2010 Volkswagen Jetta Sportwagen Technical Service Bulletins

922 technical service bulletins (TSBs) are on record for the 2010 Volkswagen Jetta Sportwagen. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10242400Mar 11, 2013Equipment, Visibility (wipers, defrost, mirrors), Electrical system, Engine…. VW Elsa Newsletter
• 10252220Mar 8, 2013Equipment. All Vehicles with Bluetooth Phone Kit Installed ? Streaming Audio from Phone to Radio
• 10239822Mar 8, 2013Electrical system, Back-over prevention (rear camera). TDI Common Rail High Pitch Whine Noise after Switching Ignition OFF
• 10242399Mar 4, 2013Electrical system, Equipment, Fuel system, Body and structure. VW Elsa Newsletter
• 10239403Mar 1, 2013Electrical system. If key blade is found to stick or bind when opening or closing, check position of roll pin that secures key blade to mechanism. If roll pin is sticking out on either side (as shown below), do not replace key. Instead, use appropriate sized punch and hammer to drive in the roll pin so that it is flush with edge of mechanism.
• 10125635Feb 22, 2013Equipment. Tech Tips (Technician Helpline Vehicle Check Sheets): When it becomes necessary to open a VW Technician Helpline VTA case while performing diagnosis for a diesel particulate filter, manual transmission repair, or turbocharger concern, it is recommended to complete the related worksheet/check sheet before calling. This document informs where Worksheets/Check Sheets are available on ServiceNet.
• 10125616Feb 22, 2013Engine cooling. Technical Bulletin (Exhaust Pressure Control issues): This document informs that water and road salt can corrode the exhaust flap shaft causing it to stick in open / closed position. The production solution to this issue was Improved parts introduced into production. This document discusses the "Fault Codes" necessary to diagnosis, and potential remedy of the issue. The fault codes for checking warranty coverage…
• 10125612Feb 22, 2013Electrical system. Technical Bulletin (Factory Installed Media-In (MDI), Updated Programming for Various iPod Concerns): The update programming procedure in this document addresses the following concerns: ? Music skips at beginning of track. This document discusses the "Fault Codes" necessary to diagnosis, and potential remedy of the issue. The fault codes for checking warranty coverage for servicing the vehicle are also available.
• 10125649Feb 15, 2013Fuel system, Other or unknown. VOLKSWAGEN DEALERSHIP COMMUNICATION (Upcoming Communication to Owners of 2009-2013 MY Volkswagen TDI Clean Diesel Engine Vehicles Registered in the State of Illinois - Using Biodiesel Fuel Blends): Due to Illinois state tax incentives for biofuels, biodiesel blends of B5 or less may not be available in the State of Illinois. Volkswagen will continue to honor the terms and conditions of Volkswagen Limited Warranties…
• 10125613Feb 15, 2013Electrical system. Technical Bulletin (Bluetooth System Identification): This document informs how to identify the various Bluetooth systems by: ? Visual Identification ? PR Code ? Part Number
• 10125615Feb 11, 2013Air bags. Technical Bulletin (Airbag Warning Lamp Illuminated in Instrument Cluster, DTC B101614 Stored in Airbag Control Module): the airbag lamp in instrument cluster may illuminate due to unfastened connector for passenger airbag warning lamp. This document informs for diagnosis purposes only.
• 10125626Feb 1, 2013Electrical system. Tech Tips (Instrument Cluster Production Mode): During PDI, or after installation of a replacement cluster, ?Pro? may be displayed in place of the odometer. The high beam indicator may be flashing in the instrument cluster as well. This indicates the cluster is in Production mode. Production mode is not the same as ?Transport? mode. This document infroms of the difference between Production, and Transport mode.
• 10239798Jan 18, 2013Air bags, Brakes. If airbag faults B10B300 OR 03551 are stored, DO NOT replace airbag components for these faults, refer to TT45-11-01?.
• 10238941Jan 18, 2013Transmission and drivetrain, Engine cooling. When servicing the timing chain sprocket or removing the vibration damper, be aware that one bolt holds both the vibration damper (harmonic balancer) and the crankshaft timing chain sprocket to the crankshaft. Once the damper is removed, the crankshaft should not be rotated unless special tool spacer T10368 has been installed. The crankshaft timing chain sprocket and spur gear drive on the crankshaft have a…
• 10238940Jan 18, 2013Engine cooling, Transmission and drivetrain. CBFA 2.0T TSI Engine
• 10241263Jan 15, 2013Engine cooling, Fuel system. Fuel Additive to Help Prevent Sporadic Misfire Faults
• 10122244Jan 15, 2013Engine cooling. Technical Bulletin (Fuel Additive to Help Prevent Sporadic Misfire Faults): Fuel quality impacts the operating performance, efficiency and service life of the engine. The use of poor quality fuels may result in deposit build up on the fuel injectors and intake valves. This may result in a rough running condition, sporadic misfires, or cold start misfire faults storing in the ECM fault memory.
