2016 Audi A7 Technical Service Bulletins

966 technical service bulletins (TSBs) are on record for the 2016 Audi A7. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10123604Nov 6, 2015Electrical system. Supersedes Technical Service Bulletin Group 20 number 15-50 dated October 19, 2015. The MIL is on. DTC P046100 (Fuel level sensor, circuit range/performance) is stored in the engine control module (ECM).
• 10123613Nov 5, 2015Electrical system. Customer may report that the instrument cluster center display and/or the MIB system briefly perform a reset or cut out. DTC U10CC00 (Optical data bus for digital sound system sporadic disruption) is stored in the information electronics control module. On A6 and A7 vehicles with PR code 9Q8 (Top instrument cluster), a software condition can cause the instrument cluster to cause disturbances on the MOST bus…
• 10123612Nov 3, 2015Electrical system. Supersedes Technical Service Bulletin Group 70 number 15-45 dated April 15, 2015. The customer may report hearing noises from the upper dashboard area when driving on poor roads, making phone calls, or playing music. The noise can be caused by unfavorable tolerances between the instrument panel speaker and the center speaker trim. A speaker that has been incorrectly installed can make the condition worse.
• 10123710Oct 29, 2015Electrical system. Supersedes Technical Service Bulletin Group 20 number 15-52 dated October 28, 2015. The MIL is on. DTC P045600 (EVAP System Leak Detected NVLD (very small leak)) is stored in the engine control module (ECM), J623 (address word 01). Drivability is not affected. The NVLD pressure switch may erroneously detect a very small leak.
• 10123709Oct 29, 2015Electrical system. Supersedes Technical Service Bulletin Group 20 number 15-51 dated October 28, 2015. The MIL is on. DTC P045600 (EVAP System Leak Detected NVLD (very small leak)) is stored in the engine control module (ECM), J623 (address word 01). Drivability is not affected. Various parts have been replaced under warranty for the condition noted above, but no issues were identified with these parts.
• 10123708Oct 28, 2015Electrical system. Supersedes Technical Service Bulletin Group 20 number 15-48 dated October 15, 2015. The MIL is on. DTC P045600 (EVAP System Leak Detected NVLD (very small leak)) is stored in the engine control module (ECM), J623 (address word 01). Drivability is not affected. The NVLD pressure switch may erroneously detect a very small leak.
• 10123707Oct 28, 2015Electrical system. Supersedes Technical Service Bulletin Group 20 number 15-49 dated October 15, 2015. The MIL is on. DTC P045600 (EVAP System Leak Detected NVLD (very small leak)) is stored in the engine control module (ECM), J623 (address word 01). Drivability is not affected. Various parts have been replaced under warranty for the condition noted above, but no issues were identified with these parts.
• 10123756Oct 27, 2015Equipment. This document contains the Audi maintenance schedule. First standard maintenance service at 5,000 miles or 1 year after delivery, whichever occurs first. Standard maintenance services thereafter occur at intervals of 10,000 miles or 1 year after the last standard maintenance service, whichever occurs first. First major maintenance service at 15,000 miles or 2 years after delivery, whichever occurs first.
• 10123718Oct 27, 2015Equipment. Supersedes Technical Service Bulletin Group 51 number 15-09 dated October 2, 2015. Instructions for vehicle inspection, protection removal, and detailing.
• 10123716Oct 20, 2015Steering, Brakes. Supersedes Technical Service Bulletin Group 46 number 14-86 dated July 14, 2014. DO NOT use this TSB if there is another TSB for same concern applicable to the VIN. This TSB is only intended for diagnostic purposes and does not serve as a guideline for determining warrantable conditions. Customer may report that the steering wheel vibrates or pulsates when the brakes are applied. driving style, environmental…
• 10123706Oct 19, 2015Electrical system. Supersedes Technical Service Bulletin Group 20 number 15-47 dated August 5, 2015. The MIL is on. DTC P046100 (Fuel level sensor, circuit range/performance) is stored in the engine control module (ECM), J623 (address word 01).
