2024 Volvo S60 Technical Service Bulletins

264 technical service bulletins (TSBs) are on record for the 2024 Volvo S60. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 11020541May 28, 2025Engine. This is a Technical Journal: Coolant Pump Dry Coolant Mix Residue. If the coolant pump has an active leak, a photo must be taken prior to replacement (see example as in attached picture TJ_36923_3). The photo showing the active water pump leak on the vehicle must be saved for the TMA photo return process and provided when requested.
 Sealing improvements have been made to PNs 32382367, 32441161 and 32382368…
• 11020538May 20, 2025Transmission and drivetrain. This is a Technical Journal: Vehicle jerks in low speed when Start/Stop is active. Improved software is introduced from version 3.5.14.
• 11020536May 20, 2025Forward collision avoidance. this a Technical Journal: ASDM = Active Safety Domain Master
 To prevent unnecessary replacements of ASDM and as a troubleshooting aid for the Intellisafe system, please follow the advice in Technical Journal
• 11020534May 17, 2025Engine. This is a Technical Journal: CEL with DTC ECM P001100, P001200, P001400, P001500. For MY 23-26 vehicles with engine code L1, an improved software is released in version 3.5.14 (and newer). Perform a Total Upgrade according to TJ 31543 before performing additional VIDA symptom-based fault tracing.
 •Software for remaining models will be released later in calendar year 2025
• 11020533May 17, 2025Engine. This is a Technical Journal: Check engine light and DTC - ECM P013926. Do not replace any parts. The hardware is usually not at fault.
• 11020532May 17, 2025Other or unknown, Fuel system. This is a Technical Journal: CEL and DTC ECM P04F000. New ECM software has been released
• 11020530May 17, 2025Back-over prevention (rear camera). This is a Technical Journal: Park Assistance System enhanced troubleshooting. Clean the sensor. Damage is not a matter for warranty.
• 11020527May 16, 2025Electrical system. This is a Technical Journal: DIM Message and DTC BECM P0C7800.
 Structure Week 2023w47 and newer: New BECM software is released in version 3.6.4.
• 11020524May 2, 2025Transmission and drivetrain. This is a Technical Journal: Transmission Shifts From D or R to P Immediately After Starting. This symptom can occur if the driver changes the position of the gear shifter from P to D or R very quickly after starting the engine and the starting process is not completed. Inform the driver to pause briefly after starting the vehicle before shifting into D or R.
• 11020523May 1, 2025Engine. This is a Technical Journal: CEL with DTC ECM P001100, P001200, P001400, P001500. For MY 23-26 vehicles with engine code L1, an improved software is released in version 3.5.14 (and newer). Perform a Total Upgrade according to TJ 31543 before performing additional VIDA symptom-based fault tracing.
 •Software for remaining models will be released later in calendar year 2025
• 11020520May 1, 2025Electrical system. This is a Technical Journal: DIM Message and DTC ECM P0DF400. •Structure weeks 202147 - 202446: Improved ECM software has been released in version 3.4.4. Please perform a software upgrade according to TJ 31543.
 Structure Weeks 2024w47 - newer: A software release is planned for 2025 quarter 2, please follow the steps belowIf the vehicle is drivable and the turtle light is not on in the DIM, do not replace any…
• 11020455Apr 25, 2025Engine. This is a Technical Journal: Coolant Pump Dry Coolant Mix Residue. If the coolant pump has an active leak, a photo must be taken prior to replacement (see example as in attached picture TJ_36923_3). The photo showing the active water pump leak on the vehicle must be saved for the TMA photo return process and provided when requested.
 Sealing improvements have been made to PNs 32382367, 32441161 and 32382368…
• 11020454Apr 25, 2025Engine. This is a Technical Journal: Check engine light and DTC - ECM P061C48/P060C48. Change engine oil and filter.
• 11020446Apr 18, 2025Other or unknown. This is a Technical Journal: Door Lock Feature. Before replacing the lock, test it by pulling the outer handle in different speeds = slow / medium (normal) / fast (as shown in the attachment TJ_37168_1.MOV.)
 If the door don´t open when pulled in slow/medium speeds, follow Vida for replacement method.