• 10241351Jan 14, 2013Fuel system, Brakes. High Pressure Fuel Pump Diagnosis
• 10239839Jan 3, 2013Transmission and drivetrain. DTC P2711 Implausible Transmission Shift Sequence Stored in the Transmission Control Module
• 10241327Jan 2, 2013Engine cooling. Camshaft Adjustment Valve 1 -N205- Diagnosis
• 10157780Nov 14, 2012Equipment. VOLKSWAGEN DEALERSHIP COMMUNICATION (20R9 Service Action Kit Allocation): This document informs of the submission of additional 20R9 kits for dealership?s use. The document instructs parts managers to use the kits to address any affected inventory vehicles, so that the campaign is completed prior to retail sale. The document also informs how additional kits can be ordered.
• 10156182Nov 14, 2012Equipment. VOLKSWAGEN DEALERSHIP COMMUNICATION (20R9 Service Action Kit Allocation): This document informs of the submission of additional 20R9 kits for dealership?s use. The document instructs parts managers to use the kits to address any affected inventory vehicles, so that the campaign is completed prior to retail sale. The document also informs how additional kits can be ordered.
• 10157804Nov 13, 2012Equipment. Warranty Information (Regularly Scheduled Maintenance Interval Time or Mileage Guidelines): The Volkswagen Customer Experience Team has monitored the claims processed through the Carefree Maintenance (CFM) program from its inception. Their findings reveal that, in many cases, the first maintenance interval service (10K) has been claimed multiple times while subsequent maintenance interval services (20K and 30K)…
• 10157750Nov 13, 2012Equipment. VOLKSWAGEN DEALERSHIP COMMUNICATION (20R9 Service Action Kit Allocation): Volkswagen will be sending an additional allocation of 20R9 kits for dealership?s to use. In addition to any customer vehicles showing the 20R9 service action open the kits are to be used to address any affected inventory vehicles, so that the campaign is completed prior to retail sale. This document informs how to acquire additional kits as…
• 10156232Nov 13, 2012Equipment. Warranty Information (Regularly Scheduled Maintenance Interval Time or Mileage Guidelines): The Volkswagen Customer Experience Team has monitored the claims processed through the Carefree Maintenance (CFM) program from its inception. Their findings reveal that, in many cases, the first maintenance interval service (10K) has been claimed multiple times while subsequent maintenance interval services (20K and 30K)…
• 10156149Nov 13, 2012Equipment. VOLKSWAGEN DEALERSHIP COMMUNICATION (20R9 Service Action Kit Allocation): Volkswagen will be sending an additional allocation of 20R9 kits for dealership?s to use. In addition to any customer vehicles showing the 20R9 service action open the kits are to be used to address any affected inventory vehicles, so that the campaign is completed prior to retail sale. This document informs how to acquire additional kits as…
• 10253203Nov 2, 2012Visibility (wipers, defrost, mirrors), Other or unknown. Wiper Blade Inspection for Proper Warranty Coding
• 10239580Nov 2, 2012Visibility (wipers, defrost, mirrors). Wiper Blade Inspection for Proper Warranty Coding
• 10157792Nov 2, 2012Visibility (wipers, defrost, mirrors). Technical Bulletin (Wiper Blade Inspection for Proper Warranty Coding): Wiper blade inspection guidelines for wear and tear, outside influence and factory defect.
• 10156194Nov 2, 2012Visibility (wipers, defrost, mirrors), Equipment. Technical Bulletin (Wiper Blade Inspection for Proper Warranty Coding): Wiper blade inspection guidelines for wear and tear, outside influence and factory defect.
• 10253439Nov 1, 2012Equipment, Engine cooling. Volkswagen Carefree Maintenance Program ? Gasoline Engines (Except Routan) - REVISED
• 10157651Oct 29, 2012Transmission and drivetrain, Equipment. Technical Bulletin (Slave Cylinder - Clutch Pedal Operation Diagnosis): A Customer may comment: ? Complaints on clutch system. ? After pressing the clutch pedal, it remains on the floor. Due to mis-diagnosis of clutch systems, and to prevent incorrect parts replacement, diagnostic procedure implemented into guided fault finding. This document is meant to inform.
• 10156071Oct 29, 2012Transmission and drivetrain, Equipment. Technical Bulletin (Slave Cylinder - Clutch Pedal Operation Diagnosis): A Customer may comment: ? Complaints on clutch system. ? After pressing the clutch pedal, it remains on the floor. Due to mis-diagnosis of clutch systems, and to prevent incorrect parts replacement, diagnostic procedure implemented into guided fault finding. This document is meant to inform.
• 10157629Oct 26, 2012Electrical system, Equipment. Tech Tips (Service Interval Settings after Instrument Cluster Replacement): This document informs that after instrument cluster replacement, service interval maximum values may need to be manually set. To set values manually, use Vehicle self-diagnosis to select 17- Instrument Cluster, then adaptation. Channel ?SIA: maximum value of distance to service? should be set to 16000 km and channel ?SIA: maximum value of…
• 10156048Oct 26, 2012Electrical system. Tech Tips (Service Interval Settings after Instrument Cluster Replacement): This document informs that after instrument cluster replacement, service interval maximum values may need to be manually set. To set values manually, use Vehicle self-diagnosis to select 17- Instrument Cluster, then adaptation. Channel ?SIA: maximum value of distance to service? should be set to 16000 km and channel ?SIA: maximum value of…
• 10157655Oct 25, 2012Body and structure, Equipment. Technical Bulletin (Paint Finish, Reducing Swirl Marks and Fine Scratches): New vehicles (prior to Retail Delivery) with swirl marks and or fine scratches from polishing or cleaning. This document informs of how the Finish can be significantly improved without the use of harsh polishing compounds and high speed buffing.
