2018 BMW X2 Technical Service Bulletins

109 technical service bulletins (TSBs) are on record for the 2018 BMW X2. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10172494Feb 1, 2020Visibility (wipers, defrost, mirrors). LIN BUS FAULTS WITH EXTERIOR REARVIEW MIRROR GLASS DAMAGE: This Service Information Bulletin (Revision 2) replaces SI B51 13 18 dated February 2020. The exterior rearview mirror glass is discolored or cracked. The power windows and folding mirrors may not operate.
• 10172489Feb 1, 2020Equipment, Electrical system. MIL LIGHT ILLUMINATED AT LOW AMBIENT TEMPERATURES. After engine start the malfunction indicator lamp (MIL) and Check Control message (ID 29) "Engine fault! Power loss" are displayed in the instrument cluster. In addition The following fault codes are stored in the Digital Motor Electronics (DME) Engine runs in failsafe mode Engine cannot exceed 800 - 1200 RPMs.
• 10171492Jan 1, 2020Seats. GROANING NOISE FROM TRIM APERTURE ON THE FRONT SEAT: When getting in or out of the vehicle a groaning noise can be heard from the opening (aperture) in the seat backrest. The noise may be heard from one or both of the front seats. The trim aperture in the front seat is insufficiently lubricated. The front and rear halves of the trim can contact each other causing friction noise.
• 10171479Jan 1, 2020Engine cooling. MALFUNCTION INDICATOR LAMP IS ILLUMINATED WITH A CRANKSHAFT ADAPTION FAULT: When diagnosing an illuminated malfunction indicator lamp (MIL) and/or a different issue the following faults may also be stored in the Digital Motor Electronics (DME). Fault code Control module Fault code text 213A2B DME Increment wheel adaption faulty This situation is not associated with any drivability complaints and only affects…
• 10171414Jan 1, 2020Air bags. SIDE PANEL REAR LIGHT HOUSINGS: LTD WTY EXT TO 10 YEARS WITHOUT MILEAGE LIMIT: The rear light housing(s) can loosen/detach at the mounting tabs this can cause a clacking sound in the rear of the vehicle while driving. The plastic mounting tabs for the rear tail light assembly housing(s) may become too brittle and crack to the point where the hold down nut(s) can no longer keep the housing(s) in place.
• 10170580Dec 1, 2019Seats. NOISE DURING FORWARD / BACK SEAT ADJUSTMENT OVER THE ENTIRE LENGTH OF TRAVEL: A loud screeching noise can be heard from the front driver's or passenger's seat during forward/back seat adjustment.
• 10169468Nov 1, 2019Equipment, Visibility (wipers, defrost, mirrors). Low Washer Fluid Warning Light is illuminated when the Washer Fluid Tank is Full : The low washer fluid warning is illuminated even though the washer fluid reservoir is full. There are no faults stored in the system for the washer fluid level switch. A non-approved washer fluid was used that is silicone-based. Silicone-based fluids are not compatible with the contactless capacitive level sensor. Fluids that contain…
• 10168015Oct 1, 2019Electrical system, Steering. LDW (LANE DEPARTURE WARNING): STEERING WHEEL VIBRATION NOT WORKING. LDW steering wheel vibration is not working. Software in the Body Domain Controller (BDC) control unit.
• 10168008Oct 1, 2019Equipment. VEHICLE WILL NOT UNLOCK USING THE REMOTE CONTROL KEY BUTTON. The vehicle cannot be unlocked using the remote control key button. However, comfort access operates normally at the front door handles and the tailgate.
• 10166390Sep 1, 2019Electrical system. HEAD UNIT NBT EVO (HU-H2) PROGRAMMING ABORT: The CID screen may light up blue. When this occurs A battery reset is not successful in restoring head unit operation Software error in the Bootloader file (BTLD) of the head unit.
• 10166382Sep 1, 2019Equipment, Electrical system. SUNROOF DOES NOT MOVE: The sunroof does not move and the vehicle has no faults stored related to the sunroof.
• 10166378Sep 1, 2019Seats, Equipment. NOISE DURING FORWARD/BACK SEAT ADJUSTMENT OVER THE ENTIRE LENGTH OF TRAVEL: A loud screeching noise can be heard from the front driver's or passenger's seat during forward/back seat adjustment.
• 10166229Sep 1, 2019Suspension. Front Suspension Ride Height Has Dropped: The front suspension ride height has dropped on one or both sides due to overload. This is caused by driving over obstacles (e.g. potholes) or an impact severe enough for the front spring strut damper to slip through the clamp of the steering knuckle.
• 10165277Aug 1, 2019Engine cooling, Transmission and drivetrain. RATTLING NOISE FROM ENGINE IN NEUTRAL This Service Information bulletin supersedes SI B11 07 19 dated May 2019. The affected production range has been increased by 6 months. Rattling noises coming from the oil sump and crankcase area when the engine is running with the transmission in neutral. The noise can be heard outside the vehicle.
