2005 Volkswagen GTI Technical Service Bulletins

177 technical service bulletins (TSBs) are on record for the 2005 Volkswagen GTI. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10050079Dec 3, 2012Engine cooling. Volkswagen:evaporative (evap) emission system, diagnostic trouble code diagnosis. Revised procedure developed to test evap system without fuel cap.
• 10157732Oct 1, 2012Electrical system. Body/Infotainment Module Software Updates: This document informs of various complaints that were addressed in software updates, and technical bulletins.
• 10156127Oct 1, 2012Equipment, Electrical system. Body/Infotainment Module Software Updates: This document informs of various complaints that were addressed in software updates, and technical bulletins.
• 10043602Feb 10, 2012Engine cooling. Volkswagen: gasoline engines have rough idle, have significant loss of power or stalling with reduced performance.
• 10041250Jun 6, 2011Transmission and drivetrain, Steering. Volkswagen: the gear box has a momentarily delay while accelerating.
• 10253213Feb 14, 2011Exterior lighting, Other or unknown. Exterior Lights, Moisture Accumulation
• 10239590Feb 14, 2011Exterior lighting. Exterior Lights, Moisture Accumulation
• 10036493Sep 30, 2010Other or unknown. Volkswagen: child restraint latch guidance fixture; compliance with fmvss 225 (usa only). Update to existing technical bulletin. No production change required. All models.
• 10036467Aug 9, 2010Exterior lighting, Electrical system. Volkswagen: headlights may intermittently dim slightly at idle. The headlamps or inside lights intermittently dim slightly at idle speed. At idle speed the alternator voltage can fluctuate, as the alternator cannot fully compensate the fluctuations. Golf & wagon gti, new beetle & convertible, eos, jetta & wagon & sportwagon, rabbit, r32, tiguan.
• 10035204Aug 9, 2010Electrical system, Exterior lighting. Volkswagen: headlights may intermittently dim slightly at idle. At idle speed the alternator voltage can fluctuate, as the alternator cannot fully compensate the fluctuations. Some electric consumers come on in cycles or have no constant current consumption, which amplifies this effect. The load condition of the vehicle battery can also influence this effect. Models golf, gti, new beetle & convertible, eos, jetta…
• 10036496Aug 1, 2010Engine cooling, Electrical system. Volkswagen: gasoline engine vehicles inspect, and if necessary, replace ignition coils. Vehicles affected by this action may have ignition coils that could malfunction under certain conditions. Models passat and wagon; golf; gti; jetta and wagon; new beetle and convertible; phaeton; eos; rabbit, etc.
• 10033216Jul 1, 2010Electrical system, Engine cooling. Volkswagen: (revised) vehicles may have ignition coils that could malfunction under certain conditions. If this happens, the malfunction indicator lamp (mil) will illuminated to let you know that vehicle may experience some deterioration in performance. In some cases, a malfunctioning ignition coil may cause a vehicle to exceed federal and/or california emissions standards. 2001-2007 passa/passat wagon. *pe updated…
• 10237716Nov 13, 2009Equipment. The streaming music feature on vehicles equipped with factory or dealer installed Bluetooth will be available only in certain instances. The vehicle must be equipped with the RCD 310 or RCD 510 (Premium 8) radios or the RNS 510 or RNS 315 navigation systems. The Bluetooth system must be either the UHV low (9W2), UHV?NAR (9W7 or 9ZR) factory installed systems or the Volk ? L dealer installed system.
• 10033207Oct 28, 2009Electrical system, Engine cooling. Volkswagen: vehicles may have ignition coils that could malfunction under certain conditions. If this happens, the malfunction indicator lamp (mil) will illuminated to let you know that the vehicle may experience some deterioration in performance. In some cases, a malfunctioning ignition coil may cause a vehicle to exceed federal and/or california emissions standards. No models listed.
• 10033286Aug 26, 2009Exterior lighting. Volkswagen: high intensity gas discharge lamp (hid) range control motor replacement for fault 01534 or 01535. When repairing auto leveling system for faults 01534 or 01535, range control adjustment motor failure, it is not necessary to replace headlight assembly. Range control adjustment motors are serviceable through etka.
• 10031384Jun 1, 2009Seats. Volkswagen service campaign: see document search button for owner letter. Revised expiration dates for seat heater customer satisfaction campaigns. Affected vehicles may have a seat heater element than can malfunction when the ignition switch is on and the seat heater switch is on. Models vv00 and vz00, m200 and m300, and r200 and r300, extended til 6/30/10 (vv, vz, m2, m3) and 9/30/10 (r2 and r3). Csc letters has…
• 10025927Jun 1, 2009Seats. Volkswagen: certain vehicles equipped with comfort seats; install new passenger side seat heater switch. This include jetta wagon. *pe updated 3/23/09. Revision to customer satisfaction campaigns for seat heaters. *pe updated 3/17/10.
• 10025926Jun 1, 2009Seats. Customer satisfaction campaign circular: certain vehicles equipped with comfort seats: install driver's side seat heater repair kit. *pe updated 3/23/09. Revision to customer satisfaction campaign. *pe updated 3/17/10.
• 10238964Feb 6, 2009Steering, Air bags, Electrical system, Brakes. If, after replacement of the steering rack, fault code 01309 008 is set in the ABS/ESP module only, follow the test plan in GFF for Driver Steering Recommendation (DSR) or channel 3 activation. If the test plan fails to clear the fault, follow the direction below using Vehicle Self Diagnosis in Address Word 44 - Steering Assistance
• 10026848Aug 28, 2008Engine cooling, Body and structure. Volkswagen: exhaust heat shield, replacement guidelines. Heat shields are to be inspected after completion o any type of repair to the underbody (exhaust system transmission, etc.), and if damaged, replaced.
• 10022576Jun 1, 2007Seats. Customer satisfaction campaign circular. Install driver's side heater repair kit. Seat heater may malfunction when the ignition switch is on. This could cause the heater mat to temporarily overheat and become inoperative.
• 10018809Jun 1, 2007Seats. Customer satisfaction campaign circular - seat heater element can malfunction when the ignition switch is on and the seat heater switch is on. The seat heater mat may temporarily overheat and become inoperative. Install new passenger side seat heater switch. *tt updated 08-21-07.
• 10021951May 23, 2007Seats. Seat heater is inoperative.
• 10021315Jan 11, 2007Engine cooling. Dtc's p1297 (17705) or p1557 (17965) stored in dtc memory. This may be caused by intake hoses leaking (during boost conditions) due to incorrect torque on clamps or improper placement, worn or torn intake hoses.
• 10020720Apr 26, 2006Visibility (wipers, defrost, mirrors). Door windows, may seperate from window regulator clamps.
• 10014558Dec 22, 2005Seats. Comfort seats may have a seat heater element that can malfunction when the ignition switch is on. Customer satisfaction campaign vv.
• 10018810Oct 10, 2005Seats. Comfort seats may have a seat heater element that can malfunction when the ignition switch is on. Customer satisfaction campaign vz.

← All problems reported for the 2005 Volkswagen GTI