2012 Audi Q5 Technical Service Bulletins

1,285 technical service bulletins (TSBs) are on record for the 2012 Audi Q5. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10204513Nov 1, 2013Equipment. Upcoming Update 28G6.
• 10121521Nov 1, 2013Engine, Electrical system. This communication is to inform you of upcoming Update 28G6. There are 79,232 Audi vehicles affected in the U.S. by this Update. Rough idle or reduced driving power and, in turn, an illuminated Malfunction Indicator Lamp (MIL) on the instrument cluster due to the presence of specific fault codes caused by this component. Inspect and replace ignition coils as required.
• 10121479Nov 1, 2013Equipment. Rough idle or reduced driving power and, in turn, an illuminated Malfunction Indicator Lamp (MIL) on the instrument cluster due to the presence of specific fault codes caused by this component. This Update is in effect until removed. Procedure is valid only for vehicles that show the 28G6 code in the ElsaWeb Campaign/Action Information screen on the day of repair. Vehicle must be within the New Vehicle Limited…
• 10121311Oct 29, 2013Electrical system. Supersedes Technical Service Bulletin Group 57 number 13-92 dated August 1, 2013. The customer inquires about the operation of the vehicle locking, and may suggest that the vehicle ?locked itself?. The lock command history is stored in the convenience system control module (J393).
• 10121987Oct 23, 2013Engine, Equipment. This document contains the Audi oil capacity chart.
• 10122046Oct 22, 2013Electrical system. Under certain conditions, permanent mode $0A DTC codes concerning the fuel pump power stage module may remain visible after the vehicle?s OBD system has run the proper monitors successfully to allow the DTC to be erased by the system, after a proper repair. This software malfunction may cause vehicle to not pass IM inspection programs. This software update eliminates specific permanent DTC codes stored in mode $0A…
• 10243775Oct 21, 2013Equipment. Audi Elsa Newsletter
• 10121948Oct 21, 2013Seats. Supersedes Technical Service Bulletin Group 74 number 13-11 dated September 13, 2013. The customer may complain that the seat heating temperature is too low or that it takes too long to heat up. From model year 2012, an additional row of fastening features were added to improve the fit of the leather seat covers on the basic and sports seats. As a consequence of this change, the temperature sensor within the seat…
• 10121947Oct 21, 2013Equipment, Engine cooling. The A/C Compressor has been diagnosed as faulty and will be replaced under warranty. When performing replacement of an A/C Compressor under warranty, the amount of refrigerant and oil recovered must be documented.
• 10121944Oct 21, 2013Seats. Supersedes Technical Service Bulletin Group 72 number 13-05 dated September 5, 2013. Customer may report hearing squeak or rattle sounds coming from the rear seat area. The rattle sound may be caused from the pivot point of the torsion bar within the 2/3 rear seat backrest pivot assembly. The squeak noise may be coming from the rear seat armrest area, specifically from the contact surface between the armrest lock…
• 10121316Oct 21, 2013Electrical system, Air bags. Supersedes Technical Service Bulletin Group 69 number 12-25 dated April 25, 2012. After the airbag control module (J234) has been replaced, the control unit cannot be coded via SVM spec/actual. An SVM code is required to code and parameterize the new service replacement airbag control module. Each model?s SVM code is provided in a parts bulletin (GP bulletin), which should have been referenced through ETKA when the…
• 10068117Oct 21, 2013Electrical system. Summary to be provided on a future date.
• 10068111Oct 21, 2013Seats. Summary to be provided on a future date.
• 10121949Oct 16, 2013Equipment. Supersedes Technical Service Bulletin Group 91 number 13-06 dated September 12, 2013. Customer reports sound system ?pops? and loses audio for a few seconds (for vehicles with base sound system) or sound system loses audio for a few seconds and returns on its own (for vehicles with Bose or Bang & Olufsen sound system). If the sound does not return on its own, or is accompanied by relevant DTCs in the vehicle…
• 10068160Oct 16, 2013Equipment. Summary to be provided on a future date.
