2009 Volkswagen Passat Technical Service Bulletins

753 technical service bulletins (TSBs) are on record for the 2009 Volkswagen Passat. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10124480Aug 22, 2014Steering. Tech Tips (Electro - Steering issues): If, after replacement of the steering rack, fault code 01309 008 is set in the ABS/ESP module only, follow the test plan in GFF for Driver Steering Recommendation (DSR) or channel 3 activation. If the test plan fails to clear the fault, follow the directions in this document
• 10124479Aug 22, 2014Electrical system. Tech Tips (Comfort Module (J393) or BCM (J519) Replacement): This document informs If a comfort or body control module is replaced during normal diagnosis, make sure the factory mode has been switched OFF. This can be accomplished by selecting the test plan through GFF or through Vehicle Self Diagnosis in adaptation channel 99. Failure to deactivate factory mode will create a concern where the door locks will not…
• 10124454Aug 1, 2014Electrical system. Assembly Instructions: Installation of original remote start feature accessory, Volkswagen Passat.
• 10239842Jul 28, 2014Transmission and drivetrain. Slave Cylinder - Clutch Pedal Operation Diagnosis
• 10120233Jul 28, 2014Transmission and drivetrain. Technical Bulletin (Slave Cylinder - Clutch Pedal Operation Diagnosis): Customer may comment: ? Complaints on clutch system. ? After pressing the clutch pedal, it remains on the floor. Due to mis-diagnosis of clutch systems, and to prevent incorrect parts replacement, diagnostic procedure implemented into guided fault finding (GFF). This document is for identifying the issue for diagnosis.
• 10243031Jul 14, 2014Equipment. VW Elsa Newsletter
• 10242369Jul 14, 2014Engine cooling, Equipment. VW Elsa Newsletter
• 10120205Jul 11, 2014Fuel system. Tech Tips (Fuel line connections): Be aware that fuel lines are color coded on vehicles with return fuel pressure lines. The black line is for fuel pressure supply and the blue line is for fuel pressure return.
• 10250695Jul 10, 2014Fuel system. Carefree Maintenance Coverage for Interim Oil Changes for Certain 2009 ? 2015 MY Volkswagen TDI® Clean Diesel Engine Vehicles Registered in the State of Minnesota Only (US Dealers
• 10239233Jul 10, 2014Fuel system. Because Volkswagen supports the development and use of renewable fuels (such as biodiesel fuel blends), customers with certain 2009-2015 MY Volkswagen TDI® Clean Diesel Engine vehicles registered in the State of Minnesota only will receive a communication in July 2014 regarding the use of biodiesel fuel blends in their vehicles.
• 10238600Jul 4, 2014Transmission and drivetrain. Incorrect torque converter or flywheel/flexplate installation can result in transmission damage. When installing an engine, flywheel or transmission, please follow the installation procedures outlined in ELSA. For the flywheel/flexplate, please be certain the correct shim is installed between it and the crankshaft (reference VWIQ120). When installing a torque converter, press the torque converter hub through the…
• 10120207Jul 4, 2014Transmission and drivetrain. Tech Tips (Torque Converter/Flywheel/Flexplate installation): Incorrect torque converter or flywheel/flexplate installation can result in transmission damage. When installing an engine, flywheel or transmission, please follow the installation procedures outlined in ELSA. This document also contains advice on the installation of these devices
• 10238934Jun 20, 2014Fuel system. When replacing or adapting fuel injectors, if there is no Guided Functions Test Plan, utilize the following
• 10238570Jun 20, 2014Fuel system. When replacing or adapting fuel injectors, if there is no Guided Functions Test Plan, utilize the following :UDS vehicles: Go to Guided Functions / Adapting Injector Quantity Adjustment correct values (IMA-IVA).
• 10120149Jun 20, 2014Fuel system. Tech Tips (Adapting Injector Quantity adjustment correction values (IMA/IVA)): When replacing or adapting fuel injectors, if there is no Guided Functions Test Plan, utilize this documents procedure
• 10238972Jun 6, 2014Tires, Wheels. The use of tire dressing gives your tires that shiny finish that completes the image of a clean (new) vehicle. There are many different tire dressing products available. When choosing a product please pay close attention to its contents. Always use a water based product.
• 10120155Jun 6, 2014Wheels, Tires. Tech Tips (All vehicles-Tire dressing for vehicle detailing): The use of tire dressing gives your tires that shiny finish that completes the image of a clean (new) vehicle. This document informs that The use of non-water based products will increase the risk of causing damage to painted surfaces. The document also gives graphical examples of the dame that can occur if non-water based products are used.
• 10253215Jun 4, 2014Exterior lighting, Other or unknown. Exterior Lights, Moisture Accumulation
• 10239592Jun 4, 2014Exterior lighting. Exterior Lights, Moisture Accumulation
• 10120169Jun 4, 2014Exterior lighting, Equipment. Technical Bulletin (Exterior Lights, Moisture Accumulation): This document informs of the Condensation and or water droplets visible on inside of exterior light lenses. The document also informs how to service the issue.
• 10239391May 28, 2014Engine cooling, Transmission and drivetrain. For an upcoming campaign that will include all MY09-14 TDI (CBEA/CJAA) vehicles, we need to test the SVM3339 code in 200 vehicles of various model-years and engine/transmission combinations.
• 10124417May 23, 2014Electrical system. Tech Tips (Engine Control Module Fault P130A ?Hide Cylinder?): This document informs that DTC P130A ?Hide Cylinder? indicates that excessive misfiring has occurred. As a result, the ECM has turned off a fuel injector to prevent catalyst damage. To address this fault, diagnose and repair all misfire concerns that are present. Repairing the other faults will resolve the P130A.