• 10123705Oct 15, 2015Electrical system. The MIL is on. DTC P045600 (EVAP System Leak Detected NVLD (very small leak)) is stored in the engine control module (ECM), J623 (address word 01). Drivability is not affected. Various parts have been replaced under warranty for the condition noted above, but no issues were identified with these parts. In an effort to gain information, we are asking that you contact the Audi Technical Assistance Center (TAC) before…
• 10123704Oct 15, 2015Electrical system. Supersedes Technical Service Bulletin Group 20 number 15-46 dated May 15, 2015. The MIL is on. DTC P045600 (EVAP System Leak Detected NVLD (very small leak)) is stored in the engine control module (ECM), J623 (address word 01). Drivability is not affected. The NVLD pressure switch may erroneously detect a very small leak.
• 10123714Oct 13, 2015Brakes. Supersedes Technical Service Bulletin Group 46 number 15-02 dated February 9, 2015. The customer may report hearing brake noise from front or rear brakes. The customer may describe these noises as a squeal, squeak, grinding, groaning, thumping, or creaking. DO NOT use this TSB if there is another brake noise TSB applicable to the VIN. For additional information, refer to the Audi Brake systems brochure. Brake noise…
• 10123755Oct 8, 2015Equipment. This document contains the Audi maintenance schedule. First standard maintenance service at 5,000 miles or 1 year after delivery, whichever occurs first. Standard maintenance services thereafter occur at intervals of 10,000 miles or 1 year after the last standard maintenance service, whichever occurs first. First major maintenance service at 15,000 miles or 2 years after delivery, whichever occurs first.
• 10123724Oct 8, 2015Electrical system. The head-up display will not power on or does not work. After the next bus silence (for example, waiting five minutes after the driver side door is locked), the head-up display works correctly. There is a software deviation that affects software versions 0304 (on A6 and A7 vehicles) and 0021 (on A8 vehicles).
• 10123712Oct 5, 2015Suspension. Supersedes Technical Service Bulletin Group 44 number 14-56 dated December 8, 2014. Customer feels vibration in the seat, vehicle floor, footwell, pedals, or steering wheel. This condition does not lead to any handling concerns or loss of vehicle control. Customer feels the vibration while driving at highway speeds from 55 ? 80 mph (88 ? 128 km/h). This bulletin is not applicable if this vehicle has a Repair…
• 10123717Oct 2, 2015Equipment. Supersedes Technical Service Bulletin Group 51 number 13-07 dated September 30, 2013. Instructions for vehicle inspection, protection removal, and detailing.
• 10123774Sep 29, 2015Electrical system. While using Audi connect, the customer cannot access the online destination search and/or the Google Earth navigation view. ?This service is currently unavailable. Please try again later" message appears in the MMI. The customer may also see an error message in the myAudi portal indicating that one or multiple licenses are expired and must be renewed. Replacing the SIM card or MMI hardware or performing the SVM…
• 10123771Sep 24, 2015Equipment. Supersedes Technical Service Bulletin Group 87 number 15-67 dated August 19, 2015. This bulletin applies to any repair that requires replacement of the air conditioning compressor. Any replacement of A/C compressors?regardless of the reason for failure?must include an ODIS GFF cooling performance test plan of the A/C system with documentation of the recovered refrigerant volume. This GFF test plan requirement is…
• 10130230Sep 23, 2015Electrical system. upersedes Technical Service Bulletin Group 91 number 15-14 dated September 23, 2015. On Bluetooth hands-free calls (from Android or Windows phones), the person on the other end of the line has trouble hearing the driver. The driver?s voice skips or sounds distorted. The driver?s voice cannot be heard at all. The person on the other end of the line only hears an echo of his or her own voice. This is condition is…
• 10123775Sep 21, 2015Electrical system. Supersedes Technical Service Bulletin Group 96 number 13-67 dated July 10, 2013. The customer may report that the handheld transmitter cannot be programmed to the garage door opener control module, J530. The customer?s door opener system may not be compatible with J530. The battery in the handheld transmitter may be too weak for a good signal. The battery charge may be sufficient to operate the garage door opener…
• 10123763Sep 9, 2015Engine. Supersedes Technical Service Bulletin Group 17 number 15-63 dated June 2, 2015. A check with the engine oil service dipstick T40178 is necessary, but the adjustment values for the dipstick are not available in the Elsa repair manual. Because of a system change, the adjustment values for the service dipstick T40178 were removed from the repair manual.
