of Customer Complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex)
• 10240860Jan 13, 2014Equipment. Please contact VW Helpline before attempting repair
• 10122234Jan 13, 2014Transmission and drivetrain. On-car analysis list of Customer Complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex)
• 10209320Dec 23, 2013Engine cooling. VW Elsa Newsletter.
• 10244073Dec 18, 2013Transmission and drivetrain. DTC P2711 Implausible Transmission Shift Sequence Stored in the Transmission Control Module
• 10239840Dec 18, 2013Transmission and drivetrain. DTC P2711 Implausible Transmission Shift Sequence Stored in the Transmission Control Module
• 10157544Dec 18, 2013Transmission and drivetrain. Technical Bulletin (Implausible Transmission Shift Sequence Stored in the Transmission Control Module): Debris in the clutch assembly causing too much drag torque from the multiple clutch. DTC as described may cause shifting concerns and/or a lack of mobility upon initial startup. The production solution to this issue was an updated clutch installed as of March 12, 2010. This document discusses the "Fault Codes"…
• 10155953Dec 18, 2013Transmission and drivetrain. Technical Bulletin (Implausible Transmission Shift Sequence Stored in the Transmission Control Module): Debris in the clutch assembly causing too much drag torque from the multiple clutch. DTC as described may cause shifting concerns and/or a lack of mobility upon initial startup. The production solution to this issue was an updated clutch installed as of March 12, 2010. This document discusses the "Fault Codes"…
• 10244045Dec 9, 2013Electrical system, Other or unknown. Volkswagen Elsa Newsletter
• 10242365Dec 9, 2013Equipment. VW Elsa Newsletter
• 10244072Dec 3, 2013Engine cooling. Rattling Noises from Engine Compartment Area or Exhaust System
• 10239808Dec 3, 2013Back-over prevention (rear camera). Customers may complain of a rattling noise from engine or exhaust area while accelerating from 1800-3000 RPM.
• 10209346Dec 3, 2013Engine. Rattling noises from engine compartmen area or exhaust system.
• 10157543Dec 3, 2013Engine cooling. Technical Bulletin (Rattling Noises from Engine Compartment Area or Exhaust System): Customers may complain of a rattling noise from engine or exhaust area while accelerating from 1800-3000 RPM. In order to complete proper diagnosis and ensure that the noise is coming from the turbocharger use the procedure in this document.
• 10155952Dec 3, 2013Engine cooling. Technical Bulletin (Rattling Noises from Engine Compartment Area or Exhaust System): Customers may complain of a rattling noise from engine or exhaust area while accelerating from 1800-3000 RPM. In order to complete proper diagnosis and ensure that the noise is coming from the turbocharger use the procedure in this document.
• 10244049Dec 2, 2013Transmission and drivetrain, Other or unknown. On-car analysis list from December 2nd, 2013 please contact VW Helpline before attempting repair
• 10209321Dec 2, 2013Engine, Transmission and drivetrain. On-Car Analysis List.
• 10157594Dec 2, 2013Transmission and drivetrain. On-car analysis list of customer complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex)
• 10155963Dec 2, 2013Transmission and drivetrain. On-car analysis list of customer complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex)
• 10240854Nov 26, 2013Engine cooling, Transmission and drivetrain, Equipment. Please contact VW Helpline before attempting repair
• 10157585Nov 26, 2013Transmission and drivetrain. On-car analysis list of Customer Complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex)
• 10156004Nov 26, 2013Transmission and drivetrain. On-car analysis list of Customer Complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex)
• 10242375Nov 25, 2013Equipment, Steering, Visibility (wipers, defrost, mirrors), Engine. VW Elsa Newsletter
• 10238932Nov 15, 2013Equipment. If a needed service part is on back order, upgrade the daily order to a red order and check the ?Car Down? box to escalate the order. If parts assistance is needed, please call 800-767-6552 to speak with a VWGoA Parts Specialist.
• 10238931Nov 15, 2013Equipment. If a needed service part is on back order, upgrade the daily order to a red order and check the ?Car Down? box to escalate the order. If parts assistance is needed, please call 800-767-6552 to speak with a VWGoA Parts Specialist.