• 10156059Oct 25, 2012Equipment. Technical Bulletin (Paint Finish, Reducing Swirl Marks and Fine Scratches): New vehicles (prior to Retail Delivery) with swirl marks and or fine scratches from polishing or cleaning. This document informs of how the Finish can be significantly improved without the use of harsh polishing compounds and high speed buffing.
• 10157661Oct 24, 2012Electrical system, Equipment, Visibility (wipers, defrost, mirrors). Technical Bulletin (Sunroof / Sunshade, Will Not Open): The issued of The panoramic sunroof, regular sunroof or sunshade cannot be opened. The sunroof?s ?Basic Setting? has been unintentionally initiated by the customer. This document informs the procedure to reset the settings of the Sunroof / Sunshade so that functionality can be retained. This document discusses the "Fault Codes" necessary to diagnosis, and…
• 10157656Oct 24, 2012Body and structure, Equipment. Technical Bulletin (Hood, Under Hood Not Painted Body Color): The paint color and/or finish of the engine compartment and underside of hood may not match the exterior paint color of the vehicle. Depending on vehicle model and production plant, the color of the engine compartment and underside hood may not match the vehicle body color.
• 10157648Oct 24, 2012Engine cooling, Equipment. Technical Bulletin (TDI Clean Diesel I/M (Inspection Maintenance) Testing Issues due to Readiness Not Set): Some readiness codes on TDI clean diesel vehicles require special driving conditions to be set. If DTCs have been recently erased from the vehicle?s ECM, it may take additional driving under different conditions to fully set OBD readiness parameters. MVB 89 (on non-UDS protocol ECM?s) will store correct data…
• 10156068Oct 24, 2012Fuel system, Engine cooling. Technical Bulletin (TDI Clean Diesel I/M (Inspection Maintenance) Testing Issues due to Readiness Not Set): Some readiness codes on TDI clean diesel vehicles require special driving conditions to be set. If DTCs have been recently erased from the vehicle?s ECM, it may take additional driving under different conditions to fully set OBD readiness parameters. MVB 89 (on non-UDS protocol ECM?s) will store correct data…
• 10156062Oct 24, 2012Visibility (wipers, defrost, mirrors), Electrical system. Technical Bulletin (Sunroof / Sunshade, Will Not Open): The issued of The panoramic sunroof, regular sunroof or sunshade cannot be opened. The sunroof?s ?Basic Setting? has been unintentionally initiated by the customer. This document informs the procedure to reset the settings of the Sunroof / Sunshade so that functionality can be retained. This document discusses the "Fault Codes" necessary to diagnosis, and…
• 10156060Oct 24, 2012Equipment. Technical Bulletin (Hood, Under Hood Not Painted Body Color): The paint color and/or finish of the engine compartment and underside of hood may not match the exterior paint color of the vehicle. Depending on vehicle model and production plant, the color of the engine compartment and underside hood may not match the vehicle body color.
• 10157734Oct 17, 2012Electrical system, Engine. Engine Control Module Updates: This document informs of complaints, and the software updates/Tech Bulletins associated with servicing engine control module issues:
• 10156128Oct 17, 2012Electrical system, Equipment, Engine. Engine Control Module Updates: This document informs of complaints, and the software updates / Tech Bulletins associated with servicing engine control module issues:
• 10157665Oct 8, 2012Electrical system, Equipment. Technical Bulletin (Bluetooth System Identification): This document informs of the method to understand how to identify the various Bluetooth systems by: ? Visual Identification ? PR Code ? Part Number
• 10156066Oct 8, 2012Equipment, Electrical system. Technical Bulletin (Bluetooth System Identification): This document informs of the method to understand how to identify the various Bluetooth systems by: ? Visual Identification ? PR Code ? Part Number
• 10157664Oct 2, 2012Air bags, Electrical system. Technical Bulletin (Airbag Warning Lamp Illuminated in Instrument Cluster, DTC B101614 Stored in Airbag Control Module): This document informs only that Airbag lamp in instrument cluster may illuminate due to unfastened connector for passenger airbag warning lamp.
• 10156065Oct 2, 2012Electrical system, Air bags. Technical Bulletin (Airbag Warning Lamp Illuminated in Instrument Cluster, DTC B101614 Stored in Airbag Control Module): This document informs only that Airbag lamp in instrument cluster may illuminate due to unfastened connector for passenger airbag warning lamp.
• 10157736Oct 1, 2012Electrical system. Updates (RVU): This document informs of the reflashs that took place at specific updated software levels to address the complaints of various cars.

← All problems reported for the 2010 Volkswagen Jetta Sportwagen