• 10123764Sep 8, 2015Engine cooling. Supersedes Technical Service Bulletin Group 19 number 15-61 dated July 7, 2015. Discontinuation and mixing of Audi-approved engine coolants. G11, G12, and G12+ coolants have been replaced by an improved version. G12++ coolant (for service available) has been introduced in MY 2005 for all engines. G13 has been introduced in MY 2008 as factory filling and service.
• 10123800Sep 2, 2015Equipment. This document contains the Audi pre-delivery inspection checklist. All items must be completed prior to customer delivery by an Audi technician. Audi recommends using an Audi approved battery charger to prevent excessive battery discharge during inspection. ALL PDI function tests must be run in Guided Fault Finding (GFF) only. Do NOT use Guided Functions for any PDI related test as these will not be uploaded to the…
• 10128419Aug 28, 2015Equipment. Supersedes Technical Service Bulletin Group 96 number 14-85 dated July 24, 2014. The sunglass holder in the dome light assembly will not latch closed or is stuck closed. The condition may be intermittent. The sunglass holder spring latch mechanism may have been damaged during the assembly procedure.
• 10128415Aug 27, 2015Equipment. Supersedes Technical Service Bulletin Group 91 number 15-80 dated March 20, 2015. The addresses and contacts stored in the Navigation >> Favorites, Navigation >> Directory, and Navigation >> Last destinations submenus disappear intermittently. Intermittently, the MMI system does not appear to remember that the user?s myAudi PIN has already been entered, and it requires the user to enter the PIN again. The voice…
• 10128408Aug 19, 2015Equipment. Customer may report poor performance of A/C system or that the A/C system is inoperative. Any replacement of A/C compressors must include an ODIS GFF test plan confirming a malfunction of the A/C system with documentation of the recovered refrigerant volume.
• 10128412Aug 17, 2015Electrical system. Supersedes Technical Service Bulletin Group 91 number 15-99 dated June 30, 2015. The tutorial videos in the MMI do not play or stop playing after some time. The condition may only occur with certain videos. Turning the ignition off and back on may correct the condition. Two of the tutorial videos for the 2016 A6 and A7 are not correct. When the user attempts to play these videos a cascading effect can occur…
• 10128361Aug 17, 2015Equipment. Supersedes Technical Service Bulletin Group 57 number 11-54 dated August 18, 2011. Audi advanced key (keyless entry) is inoperative on all doors, but the engine can be started with the keyless starting system (keyless go). The keyless starting system (keyless go) is a standard feature; Audi advanced key is an optional feature.
• 10128406Aug 13, 2015Latches, locks and linkages. Supersedes Technical Service Bulletin Group 57 number 12-62 dated January 9, 2012. The trunk cannot be unlocked with the button on the remote, with the button in the driver?s door panel, or with the handle on the lid of the trunk. Vehicles have a ?VALET? button in the glove box that activates the valet parking feature, which prevents unauthorized access to the trunk. When the valet parking feature is activated, the…
• 10128410Aug 6, 2015Visibility (wipers, defrost, mirrors). The picture from one or both of the cameras in the exterior mirrors is distorted in the rear area. There are deviating calibration values in the camera.
• 10128404Aug 5, 2015Electrical system. The MIL is on. DTC P046100 (Fuel level sensor, circuit range/performance) is stored in the engine control module (ECM), J623 (address word 01).
• 10074501Aug 5, 2015Electrical system, Engine. Summary to be provided on a future date.
• 10124694Aug 1, 2015Equipment, Tires. This document contains the Audi tire chain information by vehicle.
• 10128488Jul 30, 2015Visibility (wipers, defrost, mirrors), Equipment, Engine, Transmission and…. This document contains the fluid capacity chart.
• 10124693Jul 30, 2015Equipment, Tires. This document contains the Audi normal load condition tire pressure table.
• 10124692Jul 30, 2015Equipment, Tires. This document contains the tire pressure table for Audi vehicles. This document is in Spanish.