• 10212722Nov 15, 2013Equipment. Part ordering
• 10157603Nov 15, 2013Equipment. Tech Tips (All Models 2000-2014 - Part ordering): If a needed service part is on back order, upgrade the daily order to a red order and check the ?Car Down? box to escalate the order. This document informs how to contact VWGoA Parts Specialist for help.
• 10156008Nov 15, 2013Equipment. Tech Tips (All Models 2000-2014 - Part ordering): If a needed service part is on back order, upgrade the daily order to a red order and check the ?Car Down? box to escalate the order. This document informs how to contact VWGoA Parts Specialist for help.
• 10243034Nov 4, 2013Equipment. VW Elsa Newsletter
• 10242372Nov 4, 2013Visibility (wipers, defrost, mirrors), Equipment. VW Elsa Newsletter
• 10239532Oct 29, 2013Visibility (wipers, defrost, mirrors). HVAC, Unpleasant Odor
• 10157506Oct 29, 2013Equipment. Technical Bulletin (HVAC, Unpleasant Odor): An unpleasant odor is coming from Heating and Ventilation system. Odor mainly occurs after vehicle has been sitting (unused) at least 5 hours and within 20 to 60 seconds after vehicle is first started. Contaminants are effectively neutralized using the AIRCOMATIC? II Ultrasonic Climate System Cleaner (VAS 6189A) or AIRCOMATIC III Ultrasonic Climate System Cleaner (VAS…
• 10155925Oct 29, 2013Equipment. Technical Bulletin (HVAC, Unpleasant Odor): An unpleasant odor is coming from Heating and Ventilation system. Odor mainly occurs after vehicle has been sitting (unused) at least 5 hours and within 20 to 60 seconds after vehicle is first started. Contaminants are effectively neutralized using the AIRCOMATIC? II Ultrasonic Climate System Cleaner (VAS 6189A) or AIRCOMATIC? III Ultrasonic Climate System Cleaner (VAS…
• 10243041Oct 28, 2013Equipment. VW Elsa Newsletter
• 10242379Oct 28, 2013Engine cooling, Transmission and drivetrain. VW Elsa Newsletter
• 10238950Oct 25, 2013Engine cooling. Inspect the water pump for signs of contact with engine oil. Engine oil may cause the water pump gasket to swell, which may lead to a coolant leak. If water pump replacement is necessary, ensure that any engine oil is thoroughly cleaned off, prior to water pump installation. Please note that when replacing the water pump or opening the cooling system, there is a special bleed procedure that has to be performed…
• 10238588Oct 25, 2013Electrical system, Engine cooling. Use of aftermarket air filters such as cotton bed steel mesh or cone style, can cause the MAF sensor to not read accurately, affecting vehicle performance and critical monitoring functions for the diesel particulate filter. This can also result in premature DPF failure. Only use factory air filters. The use of aftermarket air filters is not supported as the system was designed and calibrated to work with factory…
• 10157508Oct 25, 2013Engine cooling. Tech Tips (2.0L CCTA/CBFA Coolant Leak or Repeat Coolant Leak from the Water Pump Area): This document informs of the observations that need to be taken to service a water pump replacement
• 10157497Oct 25, 2013Fuel system, Engine. Tech Tips (CBEA, CJAA, CKRA engine codes DPF replacement and/or DTCS P2413, P2463): This document informs of the use of aftermarket air filters such as cotton bed steel mesh or cone style, can cause the MAF sensor to not read accurately, affecting vehicle performance and critical monitoring functions for the diesel particulate filter. This can also result in premature DPF failure. Only use factory air filters.
• 10155915Oct 25, 2013Fuel system, Engine cooling. Tech Tips (CBEA, CJAA, CKRA engine codes DPF replacement and/or DTCS P2413, P2463): This document informs of the use of aftermarket air filters such as cotton bed steel mesh or cone style, can cause the MAF sensor to not read accurately, affecting vehicle performance and critical monitoring functions for the diesel particulate filter. This can also result in premature DPF failure. Only use factory air filters.
• 10155913Oct 25, 2013Engine cooling. Tech Tips (2.0L CCTA/CBFA Coolant Leak or Repeat Coolant Leak from the Water Pump Area): This document informs of the observations that need to be taken to service a water pump replacement
• 10240849Oct 24, 2013Engine cooling, Transmission and drivetrain, Equipment. Please contact VW Helpline before attempting repair

← All problems reported for the 2010 Volkswagen Golf