2010 Volkswagen Jetta Sportwagen Technical Service Bulletins

922 technical service bulletins (TSBs) are on record for the 2010 Volkswagen Jetta Sportwagen. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10239533Mar 27, 2014Visibility (wipers, defrost, mirrors). HVAC, Unpleasant Odor
• 10124289Mar 27, 2014Equipment. Technical Bulletin (HVAC, Unpleasant Odor): Unpleasant odor is coming from Heating and Ventilation system. Odor mainly occurs after vehicle has been sitting (unused) at least 5 hours and within 20 to 60 seconds after vehicle is first started. Condensation is a normal characteristic in all A/C systems. If odor is noticeable continue to follow this document. Contaminants are effectively neutralized using the…
• 10241311Mar 26, 2014Engine cooling. Gasoline Quality
• 10239528Mar 26, 2014Air bags. Airbag Warning Lamp Illuminated in Instrument Cluster, DTC B101614 Stored in Airbag Control Module
• 10239430Mar 26, 2014Visibility (wipers, defrost, mirrors). Sunroof / Sunshade, Will Not Open
• 10124302Mar 26, 2014Engine. Technical Bulletin The use of contaminated gasoline, seasonal fuel changes (summer/winter fuel) or gasoline with a low content of deposit control additives may result in one or more of the following conditions: -Excessive accumulation of deposits on intake valves, intake manifold, fuel injectors and combustion chambers. -Engine runs rough after cold start. -Excessive engine cranking time. -Stumbles while driving…
• 10124291Mar 26, 2014Electrical system, Body and structure. Technical Bulletin (Sunroof / Sunshade, Will Not Open): The panoramic sunroof, regular sunroof or sunshade cannot be opened. This document discusses the "Fault Codes" necessary to diagnosis, and potential remedy of the issue. The fault codes for checking warranty coverage for servicing the vehicle are also available.
• 10124290Mar 26, 2014Air bags, Electrical system. Technical Bulletin (Airbag Warning Lamp Illuminated in Instrument Cluster): Airbag lamp in instrument cluster may illuminate due to unfastened connector for passenger airbag warning lamp. This document informs on how to diagnose that this issue is taking place
• 10241342Mar 25, 2014Electrical system, Engine cooling. Electric Coolant Fans Continue to Run after Ignition is OFF
• 10241329Mar 21, 2014Engine. Proper Removal of Engine Cover to Avoid Breakage
• 10124299Mar 21, 2014Engine. Technical Bulletin (Proper Removal of Engine Cover to Avoid Breakage): Pulling on the engine cover in some areas can cause damage. This document informs on the procedure to remove the engine cover.
• 10239818Mar 20, 2014Electrical system. MIL ON, No Start, or Rough Running with DTCs P0087, P0088 or P0191 Stored in ECM Fault Memory (TDI ONLY)
• 10124295Mar 20, 2014Engine cooling. Technical Bulletin (No Start, or Rough Running due to Fuel Rail issues): When diagnosing the condition above on a common rail diesel vehicle, if no root cause is found after checking all other components and all GFF diagnostic procedures have been performed, it may be necessary to check for metallic particles in the High Pressure Fuel Pump using the service section of this document.
• 10213843Mar 19, 2014Equipment. Jetta Bluetooth manual coding procedure.
• 10241310Mar 18, 2014Electrical system, Other or unknown. Software Version Management
• 10124303Mar 18, 2014Electrical system. Technical Bulletin This Technical Bulletin details the general process for carrying out a Software Version Management (SVM) software update for any Technical Bulletin (TSB) / Required Vehicle Update (RVU).
• 10253214Mar 8, 2014Other or unknown, Exterior lighting. Exterior Lights, Moisture Accumulation
• 10239817Mar 7, 2014Electrical system. MIL ON, No Start, or Rough Running with DTCs P0087, P0088 or P0191 Stored in ECM Fault Memory (TDI ONLY)
• 10124296Mar 7, 2014Engine cooling. Technical Bulletin (No Start, or Rough Running issues): When diagnosing a MIL ON, no-start or rough running concern on a common rail diesel vehicle, and no root cause is found after following all GFF diagnostic procedures, it may be necessary to check for metallic particles in the High Pressure Fuel Pump. If such an inspection is necessary, the guidelines in this document must be observed when removing the N290…
• 10239591Mar 6, 2014Exterior lighting. Exterior Lights, Moisture Accumulation
• 10124287Mar 6, 2014Exterior lighting. Technical Bulletin (Exterior Lights, Moisture Accumulation): Exterior light assemblies (headlights, taillights, fog lights, turn signals) are vented and may collect moisture on their inner surfaces, depending on humidity and other climatic changes. This document discusses necessary to diagnosis, and potential remedy of the issue.
