2012 Volkswagen Jetta Sportwagen Technical Service Bulletins

1,084 technical service bulletins (TSBs) are on record for the 2012 Volkswagen Jetta Sportwagen. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10238959Apr 8, 2013Other or unknown, Fuel system, Engine cooling. To clear static ECM fault P1250 ?Fuel Level Too Low?, add fuel to vehicle and complete a road test of at least 10 miles. Simply adding fuel without completing a road test may not allow fault to clear.
• 10239832Apr 5, 2013Electrical system. MIL ON, DTC(s) P0671, P0672, P0673 and/or P0674 Stored in ECM Fault Memory
• 10067183Apr 5, 2013Equipment. Summary to be provided on a future date.
• 10240855Apr 2, 2013Equipment, Transmission and drivetrain, Engine cooling. Please contact VW Helpline before attempting repair
• 10144704Apr 2, 2013Transmission and drivetrain. On-car analysis list of customer complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex)
• 10238956Apr 1, 2013Fuel system. When diagnosing a customer concern of fuel gauge not reading full after fueling, start by checking for the presence of a cover over the fuel tank vent as shown in the picture below. Vent is located on filler neck and can be inspected by removing fuel door assembly. If cover is found over vent, inspect for damage to fuel tank and replace tank if needed. Ensure cover is not present on replacement fuel tank.
• 10238017Apr 1, 2013Brakes. Vibration or noise when braking may be due to brake disc corrosion protection which has not been completely removed by normal braking, or surface rust built up during transportation.
• 10238016Apr 1, 2013Brakes. Vibration or noise when braking may be due to brake disc corrosion protection which has not been completely removed by normal braking, or surface rust built up during transportation.
• 10252900Mar 29, 2013Equipment. GPS Antenna Concerns
• 10252225Mar 29, 2013Equipment. Vehicles Equipped with Bluetooth Hands-Free Phone ? Pairing of Android Phones
• 10237721Mar 29, 2013Equipment. When pairing an Android phone to the Bluetooth system, a few extra steps may be necessary. Follow the instructions below to pair the phone:
• 10237720Mar 29, 2013Electrical system. The Bluetooth module has now been integrated into the navigation head unit on 2012-2013 vehicles with RNS 315 navigation part number 1K0 035 274 B or higher. The diagnosis for this system is similar to the 9W7 system. Technical Bulletin 91 11 09 (2026015) can be used for the diagnosis.
• 10253177Mar 27, 2013Other or unknown. Satellite Radio Overview
• 10239554Mar 27, 2013Equipment. Satellite Radio Overview
• 10252905Mar 22, 2013Equipment. MDI Control of Apple Devices with Lightning Connector (iPhone 5, iPad fourth generation, iPod Nano seventh generation)
• 10252227Mar 22, 2013Equipment. Replacement Radio/Navigation Unit has no Sound
• 10239823Mar 22, 2013Electrical system. MIL ON - DTC's P047F, P0477, P048A, P048B, P048C or P0401 Stored in ECM Fault Memory
• 10237729Mar 22, 2013Electrical system. The Apple iPhone 5, iPad fourth generation, and iPod nano seventh generation use a proprietary ?Lightning? connector that is different than the 30 pin dock connector found on previous iPhone and iPod models.
• 10237723Mar 22, 2013Electrical system, Brakes. Replacement RNS 510 radio/navigation units may be shipped in transportation safeguard mode and therefore will have no sound output. In order to switch the unit out of this mode, hold down the forward seek button, the back seek button, and the music button at the same time until the unit shuts down. Once the unit is powered back ?ON? the safeguard mode will be deactivated.
• 10240880Mar 21, 2013Equipment. Please contact VW Helpline before attempting repair
• 10144701Mar 21, 2013Transmission and drivetrain. On-car analysis list of Customer Complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex)
• 10238061Mar 20, 2013Body and structure. Recommended procedure for removing damaged CV boot.
• 10243063Mar 18, 2013Equipment. VW Elsa Newsletter
• 10242401Mar 18, 2013Fuel system, Electrical system, Engine cooling. VW Elsa Newsletter
• 10238031Mar 18, 2013Steering, Electrical system. Poor Power Steering Assistance, DTCs 16344 014, 16353 014, 16355 014, 02614 014 Stored in Power Steering Control Module J500
• 10240879Mar 14, 2013Equipment. Please contact VW Helpline before attempting repair
• 10144702Mar 14, 2013Transmission and drivetrain. On-car analysis list of Customer Complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex)
• 10253483Mar 12, 2013Engine cooling. Engine Exhaust Flap Limited Warranty Extension
• 10240878Mar 12, 2013Equipment. Please contact VW Helpline before attempting repair
• 10144703Mar 12, 2013Transmission and drivetrain. On-car analysis list of Customer Complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex)
• 10242400Mar 11, 2013Equipment, Visibility (wipers, defrost, mirrors), Electrical system, Engine…. VW Elsa Newsletter
• 10252220Mar 8, 2013Equipment. All Vehicles with Bluetooth Phone Kit Installed ? Streaming Audio from Phone to Radio
• 10239822Mar 8, 2013Electrical system, Back-over prevention (rear camera). TDI Common Rail High Pitch Whine Noise after Switching Ignition OFF
• 10242399Mar 4, 2013Electrical system, Equipment, Fuel system, Body and structure. VW Elsa Newsletter
• 10239403Mar 1, 2013Electrical system. If key blade is found to stick or bind when opening or closing, check position of roll pin that secures key blade to mechanism. If roll pin is sticking out on either side (as shown below), do not replace key. Instead, use appropriate sized punch and hammer to drive in the roll pin so that it is flush with edge of mechanism.
