2024 Volvo V60 Technical Service Bulletins

221 technical service bulletins (TSBs) are on record for the 2024 Volvo V60. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 11026739Nov 14, 2025Other or unknown. This is a TJ - 1 document plus one attachment of detailed repair instructions - If the Check Engine Light is illuminated in the DIM and DTC ECM P244A00 is set, please follow the advice under "Service". This TJ is a complement to the fault tracing in VIDA. Please follow the steps below.
• 11026736Nov 7, 2025Body and structure. This is a TJ - Text plus 2 jpeg files and 1 mp4 file - If customer complains of the hood being hard to close or "Open Hood" DIM message, please follow advice under "service". And before replacing any parts, follow the 3 steps in the instructions.
• 11026735Nov 7, 2025Electrical system. This is a Technical Journal: DIM Message and DTC BECM P0C7800. Structure Week 2023w47 and newer: New BECM software is released in version 3.6.4. Perform a Total Upgrade according to TJ 31543. • If the DTC sets after SW version 3.6.4 or newer has been installed, please follow VIDA fault tracing and then create a TIE Support Needed Vehicle Report. *Structure Week 2023w46 and older: New BECM software is planned for…
• 11025563Oct 10, 2025Engine. This is a Technical Journal: CEL with DTC ECM P001100, P001200, P001400, P001500. For MY 23-26 vehicles with engine code L1, an improved software is released in version 3.5.14 (and newer). Perform a Total Upgrade according to TJ 31543 before performing additional VIDA symptom-based fault tracing.
 •Software for remaining models will be released later in calendar year 2025
• 11025561Oct 10, 2025Engine. This is a Technical Journal: If the sound can be located towards camshaft sealing area according to attached files:
 Loosen the oil filling cap a little bit and turn engine off again to see if affects the noise.
 If sound is gone with cap loosened, replace the camshaft seals according to instructions in VIDA.
• 11023544Sep 25, 2025Other or unknown. This is a Technical Journal: iCUP IHU - Software Download failure. Follow the recommended procedure depending on the MY (Model Year) of the vehicle
• 11023538Sep 2, 2025Other or unknown. This is a Technical Journal IHU 4.2 - Spare part replacement and Volvo Car UX - If the replaced IHU includes the new upgraded Volvo Car UX (one HMI) software for the Center Display, please inform the customer about the change prior to the vehicle leaving the workshop.
 Note: The Driver Display (DIM) UX will remain unchanged until a future software update.
• 11022808Aug 25, 2025Other or unknown. This is a technical Journal - iCUP - Estimated Time of Arrival in DIM missing Issue is now resolved with latest SW in VIDA 3.4.4.
• 11021940Jul 31, 2025Other or unknown. This is a Technical Journal: ICUP Critical Guidelines for Replacing IHU.After replacing the IHU with one of the part numbers listed above, follow the steps below:
 1. Download IHU reload (select Yes for replaced HW).
 2. Perform a Total Upgrade.
 3. Manually order and download SP according to the list below
• 11021937Jul 31, 2025Forward collision avoidance. This is a Technical Journal: Alleged issues with Intellisafe functionality. Please inform the car user of Intellisafe functionality and limitations in case of alleged issues with Intellisafe.
 The owner's manual is a good source of information together with films in the owner's manual in the car center screen about Intellisafe
• 11021935Jul 24, 2025Engine. This is a Technical Journal: CEL with DTC ECM P001100, P001200, P001400, P001500. For MY 23-26 vehicles with engine code L1, an improved software is released in version 3.5.14 (and newer). Perform a Total Upgrade according to TJ 31543 before performing additional VIDA symptom-based fault tracing.
 •Software for remaining models will be released later in calendar year 2025
• 11021933Jul 23, 2025Electrical system. This is a Technical Journal: Check Engine Light/DIM message and ISGM DTC P056200.
• 11021932Jul 23, 2025Other or unknown. This is a Technical Journal: iCUP IHU - Software Download failure. Follow the recommended procedure depending on the MY (Model Year) of the vehicle
• 11021931Jul 23, 2025Fuel system, Other or unknown. This is a Technical Journal: CEL and DTC ECM P04F000. New ECM software has been released
• 11021929Jul 23, 2025Other or unknown. This is a Technical Journal: AC evaporator repair, additional parts needed. Add resister in line jumper cable.