• 10165266Aug 1, 2019Equipment. SECURITY IMPROVEMENTS FOR CONNECTEDDRIVE. Security patches for non-safety critical vulnerabilities in BMW head units Entry Nav Entry Media NBT and NBT EVO.
• 10163996Jul 1, 2019Electrical system, Equipment, Engine. ENGINE MAY SWITCH OFF SHORTLY AFTER THE FIRST MSA RESTART. MSA is the automatic start/stop feature for the engine. The engine may switch off immediately after an automatic start (MSA restart). This issue may only occur if the automatic stop (MSA stop) occurs within ten seconds after a manual engine start (using the start/stop button).
• 10163995Jul 1, 2019Equipment, Engine cooling. DIAGNOSTIC HINT: CATALYTIC CONVERTER INSPECTION AFTER LOSS OF CRANKSHAFT SIGNAL. In certain situations when the crankshaft position signal is lost while driving the malfunction indicator lamp (MIL) and an engine malfunction check control message (CCM #29) may be displayed. The engine may run roughly or with reduced power.
• 10163056Jun 1, 2019Electrical system. HEAD UNIT NBT EVO (HU-H2) PROGRAMMING ABORT. During programming several aborts can occur in the head unit NBT EVO (HU-H2).
• 10163031Jun 1, 2019Electrical system. HIGH ENGINE SPEED IMMEDIATELY AFTER STARTING. In rare circumstances after the engine is started with the Start-Stop button the engine speed may immediately increase to a high constant RPM (approximately 3000 rpm).
• 10163027Jun 1, 2019Engine, Engine cooling. ENGINE VIBRATIONS OR NOISE This Service Information bulletin replaces SI B11 01 19 dated February 2019.
• 10161581May 1, 2019Electrical system, Equipment. BLUETOOTH CONNECTION IS LOST DURING A PHONE CALL. During an active call the call audio autonomously switches from the vehicle hands-free system to the phone.
• 10161579May 1, 2019Equipment. Telematics control unit activation via dcsnet for bmw assist.
• 10161578May 1, 2019Equipment. INFORMATION New information provided by this revision is preceded by this symbol. This Service Information bulletin replaces SI B84 02 14 dated September 2018.
• 10161571May 1, 2019Exterior lighting, Equipment. The tail light mounting brackets may be cracked or broken. During assembly oil may have contaminated the plastic housing of the rear tail lamps causing damage to the mounting points of the tail light assembly.
• 10161568May 1, 2019Electrical system, Body and structure. SERVICE ACTION: BODY DOMAIN CONTROLLER REPLACEMENT. During vehicle production there is the possibility that the cavity preservation wax leaked from the body and dripped onto the Body Domain Controller (BDC) and its wiring harness connector.
• 10161556May 1, 2019Engine cooling, Electrical system. DELIVERY STOP: PROGRAM CONTROL UNITS (DME). A Delivery Stop has been issued (effective May 16 2019) on certain Model Year 2016-2020 BMW vehicles that have been produced between June 19 2015 and April 17 2019. A software error within the Digital Motor Electronics (DME) may cause a miscalculation of an onboard diagnostic (OBD) function. All vehicles will need a software update (no parts required).
• 10161551May 1, 2019Equipment, Engine cooling. SERVICE ACTION: LOCK THE DME FAULT MEMORY (F39 F48). The fault memory lock in Digital Motor Electronics (DME) control unit was not activated. An activated lock would prevent the manual deletion of permanent fault codes. The DME fault memory lock has not been set.
• 10161548May 1, 2019Engine cooling, Transmission and drivetrain. Service Information May 2019 Engine B11 07 19 Technical Service RATTLING NOISE FROM ENGINE IN NEUTRAL. Rattling noises coming from the oil sump and crankcase area when the engine is running with the transmission in neutral.
• 10161546May 1, 2019Engine cooling, Electrical system. FAULT 118002 - MIXTURE TOO RICH SETS DURING WINTER WITH COLD AMBIENT TEMPERATURES. The Service Engine Soon (MIL) light is on with the following fault stored in the Digital Motor Electronics (DME). In the situation being described the fault is primarily stored during the cold winter months along with the use of winter fuel.
• 10160350Apr 1, 2019Equipment, Visibility (wipers, defrost, mirrors). The Low Washer Fluid Warning Light is illuminated when the Washer Fluid Tank is Full This Service Information bulletin supersedes SI B61 23 15 dated April 2016.
• 10160289Apr 1, 2019Equipment, Exterior lighting. DELIVERY STOP: REWORK TAIL LIGHTS. The tail light mounting brackets may be cracked or broken. During assembly oil may have contaminated the plastic housing of the rear tail lamps causing damage to the mounting points of the tail light assembly.
• 10160267Apr 1, 2019Visibility (wipers, defrost, mirrors). The Low Washer Fluid Warning Light is illuminated when the Washer Fluid Tank is Full This Service Information bulletin supersedes SI B61 23 15 dated April 2016.
