2009 Volkswagen Passat Technical Service Bulletins

753 technical service bulletins (TSBs) are on record for the 2009 Volkswagen Passat. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10241265Jan 27, 2014Engine cooling, Fuel system. Fuel Additive to Help Prevent Sporadic Misfire Faults
• 10239789Jan 24, 2014Electrical system, Visibility (wipers, defrost, mirrors), Other or unknown. To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. The check must be performed with the engine running and heated rear window switched on. Switch OFF the ignition and visually locate the damage. Proceed with checking any other lines as necessary. Once the damaged line is identified, repair utilizing the Repair kit by Permatex® ITEM…
• 10238937Jan 24, 2014Transmission and drivetrain, Engine cooling. Install a vacuum gauge on the dipstick tube and check crankcase vacuum at idle. Compare to a known good vehicle. If the vacuum reading is lower than the comparison vehicle, visually inspect for oil leaks between the engine and the transmission. Smoke test the crankcase by connecting the EVAP smoke machine to the dipstick tube and inspect for leaks at the rear main seal (this will limit pressure to 2 PSI). DO NOT…
• 10122240Jan 24, 2014Visibility (wipers, defrost, mirrors). Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. This document informs of how to diagnose the issue and tips on servicing the issue
• 10122237Jan 24, 2014Equipment, Fuel system. Tech Tips (Lean Fuel Trim Readings): This document informs on the procedure to diagnose for issues with excess fuel trim, and what needs to be serviced
• 10121563Jan 24, 2014Transmission and drivetrain. Tech Tips (Lean Fuel Trim Readings): This document informs to recheck the crankcase vacuum at idle. If low, check for additional oil leaks and verify crankcase breather operation (repairing as necessary). Erase the faults and road test 10 miles to recheck operation.
• 10243001Jan 20, 2014Steering, Engine cooling. VW Elsa Newsletter
• 10244073Dec 18, 2013Transmission and drivetrain. DTC P2711 Implausible Transmission Shift Sequence Stored in the Transmission Control Module
• 10239840Dec 18, 2013Transmission and drivetrain. DTC P2711 Implausible Transmission Shift Sequence Stored in the Transmission Control Module
• 10244045Dec 9, 2013Electrical system, Other or unknown. Volkswagen Elsa Newsletter
• 10242365Dec 9, 2013Equipment. VW Elsa Newsletter
• 10244072Dec 3, 2013Engine cooling. Rattling Noises from Engine Compartment Area or Exhaust System
• 10239808Dec 3, 2013Back-over prevention (rear camera). Customers may complain of a rattling noise from engine or exhaust area while accelerating from 1800-3000 RPM.
• 10209346Dec 3, 2013Engine. Rattling noises from engine compartmen area or exhaust system.
• 10157543Dec 3, 2013Engine cooling. Technical Bulletin (Rattling Noises from Engine Compartment Area or Exhaust System): Customers may complain of a rattling noise from engine or exhaust area while accelerating from 1800-3000 RPM. In order to complete proper diagnosis and ensure that the noise is coming from the turbocharger use the procedure in this document.
• 10155952Dec 3, 2013Engine cooling. Technical Bulletin (Rattling Noises from Engine Compartment Area or Exhaust System): Customers may complain of a rattling noise from engine or exhaust area while accelerating from 1800-3000 RPM. In order to complete proper diagnosis and ensure that the noise is coming from the turbocharger use the procedure in this document.
• 10242375Nov 25, 2013Equipment, Steering, Visibility (wipers, defrost, mirrors), Engine. VW Elsa Newsletter
• 10238932Nov 15, 2013Equipment. If a needed service part is on back order, upgrade the daily order to a red order and check the ?Car Down? box to escalate the order. If parts assistance is needed, please call 800-767-6552 to speak with a VWGoA Parts Specialist.
• 10238931Nov 15, 2013Equipment. If a needed service part is on back order, upgrade the daily order to a red order and check the ?Car Down? box to escalate the order. If parts assistance is needed, please call 800-767-6552 to speak with a VWGoA Parts Specialist.