• 11021925Jul 18, 2025Other or unknown. This is a Technical Journal: iCUP IHU - Prior Approval. In most cases, the IHU does not need to be replaced
• 11021923Jul 16, 2025Other or unknown. This is a Technical Journal: Sunroof Sun Protection. During periods of intense sunlight, it is recommended to keep the sunroof closed when parked to minimize direct sunlight entering the vehicle, as prolonged exposure may cause deterioration or quality issues in the interior materials.
• 11021918Jul 3, 2025Electrical system. This is a Technical Journal: DIM Message and DTC BECM P0C7800.
 Structure Week 2023w47 and newer: New BECM software is released in version 3.6.4.
• 11021916Jul 2, 2025Other or unknown. This is a Technical Journal: iCUP IHU - Prior Approval. In most cases, the IHU does not need to be replaced
• 11021915Jul 2, 2025Other or unknown. This is a Technical Journal: DIM Message and DTC BECM P0C3200. perform a total upgrade of the software
• 11020559Jun 27, 2025Electrical system. This is a Technical Journal: DIM Message and DTC BECM P0C7800.
 Structure Week 2023w47 and newer: New BECM software is released in version 3.6.4.
• 11020558Jun 19, 2025Engine. This is a Technical Journal: CEL with DTC ECM P001100, P001200, P001400, P001500. For MY 23-26 vehicles with engine code L1, an improved software is released in version 3.5.14 (and newer). Perform a Total Upgrade according to TJ 31543 before performing additional VIDA symptom-based fault tracing.
 •Software for remaining models will be released later in calendar year 2025
• 11020552Jun 13, 2025Other or unknown. This is a Technical Journal: Privately Imported Vehicles - Connectivity Setup. Make sure QW90 has been updated prior to performing below steps:
 If vehicle software is not up to date, please perform a Total Upgrade according to TJ 31543
• 11020551Jun 13, 2025Electrical system. This is a Technical Journal: Ghost DTC CEM-B18711B.
 The DTC is set due to wrong resistance calculation with a low 12V battery SOC.
• 11020546Jun 13, 2025Electrical system. This is a Technical Journal: DIM Message and DTC BECM P0C7800.
 Structure Week 2023w47 and newer: New BECM software is released in version 3.6.4.
• 11020543Jun 13, 2025Transmission and drivetrain. This is a Technical Journal: Transmission Shifts From D or R to P Immediately After Starting. This symptom can occur if the driver changes the position of the gear shifter from P to D or R very quickly after starting the engine and the starting process is not completed. Inform the driver to pause briefly after starting the vehicle before shifting into D or R.
• 11020542Jun 13, 2025Electrical system. This is a Technical Journal: BEV and LR-PHEV SW Update for High Voltage Battery Balancer. The Balancer software must be upgraded to version OTG_192-411899-H00-029 or higher
• 11020536May 20, 2025Forward collision avoidance. this a Technical Journal: ASDM = Active Safety Domain Master
 To prevent unnecessary replacements of ASDM and as a troubleshooting aid for the Intellisafe system, please follow the advice in Technical Journal
• 11020534May 17, 2025Engine. This is a Technical Journal: CEL with DTC ECM P001100, P001200, P001400, P001500. For MY 23-26 vehicles with engine code L1, an improved software is released in version 3.5.14 (and newer). Perform a Total Upgrade according to TJ 31543 before performing additional VIDA symptom-based fault tracing.
 •Software for remaining models will be released later in calendar year 2025
• 11020532May 17, 2025Fuel system, Other or unknown. This is a Technical Journal: CEL and DTC ECM P04F000. New ECM software has been released
• 11020530May 17, 2025Back-over prevention (rear camera). This is a Technical Journal: Park Assistance System enhanced troubleshooting. Clean the sensor. Damage is not a matter for warranty.
• 11020527May 16, 2025Electrical system. This is a Technical Journal: DIM Message and DTC BECM P0C7800.
 Structure Week 2023w47 and newer: New BECM software is released in version 3.6.4.
• 11020526May 16, 2025Electrical system. This is a Technical Journal: BEV and LR-PHEV SW Update for High Voltage Battery Balancer. The Balancer software must be upgraded to version OTG_192-411899-H00-029 or higher
• 11020524May 2, 2025Transmission and drivetrain. This is a Technical Journal: Transmission Shifts From D or R to P Immediately After Starting. This symptom can occur if the driver changes the position of the gear shifter from P to D or R very quickly after starting the engine and the starting process is not completed. Inform the driver to pause briefly after starting the vehicle before shifting into D or R.