• 10243008Mar 3, 2014Engine cooling, Electrical system. VW Elsa Newsletter
• 10241264Feb 25, 2014Engine cooling, Fuel system. Fuel Additive to Help Prevent Sporadic Misfire Faults
• 10252937Feb 14, 2014Electrical system. Vehicles equipped with Immobilizer 4 (Download) ? Adapting Keys after Vehicle Lock Set Replacement
• 10237761Feb 14, 2014Electrical system, Equipment. When replacing the complete vehicle lock set (all vehicle keys and lock cylinders) for any reason, be aware that the ?Adapt keys? test plan will not allow the new keys to adapt to the vehicle. Instead, perform the test plan for ?New identity?. During this test plan, make the appropriate selection to indicate only the lock set has been replaced, as shown below in figures 1 and 2.
• 10122258Feb 11, 2014Transmission and drivetrain. On-car analysis list of Customer Complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex)
• 10239841Feb 6, 2014Transmission and drivetrain. DTC P2711 Implausible Transmission Shift Sequence Stored in the Transmission Control Module
• 10241265Jan 27, 2014Engine cooling, Fuel system. Fuel Additive to Help Prevent Sporadic Misfire Faults
• 10240862Jan 27, 2014Equipment. Please contact VW Helpline before attempting repair
• 10127719Jan 27, 2014Transmission and drivetrain. On-car analysis list of Customer Complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex)
• 10239789Jan 24, 2014Electrical system, Visibility (wipers, defrost, mirrors), Other or unknown. To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. The check must be performed with the engine running and heated rear window switched on. Switch OFF the ignition and visually locate the damage. Proceed with checking any other lines as necessary. Once the damaged line is identified, repair utilizing the Repair kit by Permatex® ITEM…
• 10122240Jan 24, 2014Visibility (wipers, defrost, mirrors). Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. This document informs of how to diagnose the issue and tips on servicing the issue
• 10243001Jan 20, 2014Steering, Engine cooling. VW Elsa Newsletter
• 10121243Jan 20, 2014Equipment. Technical Bulletin (Frozen Charge Air Cooler ? Engine Will Not Start): Document discusses diagnosis Codes necessary to diagnosis, and potential remedy of engine issue. The diagnosis codes for checking warranty coverage for servicing the vehicle are also available
• 10240861Jan 14, 2014Equipment. Please contact VW Helpline before attempting repair
• 10127718Jan 14, 2014Transmission and drivetrain. On-car analysis list of Customer Complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex)
• 10240860Jan 13, 2014Equipment. Please contact VW Helpline before attempting repair
• 10122234Jan 13, 2014Transmission and drivetrain. On-car analysis list of Customer Complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex)
• 10243029Dec 23, 2013Equipment. VW Elsa Newsletter
• 10242367Dec 23, 2013Electrical system, Equipment, Transmission and drivetrain. VW Elsa Newsletter
• 10209320Dec 23, 2013Engine cooling. VW Elsa Newsletter.
• 10244073Dec 18, 2013Transmission and drivetrain. DTC P2711 Implausible Transmission Shift Sequence Stored in the Transmission Control Module
• 10239840Dec 18, 2013Transmission and drivetrain. DTC P2711 Implausible Transmission Shift Sequence Stored in the Transmission Control Module
• 10157544Dec 18, 2013Transmission and drivetrain. Technical Bulletin (Implausible Transmission Shift Sequence Stored in the Transmission Control Module): Debris in the clutch assembly causing too much drag torque from the multiple clutch. DTC as described may cause shifting concerns and/or a lack of mobility upon initial startup. The production solution to this issue was an updated clutch installed as of March 12, 2010. This document discusses the "Fault Codes"…
• 10155953Dec 18, 2013Transmission and drivetrain. Technical Bulletin (Implausible Transmission Shift Sequence Stored in the Transmission Control Module): Debris in the clutch assembly causing too much drag torque from the multiple clutch. DTC as described may cause shifting concerns and/or a lack of mobility upon initial startup. The production solution to this issue was an updated clutch installed as of March 12, 2010. This document discusses the "Fault Codes"…
• 10244045Dec 9, 2013Electrical system, Other or unknown. Volkswagen Elsa Newsletter
• 10242365Dec 9, 2013Equipment. VW Elsa Newsletter
• 10244072Dec 3, 2013Engine cooling. Rattling Noises from Engine Compartment Area or Exhaust System
• 10239808Dec 3, 2013Back-over prevention (rear camera). Customers may complain of a rattling noise from engine or exhaust area while accelerating from 1800-3000 RPM.
• 10209346Dec 3, 2013Engine. Rattling noises from engine compartmen area or exhaust system.

← All problems reported for the 2010 Volkswagen Jetta Sportwagen