• 10212722Nov 15, 2013Equipment. Part ordering
• 10157603Nov 15, 2013Equipment. Tech Tips (All Models 2000-2014 - Part ordering): If a needed service part is on back order, upgrade the daily order to a red order and check the ?Car Down? box to escalate the order. This document informs how to contact VWGoA Parts Specialist for help.
• 10156008Nov 15, 2013Equipment. Tech Tips (All Models 2000-2014 - Part ordering): If a needed service part is on back order, upgrade the daily order to a red order and check the ?Car Down? box to escalate the order. This document informs how to contact VWGoA Parts Specialist for help.
• 10243034Nov 4, 2013Equipment. VW Elsa Newsletter
• 10242372Nov 4, 2013Visibility (wipers, defrost, mirrors), Equipment. VW Elsa Newsletter
• 10239532Oct 29, 2013Visibility (wipers, defrost, mirrors). HVAC, Unpleasant Odor
• 10157506Oct 29, 2013Equipment. Technical Bulletin (HVAC, Unpleasant Odor): An unpleasant odor is coming from Heating and Ventilation system. Odor mainly occurs after vehicle has been sitting (unused) at least 5 hours and within 20 to 60 seconds after vehicle is first started. Contaminants are effectively neutralized using the AIRCOMATIC? II Ultrasonic Climate System Cleaner (VAS 6189A) or AIRCOMATIC III Ultrasonic Climate System Cleaner (VAS…
• 10155925Oct 29, 2013Equipment. Technical Bulletin (HVAC, Unpleasant Odor): An unpleasant odor is coming from Heating and Ventilation system. Odor mainly occurs after vehicle has been sitting (unused) at least 5 hours and within 20 to 60 seconds after vehicle is first started. Contaminants are effectively neutralized using the AIRCOMATIC? II Ultrasonic Climate System Cleaner (VAS 6189A) or AIRCOMATIC? III Ultrasonic Climate System Cleaner (VAS…
• 10238950Oct 25, 2013Engine cooling. Inspect the water pump for signs of contact with engine oil. Engine oil may cause the water pump gasket to swell, which may lead to a coolant leak. If water pump replacement is necessary, ensure that any engine oil is thoroughly cleaned off, prior to water pump installation. Please note that when replacing the water pump or opening the cooling system, there is a special bleed procedure that has to be performed…
• 10238588Oct 25, 2013Electrical system, Engine cooling. Use of aftermarket air filters such as cotton bed steel mesh or cone style, can cause the MAF sensor to not read accurately, affecting vehicle performance and critical monitoring functions for the diesel particulate filter. This can also result in premature DPF failure. Only use factory air filters. The use of aftermarket air filters is not supported as the system was designed and calibrated to work with factory…
• 10157508Oct 25, 2013Engine cooling. Tech Tips (2.0L CCTA/CBFA Coolant Leak or Repeat Coolant Leak from the Water Pump Area): This document informs of the observations that need to be taken to service a water pump replacement
• 10157497Oct 25, 2013Fuel system, Engine. Tech Tips (CBEA, CJAA, CKRA engine codes DPF replacement and/or DTCS P2413, P2463): This document informs of the use of aftermarket air filters such as cotton bed steel mesh or cone style, can cause the MAF sensor to not read accurately, affecting vehicle performance and critical monitoring functions for the diesel particulate filter. This can also result in premature DPF failure. Only use factory air filters.
• 10155915Oct 25, 2013Fuel system, Engine cooling. Tech Tips (CBEA, CJAA, CKRA engine codes DPF replacement and/or DTCS P2413, P2463): This document informs of the use of aftermarket air filters such as cotton bed steel mesh or cone style, can cause the MAF sensor to not read accurately, affecting vehicle performance and critical monitoring functions for the diesel particulate filter. This can also result in premature DPF failure. Only use factory air filters.