• 11020443Apr 16, 2025Engine. This is a Technical Journal: Torque Rod, Right Upper Replacement. replacements of Torque rod, Right upper (P/N's 32298950 and 31682684
• 11020441Apr 16, 2025Engine. This is a Technical Journal: Coolant Pump Dry Coolant Mix Residue. If the coolant pump has an active leak, a photo must be taken prior to replacement (see example as in attached picture TJ_36923_3). The photo showing the active water pump leak on the vehicle must be saved for the TMA photo return process and provided when requested.
 Sealing improvements have been made to PNs 32382367, 32441161 and 32382368…
• 11020437Apr 10, 2025Exterior lighting. This is a Technical Journal: Remote connection, BOMGAR application. Before joining a remote session:
 •Connect a suitable battery maintainer/charger and verify that the battery voltage indicated in VIDA is between 12.5V and 14.9V.
 •Connect to the vehicle over a wired connection using a VOE (Volvo OBD to Ethernet) adapter and perform a NEW vehicle readout.
• 11020435Apr 8, 2025Engine. This is a Technical Journal: Chirping noise from engine during engine shutoff. Replace both front camshaft seals
• 11016907Mar 20, 2025Engine. This is a Technical Journal: DTC ECM-P06DE00 set, no symptoms. Do not replace any parts or perform additional fault tracing.
 This is a misdetection and a false positive (a.k.a. "ghost code"). The oil pump is actually working as intended
• 11016902Mar 18, 2025Electrical system. This is a Technical Journal: Improved 12V battery test in VIDA. Service:
 Don´t charge the battery before the test, jump start the vehicle if needed. Read out the vehicle with VIDA and start the test.
• 11016899Mar 14, 2025Transmission and drivetrain. This is a Technical Journal: Clicking sound from transmission area.
 This is considered a normal operating characteristic/function of the vehicle.
• 11016896Mar 11, 2025Other or unknown. This is a Technical Journal: DIM Message and DTC BECM P0C3200. perform a total upgrade of the software
• 11016894Mar 11, 2025Engine. This is a Technical Journal: MIL and DTCs ECM P012807/P01287A. A software solution was released in version 3.4.4
• 11016892Mar 11, 2025Other or unknown. This is a Technical Journal: ICUP - Service Reminder Indicator Not Possible to Reset. Work is ongoing to provide new DIM software which will be available in VIDA
• 11016891Mar 11, 2025Electrical system. This is a Technical Journal: MVBM Replacement - Prior Approval Needed
• 11016890Mar 11, 2025Transmission and drivetrain. This is a Technical Journal: Vehicle jerks and TCM DTC P071164 set. A software solution is introduced from version 3.4.4.
• 11016887Mar 11, 2025Electrical system. This is a Technical Journal: DIM Message and DTC ECM P0DF400. •Structure weeks 202147 - 202446: Improved ECM software has been released in version 3.4.4. Please perform a software upgrade according to TJ 31543.
 Structure Weeks 2024w47 - newer: A software release is planned for 2025 quarter 2, please follow the steps belowIf the vehicle is drivable and the turtle light is not on in the DIM, do not replace any…
• 11016886Mar 11, 2025Forward collision avoidance. This is a Technical Journal: Alleged issues with Intellisafe functionality. Please inform the car user of Intellisafe functionality and limitations in case of alleged issues with Intellisafe.
 The owner's manual is a good source of information together with films in the owner's manual in the car center screen about Intellisafe
• 11016016Feb 28, 2025Exterior lighting. This is a Technical Journal: Changed front fog/cornering lights behavior. This logic of the cornering lights is now changed in the cars with software version 3.3.16 or later
• 11016015Feb 28, 2025Engine. This is a Technical Journal: Check engine light and DTC - ECM P013926. Do not replace any parts. The hardware is usually not at fault.
• 11016009Feb 27, 2025Other or unknown, Fuel system. This is a Technical Journal: CEL and DTC ECM P04F000. New ECM software has been released
• 11016002Feb 21, 2025Other or unknown. Volvo Cars USA LLC and Volvo Car Canada LTD on behalf of the Volvo Car Corporation has decided to launch Service Action S10303 on certain model year 2025 EX90 vehicles.
 Volvo Car Investigations have identified that there is a pairing issue with the key fob.
 As a result, there is a possibility that the customer’s key fob is not paired to the vehicle.
 The corrective action is to download SP…
• 11015996Feb 19, 2025Engine. This is a Technical Journal: Check engine light and DTC - ECM P061C48/P060C48. Change engine oil and filter.
