2018 BMW 440I Technical Service Bulletins

190 technical service bulletins (TSBs) are on record for the 2018 BMW 440I. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10149572Oct 1, 2018Engine cooling, Electrical system. DME FC 1C0102 IS STORED WITH NO OTHER RELATED FAULTS. The following fault has been stored in the Digital Motor electronics (DME) fault memory with no other engine oil pressure faults stored: ??1C0102 - oil pressure control, plausibility, static: Pressure too low This fault will not cause a customer complaint or a Check Control Message (CCM). The fault is typically identified during unrelated diagnostics.
• 10149540Oct 1, 2018Electrical system. RAIN/LIGHT SENSOR (RLS): OIL LEAKAGE FROM GEL PAD. ??Oil leaking from the Rain/Light Sensor (RLS). Note: This oil serves as a separation medium between the RLS mounting gel pad and the windscreen. The oil ensures damage free disassembly in case of repair. CAUSE The oil that serves as the separation medium of the Rain/Light Sensor (RLS) gel pad and the windscreen leaks out. Expose the Rain/Light Sensor (RLS) and…
• 10149533Oct 1, 2018Equipment, Fuel system. SERVICE ACTION. RE-WORK SEAL OF FUEL FILLER HOUSING. The fuel filler pipe seal is possibly not mounted and/or only poorly mounted over the wheel arch flange. If incorrectly installed, water may leak into the luggage compartment. Incorrect installation during production.
• 10150894Sep 1, 2018Electrical system, Equipment, Body and structure. ?RETRACTABLE HARDTOP STATUS REQUEST SUPPLEMENT. INFORMATION Documents have been developed showing the known correct statuses for all hall sensors and micro switches used to operate the retractable hard top (RHT). This document is intended to act as a supplement to the diagnostic information available in ISTA. Comparing these statuses to the actual statuses of a vehicle with a functional problem may assist in…
• 10150057Sep 1, 2018Electrical system. ?BMW ONLINE NON-FUNCTIONAL: CHECK ICC-ID IN ACCOUNT. BMW Online/BMW ConnectedDrive not functional. Vehicle and service cockpit have different ICC-ID's (Integrated Circuit Card Identifier).
• 10150056Sep 1, 2018Electrical system. ?CONNECTEDDRIVE/BMW ASSIST SYSTEM DIAGNOSIS INFORMATION. ConnectedDrive/BMW Assist features are partially or completely inoperative. This Service Information bulletin is being published because vehicles are down for an extended period of time when researching system failures with ConnectedDrive or BMW Assist. This Service Information bulletin will assist you both in identifying the issue and providing technical…
• 10145340Jul 1, 2018Steering. STEERING WHEEL BUTTONS DO NOT FUNCTION RELIABLY: Sporadic or continuous malfunction of multifunction steering wheel buttons
• 10145339Jul 1, 2018Electrical system. AFTER EXCHANGING THE FRONT ELECTRONIC MODULE (FEM), PROGRAMMING / ENCODING IS NOT POSSIBLE: After replacing the Front Electronic Module (FEM) for an applicable repair, programming / encoding is not possible.
• 10145321Jul 1, 2018Equipment. PHONE CONTACTS: HEADUNIT BASIC 2 SORTING ORDER: Improper sorting of phone contacts, in the on-board computer or in the Central Information Display (CID), upon connecting to the vehicle:
• 10145320Jul 1, 2018Equipment. CONNECTEDDRIVE/BMW ASSIST SYSTEM DIAGNOSIS INFORMATION: ConnectedDrive/BMW Assist features are partially or completely inoperative.
• 10145283Jul 1, 2018Engine, Engine cooling. BUZZING NOISE FROM VALVETRONIC MOTOR BEFORE OR AFTER ENGINE OPERATION: Buzzing noise may be heard from the Valvetronic motor when the vehicle is unlocked, before the engine is started, or after the engine is turned off.
• 10145316Jun 1, 2018Equipment. COMPONENT PROTECTION ACTIVE. HEAD UNITS CANNOT BE SWAPPED BETWEEN VEHICLES FOR TESTING.: If either the head unit (NBT-EVO or ENTRY-NAV-EVO) or the Body Domain Controller (BDC) are swapped into a different vehicle they will cause the head unit to enter a locked mode once it recognizes a different VIN.
• 10145306Jun 1, 2018Equipment. NAVIGATION SYSTEM: REPORTING MISSING OR INCORRECT ROAD MAP DATA: The route guidance is inaccurate and therefore irritating to the customer; or it is not possible to locate certain addresses, for instance:
• 10145298Jun 1, 2018Seats. MEMORY SEAT ADJUSTMENT IS LIMITED: After programming the vehicle with ISTA 4.10.2x, the adjustment range of the memory seat may restricted.