• 10155913Oct 25, 2013Engine cooling. Tech Tips (2.0L CCTA/CBFA Coolant Leak or Repeat Coolant Leak from the Water Pump Area): This document informs of the observations that need to be taken to service a water pump replacement
• 10240605Oct 15, 2013Other or unknown, Engine cooling, Electrical system, Transmission and drivetrain. P0102, P1128, P1296 - WA front oxygen sensor faults
• 10157460Oct 15, 2013Equipment, Electrical system. Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle
• 10155839Oct 15, 2013Electrical system. Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle
• 10241344Oct 10, 2013Electrical system, Engine cooling. Electric Coolant Fans Continue to Run after Ignition is OFF
• 10157516Oct 10, 2013Engine cooling. Technical Bulletin (Electric Coolant Fans Continue to Run after Ignition is Switched OFF): This document informs it is considered normal operation for the electric coolant fans to continue to run for up to 15 minutes after the ignition is switched off in gasoline engine applications, and up to 16 minutes in diesel engine applications.
• 10155930Oct 10, 2013Engine cooling. Technical Bulletin (Electric Coolant Fans Continue to Run after Ignition is Switched OFF): This document informs it is considered normal operation for the electric coolant fans to continue to run for up to 15 minutes after the ignition is switched off in gasoline engine applications, and up to 16 minutes in diesel engine applications.
• 10157538Oct 7, 2013Equipment. Warranty Information (Volkswagen DoubleCheck Labor Operations): Volkswagen DoubleCheck Labor Operations for All VW Models Except Routan ElsaWeb/Pro was updated on August 12, 2013 with the following Volkswagen DoubleCheck labor operations for all Volkswagen models except Routan. This document informs where in ElsaWeb/Pro this information can be located.
• 10155947Oct 7, 2013Equipment. Warranty Information (Volkswagen DoubleCheck Labor Operations): Volkswagen DoubleCheck Labor Operations for All VW Models Except Routan ElsaWeb/Pro was updated on August 12, 2013 with the following Volkswagen DoubleCheck labor operations for all Volkswagen models except Routan. This document informs where in ElsaWeb/Pro this information can be located.
• 10241335Oct 3, 2013Engine cooling. Oil Consumption Measurement
• 10157515Oct 3, 2013Engine cooling. Technical Bulletin (Oil Consumption Measurement): Customers have stated oil consumption is higher than the Volkswagen oil consumption standard of up to 0.5 quarts per 600 miles, or 0.5 liters per 1000 km. This document informs how to test the oil consumption rate
• 10155922Oct 3, 2013Engine. Technical Bulletin (Oil Consumption Measurement): Customers have stated oil consumption is higher than the Volkswagen oil consumption standard of up to 0.5 quarts per 600 miles, or 0.5 liters per 1000 km. This document informs how to test the oil consumption rate
• 10242381Sep 9, 2013Electrical system, Engine, Equipment. VW Elsa Newsletter
• 10238571Sep 9, 2013Engine cooling. When diagnosing fault code P2279-Leaking Air in Intake System, be sure to check the cam timing first.
• 10157406Aug 30, 2013Equipment, Engine. Volkswagen Note (Warranty Extension for Intake Manifold & Fuel Injectors Certain 2008-2011 Model Year Volkswagen Vehicles with 2.0 TFSI Engine): As part of Volkswagen?s ongoing commitment to our environment, and in cooperation with the United States Environmental Protection Agency and the California Air Resources Board, Volkswagen is informing customers of the decision to extend the customers Emissions Control…
• 10155878Aug 30, 2013Engine cooling. Volkswagen Note (Warranty Extension for Intake Manifold & Fuel Injectors Certain 2008-2011 Model Year Volkswagen Vehicles with 2.0 TFSI Engine): As part of Volkswagen?s ongoing commitment to our environment, and in cooperation with the United States Environmental Protection Agency and the California Air Resources Board, Volkswagen is informing customers of the decision to extend the customers Emissions Control…
• 10053891Aug 14, 2013Fuel system. Volkswagen: diagnosis for high pressure fuel pump where no start, engine crank, without driving, after long periods and may have rough running engine. Models 2008-2014 eos, gti, beetle convertible, jetta, cc, passat, tiguan, beetle.
• 10237995Jul 19, 2013Transmission and drivetrain. This bulletin provides a procedure to determine ?repair? versus ?replacement? of an automatic transmission. This procedure is to be used ?After? the transmission has been removed from the vehicle.

← All problems reported for the 2009 Volkswagen Passat