• 10128461Jul 28, 2015Equipment. This document contains the Audi maintenance schedule. The intervals shown in this table are based on vehicles operating under normal conditions. In case of severe conditions, such as extremely low temperatures, excessive dust, etc., it is necessary for certain operations to be carried out in between the given intervals. This applies particularly to engine oil changes and the cleaning or replacing of the air cleaner…
• 10128508Jul 22, 2015Equipment. This document contains the pre-delivery inspection technician reference document. The Pre-Delivery Inspection Technician Reference Document is designed to be a resource used in hand with the Pre-Delivery Inspection Checklist (PDI). The PDI Checklist has been simplified to make the process more efficient, and in doing so, this document has been created to be used as a reference for checklist items that may have…
• 10124703Jul 22, 2015Equipment. This document contains the pre-delivery inspection technician reference document. The Pre-Delivery Inspection Technician Reference Document is designed to be a resource used in hand with the Pre-Delivery Inspection Checklist (PDI). The PDI Checklist has been simplified to make the process more efficient, and in doing so, this document has been created to be used as a reference for checklist items that may have…
• 10128478Jul 21, 2015Equipment. The customer is unable to play music when using the USB AMI cable connection (in A3 vehicles) or the USB media port (in A6, A7, or TT vehicles). Android phones connect to the MMI using the Media Transport Protocol (MTP). If the phone is not correctly configured to use MTP, it is possible that the MMI does not see the phone. When correctly set up, the MMI sees the phone as a media storage device (similar to a USB…
• 10128503Jul 20, 2015Equipment. This document contains the Audi delivery guidelines checklist.
• 10128359Jul 10, 2015Engine, Electrical system. Supersedes Technical Service Bulletin Group 01 number 15-27 dated June 30, 2015. DTC P164D00 is stored in the engine control module. The red oil pressure warning light may be on. Rubber oil drain plug within the oil filter housing is out of position.
• 10128399Jul 7, 2015Engine cooling. Supersedes Technical Service Bulletin Group 19 number 14-50 dated June 20, 2014. Discontinuation and mixing of Audi-approved engine coolants. G11, G12, and G12+ coolants have been replaced by an improved version. G12++ coolant (for service available) has been introduced in MY 2005 for all engines. G13 has been introduced in MY 2008 as factory filling and service.
• 10128471Jul 1, 2015Transmission and drivetrain, Equipment. Supersedes Technical Service Bulletin Group 30 number 11-10 dated December 2, 2011. Clutch is not operating properly. Clutch has a burnt smell. Clutch pedal does not fully return to starting position. Incorrect shifting, the revolutions of clutch plate and engine input shaft differ too much, excessive slipping of the clutch, and when the clutch is pressed and an incorrect lower gear is selected, can result in…
• 10120833Jun 30, 2015Electrical system. Supersedes Technical Service Bulletin Group 96 number 15-95 dated April 14, 2015. MMI tutorial videos cannot be played or stop playing Turning the ignition off and back on may correct the condition. Two of the tutorial videos for the 2016 A6 and A7 are not correct. When the user attempts to play these videos a cascading effect can occur, causing all other videos to cease playing after some time. The incorrect video…
• 10120747Jun 30, 2015Engine cooling, Transmission and drivetrain. DTC P164D00 is stored in the engine control module. The red oil pressure warning light may be on. Rubber oil drain plug within the oil filter housing is out of position.
• 10120832Jun 29, 2015Electrical system. Supersedes Technical Service Bulletin Group 91 number 14-50 dated July 10, 2014. Customer may report that cracking, grinding, rattling, humming, whining, or similar interference is coming from one or more speakers. Parts of the speakers (such as the brackets, cables, or covers) or parts of the interior fittings (such as door covers, rear shelf, facings, or covers) can vibrate at certain frequencies, causing noises.
• 10120821Jun 24, 2015Equipment. Supersedes Technical Service Bulletin Group 87 number 15-63 dated May 18, 2015. There is an unpleasant, musty odor coming from the heating and ventilation system. The odor usually occurs when the vehicle has been sitting unused for five hours or more. The odor usually occurs within 20 to 60 seconds after the vehicle is started. Condensation, which is a normal condition in all A/C systems, can cause a musty odor.

← All problems reported for the 2016 Audi A7