• 10145293Jun 1, 2018Engine. SERVICE ACTION: PROGRAM CONTROL UNITS (DME): The check engine light is illuminated and the vehicle may run roughly
• 10143570May 1, 2018Electrical system. HEAD UNIT HIGH 2 RESET WHILE BLUETOOTH IS CONNECTED: The following event may cause an unexpected reset of the Head Unit High 2 (NBT EVO) when:
• 10143569May 1, 2018Electrical system, Equipment. BMW ONLINE NON-FUNCTIONAL: CHECK ICC-ID IN ACCOUNT: BMW Online/BMW ConnectedDrive not functional.
• 10143565May 1, 2018Equipment. NAVIGATION PRO (NBT EVO) MAP UPDATE NOT POSSIBLE, NAVIGATION DOES NOT START: Navigation system will not start at all or the: ÒNavigation system startsÓ message is permanently displayed; or
• 10143564May 1, 2018Equipment. NAVIGATION SYSTEM: REPORTING MISSING OR INCORRECT ROAD MAP DATA: The route guidance is inaccurate and therefore irritating to the customer; or it is not possible to locate certain addresses, for instance:
• 10138411Apr 1, 2018Equipment. HEAD UNIT HIGH 2 RESET WHILE BLUETOOTH IS CONNECTED: The following event may cause an unexpected reset of the Head Unit High 2 (NBT EVO) when:
• 10138410Apr 1, 2018Equipment. IPHONE: CALL LIST MISSING AFTER RESTART: The call list from iPhone 8 or iPhone X, that is displayed, is missing after cycling the ignition.
• 10138404Apr 1, 2018Electrical system, Equipment. NBT-EVO Head Unit Cannot be Swapped between Vehicles for Testing: If either the NBT-EVO head unit or Body Domain Controller (BDC) are swapped into a different vehicle they will cause the head unit NBT-EVO to enter a locked mode once it recognizes a different VIN.
• 10138402Apr 1, 2018Electrical system. INSTRUMENT CLUSTER OUTSIDE TEMPERATURE DISPLAY IMPLAUSIBLE: In the Instrument Cluster (Kombi) display you may observe an implausible outside temperature reading.
• 10138375Apr 1, 2018Engine. DME FC 1C0102 IS STORED WITH NO OTHER RELATED FAULTS: The following fault has been stored in the Digital Motor electronics (DME) fault memory with no other engine oil pressure faults stored.
• 10136357Mar 1, 2018Equipment. HVAC BLOWER NOT WORKING: HVAC blower is not working.
• 10136355Mar 1, 2018Exterior lighting. HEADLIGHT ASSEMBLIES HAVE VISIBLE INTERNAL MOISTURE/CONDENSATION: Water on the inside (A) or misting (B) of both headlight lenses that is visible from outside.
• 10136344Mar 1, 2018Latches, locks and linkages. TAILGATE UNINTENTIONALLY OPENS: Trunk/tailgate may open when vehicle is locked.
• 10136336Mar 1, 2018Engine cooling, Equipment. DIAGNOSING NOISE FROM THE REAR EXHAUST FLAP (B58): There is a rattling noise from the rear exhaust flap during initial start-up.
• 10136333Mar 1, 2018Electrical system. ROUGH RUNNING AND VARIOUS VANOS FAULTS STORED: The check engine light is illuminated and the vehicle may run rough at idle and while driving.
• 10136000Mar 1, 2018Equipment. CONNECTEDDRIVE-REMOTE SERVICES DO NOT FUNCTION: Remote Services (such as locking and unlocking the car, vehicle location by honking the horn, flashing the lights or on the map in the BMW Connected App) do not function after vehicle has been sitting for extended amount of time (In excess of 20 hours).
• 10135998Mar 1, 2018Equipment. BLUETOOTH AND USB AUDIO PLAYBACK FUNCTIONS MISSING - IPHONE: Playlists, song titles, etc. from iPhone do not display on Head Unit Basic 2.
• 10135995Mar 1, 2018Equipment. CONTACTLESS TAILGATE (SMART OPENER) IS TOO SENSITIVE: When the remote is located in the range of the Smart Opener operation may be the contactless tailgate (Smart Opener) opens / close unintentionally from objects in the vicinity of the rear of the vehicle; for example by a gas filling hose.
• 10135992Mar 1, 2018Equipment. NBT-EVO Head Unit Cannot be Swapped between Vehicles for Testing. 'Component Protection Active': If either the NBT-EVO head unit or Body Domain Controller (BDC) are swapped into a different vehicle they will cause the head unit NBT-EVO to enter a locked mode once it recognizes a different VIN.