• 10243774Oct 14, 2013Equipment. Audi Elsa Newsletter
• 10228332Oct 10, 2013Engine cooling. Under certain driving conditions, the secondary air ports in the cylinder head can accumulate carbon over time, causing a restriction.
• 10225011Oct 10, 2013Engine cooling. Under certain driving conditions, the secondary air ports in the cylinder head can accumulate carbon over time, causing a restriction.
• 10221984Oct 10, 2013Engine cooling. Under certain driving conditions, the secondary air ports in the cylinder head can accumulate carbon over time, causing a restriction.
• 10121297Oct 10, 2013Engine. Supersedes Technical Service Bulletin Group 01 number 13-24 dated August 20, 2013. MIL on. DTCs are stored in the engine control module. Mileage is greater than 15,000 miles. Under certain driving conditions, the secondary air ports in the cylinder head can accumulate carbon over time, causing a restriction.
• 10228330Oct 8, 2013Engine cooling. During reset of the service reminder, the following message appears on the ODIS tester: ?Secondary air injection system - checking secondary air mass?. Under certain driving conditions, the secondary air ports in the cylinder head can accumulate carbon over time, causing a restriction. The ODIS tester can identify the state of the restriction, and will request that the system is cleaned in order to prevent the MIL…
• 10225009Oct 8, 2013Engine cooling. During reset of the service reminder, the following message appears on the ODIS tester: ?Secondary air injection system - checking secondary air mass?. Under certain driving conditions, the secondary air ports in the cylinder head can accumulate carbon over time, causing a restriction. The ODIS tester can identify the state of the restriction, and will request that the system is cleaned in order to prevent the MIL…
• 10221982Oct 8, 2013Engine cooling. During reset of the service reminder, the following message appears on the ODIS tester: ?Secondary air injection system - checking secondary air mass?. Under certain driving conditions, the secondary air ports in the cylinder head can accumulate carbon over time, causing a restriction. The ODIS tester can identify the state of the restriction, and will request that the system is cleaned in order to prevent the MIL…
• 10121295Oct 8, 2013Equipment. During reset of the service reminder, the following message appears on the ODIS tester: ?Secondary air injection system - checking secondary air mass?. MIL is not illuminated. Under certain driving conditions, the secondary air ports in the cylinder head can accumulate carbon over time, causing a restriction. The ODIS tester can identify the state of the restriction, and will request that the system is cleaned in…
• 10212668Oct 7, 2013Electrical system. Low battery charge: excess current draw location
• 10121306Oct 7, 2013Electrical system. Supersedes Technical Service Bulletin Group 27 number 12-13 dated March 22, 2012. The customer may report a discharged battery when trying to start the vehicle. The condition results in a no start.
• 10212667Oct 4, 2013Electrical system. Battery testing and charging - vehicles with BDM
• 10210615Oct 4, 2013Equipment. Battery testing and charging for vehicles equipped with a Battery Data Manager (BDM - J367). When the InCharge 940 is used as a battery charger in auto mode, it performs a battery condition test and may prematurely fail the battery if the charging takes place at the jumper posts in the engine compartment. This is due to the added resistance in the system between the battery and jumper posts.
• 10121314Oct 4, 2013Visibility (wipers, defrost, mirrors). Supersedes Technical Service Bulletin Group 66 number 13-34 dated September 30, 2013. The customer may report hearing wind noise while driving at highway speeds. The noise may occur on either side of the vehicle. Wind noise may be coming from either the mirror base or the lane change assist lamp. Improved parts are available.
• 10121305Oct 4, 2013Electrical system. Supersedes Technical Service Bulletin Group 27 number 12-10 dated February 13, 2012. Battery testing and charging for vehicles equipped with a Battery Data Manager (BDM - J367). When the InCharge 940 is used as a battery charger in auto mode, it performs a battery condition test and may prematurely fail the battery if the charging takes place at the jumper posts in the engine compartment. This is due to the added…
• 10066990Oct 4, 2013Body and structure. Summary to be provided on a future date.