• 11020523May 1, 2025Engine. This is a Technical Journal: CEL with DTC ECM P001100, P001200, P001400, P001500. For MY 23-26 vehicles with engine code L1, an improved software is released in version 3.5.14 (and newer). Perform a Total Upgrade according to TJ 31543 before performing additional VIDA symptom-based fault tracing.
 •Software for remaining models will be released later in calendar year 2025
• 11020520May 1, 2025Electrical system. This is a Technical Journal: DIM Message and DTC ECM P0DF400. •Structure weeks 202147 - 202446: Improved ECM software has been released in version 3.4.4. Please perform a software upgrade according to TJ 31543.
 Structure Weeks 2024w47 - newer: A software release is planned for 2025 quarter 2, please follow the steps belowIf the vehicle is drivable and the turtle light is not on in the DIM, do not replace any…
• 11020453Apr 24, 2025Engine. This is a Technical Journal: Check engine light and DTC - ECM P014526. perform an adapatation test drive
• 11020443Apr 16, 2025Engine. This is a Technical Journal: Torque Rod, Right Upper Replacement. replacements of Torque rod, Right upper (P/N's 32298950 and 31682684
• 11020437Apr 10, 2025Exterior lighting. This is a Technical Journal: Remote connection, BOMGAR application. Before joining a remote session:
 •Connect a suitable battery maintainer/charger and verify that the battery voltage indicated in VIDA is between 12.5V and 14.9V.
 •Connect to the vehicle over a wired connection using a VOE (Volvo OBD to Ethernet) adapter and perform a NEW vehicle readout.
• 11020435Apr 8, 2025Engine. This is a Technical Journal: Chirping noise from engine during engine shutoff. Replace both front camshaft seals
• 11016907Mar 20, 2025Engine. This is a Technical Journal: DTC ECM-P06DE00 set, no symptoms. Do not replace any parts or perform additional fault tracing.
 This is a misdetection and a false positive (a.k.a. "ghost code"). The oil pump is actually working as intended
• 11016902Mar 18, 2025Electrical system. This is a Technical Journal: Improved 12V battery test in VIDA. Service:
 Don´t charge the battery before the test, jump start the vehicle if needed. Read out the vehicle with VIDA and start the test.
• 11016899Mar 14, 2025Transmission and drivetrain. This is a Technical Journal: Clicking sound from transmission area.
 This is considered a normal operating characteristic/function of the vehicle.
• 11016896Mar 11, 2025Other or unknown. This is a Technical Journal: DIM Message and DTC BECM P0C3200. perform a total upgrade of the software
• 11016894Mar 11, 2025Engine. This is a Technical Journal: MIL and DTCs ECM P012807/P01287A. A software solution was released in version 3.4.4
• 11016892Mar 11, 2025Other or unknown. This is a Technical Journal: ICUP - Service Reminder Indicator Not Possible to Reset. Work is ongoing to provide new DIM software which will be available in VIDA
• 11016891Mar 11, 2025Electrical system. This is a Technical Journal: MVBM Replacement - Prior Approval Needed
• 11016890Mar 11, 2025Transmission and drivetrain. This is a Technical Journal: Vehicle jerks and TCM DTC P071164 set. A software solution is introduced from version 3.4.4.
• 11016887Mar 11, 2025Electrical system. This is a Technical Journal: DIM Message and DTC ECM P0DF400. •Structure weeks 202147 - 202446: Improved ECM software has been released in version 3.4.4. Please perform a software upgrade according to TJ 31543.
 Structure Weeks 2024w47 - newer: A software release is planned for 2025 quarter 2, please follow the steps belowIf the vehicle is drivable and the turtle light is not on in the DIM, do not replace any…
• 11016886Mar 11, 2025Forward collision avoidance. This is a Technical Journal: Alleged issues with Intellisafe functionality. Please inform the car user of Intellisafe functionality and limitations in case of alleged issues with Intellisafe.
 The owner's manual is a good source of information together with films in the owner's manual in the car center screen about Intellisafe

← All problems reported for the 2024 Volvo V60