• 10154817Feb 1, 2018Engine. ENGINE VIBRATIONS OR NOISE. One of the following complaints may be reported The engine runs erratically; The engine causes vibrations when running; Grinding noise from the engine compartment when engine is running.
• 10136305Feb 1, 2018Steering. CHECK CONTROL MESSAGE (CCM): ASSISTANCE SYSTEM RESTRICTED AFTER DELETING TRANSPORT MODE: The CCM assistance systems restricted or pedestrian protection system failed is displayed after deleting transport mode.
• 10135054Feb 1, 2018Equipment. BMW APPS RANDOMLY STARTS PLAYING ON ITS OWN: While listening to FM, or AM, or Satellite Radio (SDARs), the audio source randomly switches to BMW Apps (Pandora, Spotify, Audible etc.) with no input from driver or passenger.
• 10135052Feb 1, 2018Electrical system. Head unit high resets with connection of iphone 8, iphone 8+ or iphone x
• 10135050Feb 1, 2018Fuel system. CONTACTLESS TAILGATE (SMART OPENER) IS TOO SENSITIVE: When the remote is located in the range of the Smart Opener operation may be the contactless tailgate (Smart Opener) opens / close unintentionally from objects in the vicinity of the rear of the vehicle; for example by a gas filling hose.
• 10135042Feb 1, 2018Electrical system. FUEL GAUGE ERRONEOUS DISPLAY: Vehicle runs out of fuel but the instrument cluster still displays fuel remaining in the tank.
• 10135040Feb 1, 2018Electrical system. INSTRUMENT CLUSTER BLANKS OUT OR REMAINS DARK AFTER STARTING THE VEHICLE: Instrument cluster display goes black during starting or while driving.
• 10135038Feb 1, 2018Body and structure. NOISES FROM THE C-PILLAR AREA OF THE CONVERTIBLE TOP: Cracking or clicking noises can be heard from the rear area of the convertible top (C-pillar area) when driving on uneven roads.
• 10142945Jan 1, 2018Equipment. Bluetooth Connection Failures: There are various connectivity failures with the following devices: Apple iPhones: Samsung S6 and the S6 Edge.
• 10142941Jan 1, 2018Equipment. Nbt-evo (next generation navigation professional) head unit cannot be swapped between vehicles for testing. õcomponent protection activeõ
• 10142940Jan 1, 2018Equipment. NO AUDIO PLAYBACK AFTER REPLACING THE HEAD UNIT HIGH 2 (HU-H2): After replacing the Head Unit High (HU-H2) and performing ISTA4 programming, there is no audio playback.
• 10142933Jan 1, 2018Body and structure. TAILGATE UNINTENTIONALLY OPENS: Trunk/tailgate may open when vehicle is locked.
• 10142926Jan 1, 2018Engine cooling. No audible difference in exhaust with "m performance power and sound kit
• 10136739Nov 1, 2017Equipment. ENTRY EVO HEAD UNIT WILL NOT PLAY MP3 FORMATTED CD's: Data CDÕs (encoded as MP3Õs) can NOT be played.
• 10146769Sep 1, 2017Air bags. "AIRBAG WARNING LIGHT: ACSM FC 930A60 OR 930A1C SEAT OCCUPANCY DETECTION. According to the customer, the airbag warning light was on, but it may not be on when the vehicle arrives in the workshop. 1. ACSM fault code ""930A60 - Seat occupancy detection, front passenger; malfunction"" is stored. The fault may or may not currently be present. Or 2. ACSM fault code ""930A1C - Front passenger seat occupancy detection…
• 10146765Sep 1, 2017Electrical system. "BATTERY DISCHARGE CCM (CHECK CONTROL MESSAGE) DISPLAYED: COMFORT ACCESS DISABLED. One or more of the following conditions are present: * CCM ""Battery. Discharge in standstill."", or similar, is displayed. * Comfort Access and contactless tailgate opening are not working. * Vehicle can still be unlocked with radio remote control (ID transmitter). Fault conditions are cleared upon engine restart.
• 10146763Sep 1, 2017Electrical system. VARIOUS CCM (CHECK CONTROL MESSAGES) CAUSED BY SHORTED K-CAN. The customer states that one or more of the following CCM are displayed: * 627 - Steering behavior: Drive moderately * 070 - Steering: Drive moderately * 765 - Rear-end collision restricted * 850 - Pedestrian warning restricted * 236 - Driving stabilization: Drive moderately * 299 - SOS call system failure * 042 - Brake system: Drive moderately After…

← All problems reported for the 2018 BMW 440I