• 10160220Apr 1, 2019Exterior lighting. DELIVERY STOP: REWORK TAIL LIGHTS. The tail light mounting brackets may be cracked or broken. During assembly oil may have contaminated the plastic housing of the rear tail lamps causing damage to the mounting points of the tail light assembly.
• 10159151Mar 1, 2019Equipment, Electrical system. PHONE CALL AUDIO AUTONOMOUSLY SWITCH FROM VEHICLE TO PHONE. During an active phone call the call audio autonomously switches from the vehicle hands-free system to the phone.
• 10159143Mar 1, 2019Air bags. AIR BAG WARNING LAMP CC MESSAGE 'RESTRAINT SYSTEM'. Air bag Warning indicator sporadically illuminates for short intervals when occupants are exiting the front of the vehicle.
• 10159117Mar 1, 2019Engine. CHECK ENGINE OIL LEVEL MESSAGE. "Check engine oil level" Check Control message (ID961) appears when starting the engine and again at the end of a trip.
• 10153774Jan 1, 2019Electrical system, Air bags. AIRBAG INDICATOR LIGHT REMAINS ON AFTER SEAT OCCUPANCY MAT REPLACEMENT. The airbag indicator light illuminates after replacing the CIS (Capacitive Interior Sensing) mat.
• 10153749Jan 1, 2019Steering. SERVICE ACTION: MECHANICAL STEERING COLUMN. The steering column adjustment gears may not have been aligned correctly Fault in the production of the steering column.
• 10153647Jan 1, 2019Equipment. INSUFFICENT AIR COMING FROM VENTS. Air quantity from vents does not chance with blower speed.
• 10153644Jan 1, 2019Exterior lighting. Delivery stop: rear lamp.
• 10153640Jan 1, 2019Seats. FRONT PASSENGER SEAT SPORADIC MOVEMENT. Occasional stopping of seat adjustability movement in the driver and front passenger seats when occupied.
• 10153708Dec 1, 2018Electrical system. Instrument cluster fault b7f67e main board fault stored.
• 10153691Dec 1, 2018Engine cooling, Engine. FAULT 118002 - MIXTURE TOO RICH SETS DURING WINTER WITH COLD AMBIENT TEMPERATURES. The Service Engine Soon (MIL) light is on with the following fault stored in the Digital Motor Electronics (DME). Fault: 118002 - Mixture too rich In the situation being described.
• 10152667Nov 1, 2018Body and structure. RATTLE NOISE FROM LOWER A-PILLAR. A rattle noise is present from the lower area of the A-Pillar. Due to a manufacturing error, the bolt securing the front door brake/stop to the A-Pillar may have loosened over time.
• 10149541Oct 1, 2018Electrical system. INSTRUMENT CLUSTER FAULT B7F67E MAIN BOARD FAULT STORED. During the service visit, or after programming or exchanging the Instrument Cluster (KOMBI) there is a stored fault B7F67E - KOMBI Control Unit: Restart the main board (watchdog) Software error in the instrument cluster (Kombi).
• 10149537Oct 1, 2018Electrical system. THE DISPLAY GOES BLACK, THE ENGINE CAN BE SWITCHED OFF ONLY VIA THE EMERGENCY-OFF.. * On board computer and navigation system goes black or resets. * The engine can only be switched off by pressing the START/STOP button three times (Emergency STOP) * Various Check Control messages are displayed.
• 10150896Sep 1, 2018Equipment, Electrical system. "?REMOTE KEY WILL NOT OPEN OR START VEHICLE. Remote key battery in service significantly less (under a year) than expected two-year life-span. Remote key will NOT: * Open/close vehicle door locks * Start engine (except when held directly against steering column) CC message ""Battery of remote key empty (ID:00067)"" displayed Fault memory entry ""BDC 804415- ID Transmitter: Battery under-voltage"" stored Remote key…
• 10150057Sep 1, 2018Electrical system. ?BMW ONLINE NON-FUNCTIONAL: CHECK ICC-ID IN ACCOUNT. BMW Online/BMW ConnectedDrive not functional. Vehicle and service cockpit have different ICC-ID's (Integrated Circuit Card Identifier).
• 10150056Sep 1, 2018Electrical system. ?CONNECTEDDRIVE/BMW ASSIST SYSTEM DIAGNOSIS INFORMATION. ConnectedDrive/BMW Assist features are partially or completely inoperative. This Service Information bulletin is being published because vehicles are down for an extended period of time when researching system failures with ConnectedDrive or BMW Assist. This Service Information bulletin will assist you both in identifying the issue and providing technical…
• 10145338Jul 1, 2018Engine cooling. THE DISPLAY GOES BLACK, VEHICLE DOESNT START AGAIN AFTER SWITCHING THE ENGINE OFF.: On board computer and navigation system goes black or resets.

← All problems reported for the 2018 BMW X2