• 11015995Feb 19, 2025Engine. This is a Technical Journal: Chirping noise from engine during engine shutoff. Replace both front camshaft seals
• 11015994Feb 13, 2025Other or unknown. Volvo Cars USA LLC and Volvo Car Canada LTD on behalf of the Volvo Car Corporation has decided to launch Service Action S10303 on certain model year 2025 EX90 vehicles.
 Volvo Car Investigations have identified that there is a pairing issue with the key fob.
 As a result, there is a possibility that the customer’s key fob is not paired to the vehicle.
 The corrective action is to download SP…
• 11014131Jan 30, 2025Electrical system. This is a Technical Journal: ICUP - Volvo Cars app displays "Vehicle offline" message. fault trace the 12 V system according to VIDA
• 11014128Jan 30, 2025Transmission and drivetrain. This is a Technical Journal: DIM Message and DTC IEM P0A4000. A software solution is introduced with version 3.3.16. Perform a software upgrade
• 11014126Jan 30, 2025Other or unknown. This is a Technical Journal: Climate system heating performance (HVCH). Replace HVCH.
• 11014119Jan 27, 2025Electrical system. This is a Technical Journal: Intermittent DTC CEM B124713 and CEM B124813. Please start by following this journal prior to any replacements:
 - If the left rear turn indicator is not working, continue the fault tracing and repair according to our VIDA instructions.
 - If the left rear turn indicator is working, through visual inspection and DTC stated above is set, do not replace any parts.
 A software…
• 11014118Jan 27, 2025Transmission and drivetrain. This is a Technical Journal: Transmission Shifts From D or R to P Immediately After Starting. This symptom can occur if the driver changes the position of the gear shifter from P to D or R very quickly after starting the engine and the starting process is not completed. Inform the driver to pause briefly after starting the vehicle before shifting into D or R.
• 11014116Jan 23, 2025Other or unknown. Volvo Car USA LLC and Volvo Car Canada LTD, on behalf of Volvo Car Corporation, has decided to launch Complimentary Upgrade – C000017 on certain Android-based Infotainment system (iCup) vehicles that have missed three (3) or more consecutive Over-The-Air (OTA) downloads.
 C000017 also addresses certain EX90’s that have missed one (1) or more OTA downloads.
 Complimentary Upgrade C000017 addresses vehicles…
• 11014113Jan 16, 2025Other or unknown. This is a Technical Journal: Vehicle/Connectivity report checklist. To provide timely and high-quality feedback to the appropriate department or factory
• 11014112Jan 16, 2025Exterior lighting. This is a Technical Journal: Remote connection, BOMGAR application. Before joining a remote session:
 •Connect a suitable battery maintainer/charger and verify that the battery voltage indicated in VIDA is between 12.5V and 14.9V.
 •Connect to the vehicle over a wired connection using a VOE (Volvo OBD to Ethernet) adapter and perform a NEW vehicle readout.
• 11014105Jan 9, 2025Body and structure. This is a Technical Journal: Fuel Door Won't Open. Using the key fob buttons:
 •Press the lock button
 •Wait approximately 10 seconds
 •Press the unlock button
• 11014102Jan 4, 2025Engine. This is a Technical Journal: Check engine light and DTC - ECM P013926. perform an adapatation test drive
• 11014101Jan 4, 2025Other or unknown. This is a Technical Journal: ICUP - Estimated Time of Arrival in DIM missing. The plan is to reintroduce this function in the next software release that is expected in year 2025 quarter 1 in VIDA
• 11014100Jan 4, 2025Other or unknown. This is a Technical Journal: Volvo Cars app, unpaired vehicle - Profile tab. Create a TIE report.
• 11012561Dec 3, 2024Other or unknown. This is a Technical Journal: Slow Response from iCUP Infotainment System after v3.3.16 SW. The issue is expected to be resolved within approximately 5 driving cycles
• 11011738Nov 1, 2024Other or unknown. This is a Technical Journal: ICUP - Steering wheel buttons won't tune/seek media. perform an IHU reload in VIDA.
• 11011735Nov 1, 2024Exterior lighting. This is a Technical Journal: Headlamp condensation inside lens - information/leak test. If the result is not ok (air leak), it is ok to replace the headlamp

← All problems reported for the 2024 Volvo S60