• 10239209May 5, 2014Equipment. Quick Reference Update Guide
• 10124367Apr 29, 2014Electrical system. Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle
• 10239534Apr 18, 2014Visibility (wipers, defrost, mirrors). HVAC, Unpleasant Odor
• 10124340Apr 18, 2014Equipment. Technical Bulletin (HVAC, Unpleasant Odor): Condensation, which is a normal condition in all A/C systems, can cause a musty odor. If the odor is noticeable in the vehicle when the engine is not turned on, the cause may be mold and mildew in the passenger compartment, and not be related to the A/C system. All other possible sources of the odor must be investigated before this document can be performed. This document…
• 10238970Apr 11, 2014Steering. If the steering rack is replaced on the above models for any reason, it is necessary to replace the steering harness as well. The new harness may be equipped with an extra connector. If all connections are made correctly, then it is necessary to remove that connector and tape the exposed wires back into the harness. Be sure to tape tightly in order to provide a water-tight repair.
• 10241266Apr 10, 2014Equipment. Squeaks, Rattles, Noise, Repair Materials
• 10124348Apr 10, 2014Equipment. Technical Bulletin (Squeaks, Rattles, Noise, Repair Materials): This doucment contains a list of components and applications developed to repair concerns of squeaks, rattles, noise and trim fit conditions.
• 10252915Apr 4, 2014Equipment. MDI Functions with iPhone 5 Variants (5, 5c, 5s and iPad fourth generation, iPod Nano seventh generation)
• 10124374Apr 4, 2014Electrical system. Tech Tips (MDI Functions with iPhone 5 Variants (5, 5c, 5s and iPad fourth generation, iPod Nano seventh generation)): The Apple iPhone 5, iPhone 5c, and iPhone 5s, as well as the iPad 4th generation and iPod Nano 7th generation use a proprietary ?Lightning? connector that is different than the 30-pin dock connector found on previous iPhone and iPad/iPod models. A new MDI cable (?MDI Adapter Cable ?
• 10239270Apr 1, 2014Equipment. Volkswagen Warranty Policies and Procedures ? April 2014
• 10239533Mar 27, 2014Visibility (wipers, defrost, mirrors). HVAC, Unpleasant Odor
• 10124289Mar 27, 2014Equipment. Technical Bulletin (HVAC, Unpleasant Odor): Unpleasant odor is coming from Heating and Ventilation system. Odor mainly occurs after vehicle has been sitting (unused) at least 5 hours and within 20 to 60 seconds after vehicle is first started. Condensation is a normal characteristic in all A/C systems. If odor is noticeable continue to follow this document. Contaminants are effectively neutralized using the…
• 10241311Mar 26, 2014Engine cooling. Gasoline Quality
• 10124302Mar 26, 2014Engine. Technical Bulletin The use of contaminated gasoline, seasonal fuel changes (summer/winter fuel) or gasoline with a low content of deposit control additives may result in one or more of the following conditions: -Excessive accumulation of deposits on intake valves, intake manifold, fuel injectors and combustion chambers. -Engine runs rough after cold start. -Excessive engine cranking time. -Stumbles while driving…
• 10241342Mar 25, 2014Electrical system, Engine cooling. Electric Coolant Fans Continue to Run after Ignition is OFF
• 10241329Mar 21, 2014Engine. Proper Removal of Engine Cover to Avoid Breakage
• 10124299Mar 21, 2014Engine. Technical Bulletin (Proper Removal of Engine Cover to Avoid Breakage): Pulling on the engine cover in some areas can cause damage. This document informs on the procedure to remove the engine cover.
• 10239818Mar 20, 2014Electrical system. MIL ON, No Start, or Rough Running with DTCs P0087, P0088 or P0191 Stored in ECM Fault Memory (TDI ONLY)
• 10241310Mar 18, 2014Electrical system, Other or unknown. Software Version Management
• 10124303Mar 18, 2014Electrical system. Technical Bulletin This Technical Bulletin details the general process for carrying out a Software Version Management (SVM) software update for any Technical Bulletin (TSB) / Required Vehicle Update (RVU).
• 10253214Mar 8, 2014Other or unknown, Exterior lighting. Exterior Lights, Moisture Accumulation
• 10239817Mar 7, 2014Electrical system. MIL ON, No Start, or Rough Running with DTCs P0087, P0088 or P0191 Stored in ECM Fault Memory (TDI ONLY)
• 10239591Mar 6, 2014Exterior lighting. Exterior Lights, Moisture Accumulation
• 10124287Mar 6, 2014Exterior lighting. Technical Bulletin (Exterior Lights, Moisture Accumulation): Exterior light assemblies (headlights, taillights, fog lights, turn signals) are vented and may collect moisture on their inner surfaces, depending on humidity and other climatic changes. This document discusses necessary to diagnosis, and potential remedy of the issue.
• 10243008Mar 3, 2014Engine cooling, Electrical system. VW Elsa Newsletter
• 10241264Feb 25, 2014Engine cooling, Fuel system. Fuel Additive to Help Prevent Sporadic Misfire Faults
• 10252937Feb 14, 2014Electrical system. Vehicles equipped with Immobilizer 4 (Download) ? Adapting Keys after Vehicle Lock Set Replacement
• 10237761Feb 14, 2014Electrical system, Equipment. When replacing the complete vehicle lock set (all vehicle keys and lock cylinders) for any reason, be aware that the ?Adapt keys? test plan will not allow the new keys to adapt to the vehicle. Instead, perform the test plan for ?New identity?. During this test plan, make the appropriate selection to indicate only the lock set has been replaced, as shown below in figures 1 and 2.

← All problems reported for the 2009 Volkswagen Passat