• 10121945Oct 2, 2013Equipment, Body and structure. Supersedes Technical Service Bulletin Group 70 number 08-39 dated December 4, 2008. Leather upholstery is dirty or stained.
• 10243918Oct 1, 2013Fuel system, Other or unknown. Audi Oil Capacity Chart
• 10243781Sep 30, 2013Equipment. Audi Elsa Newsletter
• 10121352Sep 30, 2013Electrical system. Supersedes Technical Service Bulletin Group 66 number 13-32 dated September 26, 2013. The customer may report hearing wind noise while driving at highway speeds. The noise may occur on either side of the vehicle. Wind noise may be coming from either the mirror base or the lane change assist lamp. Improved parts are available.
• 10121351Sep 30, 2013Visibility (wipers, defrost, mirrors). Supersedes Technical Service Bulletin Group 66 number 13-27 dated April 8, 2013. Wind noise is heard by the customer at highway speeds. Air flows through the exterior rear view mirror housing at the seam where the turn signal lamp meets the housing. This causes a high-frequency whistling tone.
• 10121343Sep 30, 2013Equipment. Supersedes Technical Service Bulletin Group 51 number 13-06 dated August 9, 2013. Instructions for vehicle inspection, protection removal, and detailing.
• 10066988Sep 30, 2013Body and structure. Summary to be provided on a future date.
• 10066987Sep 30, 2013Body and structure. Summary to be provided on a future date.
• 10249104Sep 27, 2013Steering. Power Steering Control Unit Software (NVLW)
• 10216643Sep 27, 2013Equipment. Electronic oil consumption measurement
• 10121397Sep 27, 2013Steering. When making minor steering movements while driving in a straight line in Audi vehicles with electromechanical power steering manufactured within a specific period, the customer may occasionally perceive slight irregularities with the assistance provided by the power steering. This phenomenon mainly occurs when the temperature is around the freezing point. This is a comfort-related issue; therefore no warning symbol…
• 10121338Sep 27, 2013Suspension, Steering. Supersedes Technical Service Bulletin Group 44 number 13-36 dated February 18, 2013. This bulletin is not applicable if this vehicle has a Repair Authorization on this topic. Customer feels vibration in the seat, vehicle floor, footwell, pedals, or steering wheel. This condition does not lead to any handling concerns or loss of vehicle control. The customer feels the vibration in one or both of the following…
• 10121325Sep 27, 2013Engine. Supersedes Technical Service Bulletin Group 17 number 11-24 dated November 11, 2011. Electronic oil consumption measurement - Repair Authorization Model Year 2012. In order to provide effective lubrication and cooling of internal engine components, all internal combustion engines consume a certain amount of engine oil. Oil consumption varies from engine to engine, and may change significantly over the life of the…
• 10251001Sep 26, 2013Engine cooling. Rattling/engine noises in passenger compartment
• 10250660Sep 26, 2013Body and structure, Back-over prevention (rear camera). Rattling/engine noises in passenger compartment
• 10249082Sep 26, 2013Steering. Power Steering Control Unit
• 10121387Sep 26, 2013Electrical system. This communication is to inform you of that Update 48K8 has been revised to include a warning to ensure that the Bluetooth function of the scan tool must be physically switched off prior to performing this Update. The revised Update will be visible in ElsaWeb and ServiceNet on or about September 27, 2013. Please ensure your technicians are made aware of this new information.
• 10121350Sep 26, 2013Visibility (wipers, defrost, mirrors). Supersedes Technical Service Bulletin Group 66 number 13-31 dated June 12, 2013. The customer may report hearing wind noise while driving at highway speeds. The noise may occur on either side of the vehicle. Wind noise may be coming from either the mirror base or the lane change assist lamp. Improved parts are available.
• 10066868Sep 26, 2013Steering. Summary to be provided on a future date.

← All problems reported for the 2012 Audi Q5