• 10069112Mar 1, 2013Equipment. Summary to be provided on a future date.
• 10125617Feb 26, 2013Electrical system. Technical Bulletin (Update Programming - MIL ON, DTC P240F Stored in ECM Fault Memory): The following fault code (P240F) may be stored in the ECM Fault Memory concerning (Exhaust Gas Recirculation Slow Response). This document informs that the Diagnostic strategy is too sensitive when addressing this issue. The production to address this issue was Improved ECM software to address MIL ON complaints.
• 10125635Feb 22, 2013Equipment. Tech Tips (Technician Helpline Vehicle Check Sheets): When it becomes necessary to open a VW Technician Helpline VTA case while performing diagnosis for a diesel particulate filter, manual transmission repair, or turbocharger concern, it is recommended to complete the related worksheet/check sheet before calling. This document informs where Worksheets/Check Sheets are available on ServiceNet.
• 10125616Feb 22, 2013Engine cooling. Technical Bulletin (Exhaust Pressure Control issues): This document informs that water and road salt can corrode the exhaust flap shaft causing it to stick in open / closed position. The production solution to this issue was Improved parts introduced into production. This document discusses the "Fault Codes" necessary to diagnosis, and potential remedy of the issue. The fault codes for checking warranty coverage…
• 10125649Feb 15, 2013Fuel system, Other or unknown. VOLKSWAGEN DEALERSHIP COMMUNICATION (Upcoming Communication to Owners of 2009-2013 MY Volkswagen TDI Clean Diesel Engine Vehicles Registered in the State of Illinois - Using Biodiesel Fuel Blends): Due to Illinois state tax incentives for biofuels, biodiesel blends of B5 or less may not be available in the State of Illinois. Volkswagen will continue to honor the terms and conditions of Volkswagen Limited Warranties…
• 10125613Feb 15, 2013Electrical system. Technical Bulletin (Bluetooth System Identification): This document informs how to identify the various Bluetooth systems by: ? Visual Identification ? PR Code ? Part Number
• 10125615Feb 11, 2013Air bags. Technical Bulletin (Airbag Warning Lamp Illuminated in Instrument Cluster, DTC B101614 Stored in Airbag Control Module): the airbag lamp in instrument cluster may illuminate due to unfastened connector for passenger airbag warning lamp. This document informs for diagnosis purposes only.
• 10125614Feb 8, 2013Electrical system. Technical Bulletin (Update Programming RCD-510 Radio (Premium 8)): Programming contained in software level(s) for certain RCD-510 Radio (Premium 8) radios may cause Bluetooth audio quality complaints for model year 2012, and 2013. The production solution for this issue is a running software change. This document discusses the "Fault Codes" necessary to diagnosis, and potential remedy of the issue. The fault codes…
• 10125626Feb 1, 2013Electrical system. Tech Tips (Instrument Cluster Production Mode): During PDI, or after installation of a replacement cluster, ?Pro? may be displayed in place of the odometer. The high beam indicator may be flashing in the instrument cluster as well. This indicates the cluster is in Production mode. Production mode is not the same as ?Transport? mode. This document infroms of the difference between Production, and Transport mode.
• 10239552Jan 22, 2013Equipment. Update programming RCD-510 Radio (Premium 8)
• 10239798Jan 18, 2013Air bags, Brakes. If airbag faults B10B300 OR 03551 are stored, DO NOT replace airbag components for these faults, refer to TT45-11-01?.
• 10238941Jan 18, 2013Transmission and drivetrain, Engine cooling. When servicing the timing chain sprocket or removing the vibration damper, be aware that one bolt holds both the vibration damper (harmonic balancer) and the crankshaft timing chain sprocket to the crankshaft. Once the damper is removed, the crankshaft should not be rotated unless special tool spacer T10368 has been installed. The crankshaft timing chain sprocket and spur gear drive on the crankshaft have a…
• 10238940Jan 18, 2013Engine cooling, Transmission and drivetrain. CBFA 2.0T TSI Engine
• 10241263Jan 15, 2013Engine cooling, Fuel system. Fuel Additive to Help Prevent Sporadic Misfire Faults
• 10122244Jan 15, 2013Engine cooling. Technical Bulletin (Fuel Additive to Help Prevent Sporadic Misfire Faults): Fuel quality impacts the operating performance, efficiency and service life of the engine. The use of poor quality fuels may result in deposit build up on the fuel injectors and intake valves. This may result in a rough running condition, sporadic misfires, or cold start misfire faults storing in the ECM fault memory.

← All problems reported for the 2012 Volkswagen Jetta Sportwagen