2016 BMW X5 Fuel system Problems
- Complaints
- 12about this part
- Share
- 16%of 74 total for the year
- Median mileage
- 40,239miles
- Trend
- Not enough dataFewer than 15 complaints, too few for a reliable trend.
NHTSA recorded 12 complaints about the fuel system of the 2016 BMW X5, 16% of the 74 complaints for this model year. Where a mileage was given, the median is 40,239 miles. 2 recall campaigns on record are filed under a similar system.
Fewer than 15 complaints name this part, so treat the figures as a rough indication only.
Example complaints
Selected from NHTSA records; personal details are removed. They are consumer reports, not findings.
“According to the manufacturer sticker Bmw X5 5.0 gets 15/21mpg. I wish I get anywhere near that. I get about 11 average mpg. I took the car to the dealer twice and I called Bmw north america and they said that is the way it is. You will never get what you see on the sticker. So when you buy a car never trust what they say on the sticker price.”
NHTSA complaint #11043266, filed 2017-11, 5,000 miles“The engine light came on while I was 250 miles from home and on a Saturday. Was able to contact my dealer's service department who said to drive home and just monitor for any issues and hopefully it will be ok. I brought the vehicle in for diagnostic check following week. Faults were for the diesel particulate filter sensor and recommended $1300. replacement. They couldn't tell me if this part would impair the driving ability of the vehicle, but the cost seemed excessive for a sensor so I haven't made the repair yet (nor driven far) pending checking more into this. …”
NHTSA complaint #11550584, filed 2023-10“The contact owns a 2016 BMW X5. The contact stated while driving at approximately 50 MPH, the vehicle stalled. The message Drivetrain Failure was displayed on the instrument panel. The vehicle failed to restart. The vehicle was not drivable and was towed to a dealer where it was diagnosed that the high-pressure fuel pump had failed. The contact stated that the fuel system needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 129,000.”
NHTSA complaint #11617222, filed 2024-09, 129,000 miles“The contact owns a 2016 BMW X5. The contact stated that the vehicle was repaired under NHTSA Campaign Number: 21V586000 (Fuel System, Diesel); however, the repair failed to prevent the failure from occurring. The contact stated that on three separate occasions, the same recall failure had occurred. The vehicle was towed to the same local dealer where it was diagnosed with a fuel pump failure due to debris inside the fuel pump. The vehicle was not repaired due to the cost. The manufacturer was made aware of the failure. The failure mileage was approximately 40,239.”
NHTSA complaint #11657914, filed 2025-04, 40,239 miles“The component that failed appears to be the hybrid propulsion and charging system, including the high-voltage battery management system and/or integrated charging electronics. The vehicle will not accept a charge from any home or public charging source. The high-voltage battery was replaced approximately one year ago; however, the charging failure persists. The vehicle is available for inspection upon request. In addition to the charging failure, the vehicle displayed drivetrain malfunction and start/stop malfunction warnings. …”
NHTSA complaint #11719865, filed 2026-02Related recalls
- 21V907000Nov 19, 2021BMW of North America, LLC (BMW) is recalling certain 2013-2018 328d, 328d xDrive, 2014-2018 328d Sports Wagon, 328d xDrive Sports Wagon, 2014-2016 535d, 535d…Covers: BMW X5 2014–2017, 328D 2013–2018, X3 2015–2017 +2 more
- 21V586000Jul 29, 2021BMW of North America, LLC (BMW) is recalling certain 2014-2018 328d, 328d xDrive, X5 xDrive35d, 2014-2016 535d, 535d xDrive, 2015 740Ld xDrive, and 2015-2017…Covers: BMW X5 2014–2018, 328D 2014–2018, X3 2015–2017 +2 more
Related service bulletins
- 11015848Mar 13, 2025The High-Voltage (HV) Battery Assemblys Cell Modules Temperature Sensors (Internal NTC repair kit-specific) limited warranty for defects in materials or workmanship has been…
- 10247567Dec 20, 2023Engine will crank but not start. There is no communication with the integrated fuel module (TFE) whendiagnosing with ISTA. The following two fault codes will be stored in the…
- 10230717Dec 1, 2022For the eligible vehicles, BMW of North America, LLC (BMW NA) is extending the limited warranty for the vehicle's Fuel Injectors to 10 years/120,000 miles as determined by the…
- 10218412Jul 1, 2022The fuel gauge may indicate the incorrect fuel level (full and reserve).
- 10218318Jun 1, 2022Component specific limited warranty extension for the Exhaust Gas Recirculation Valve.
- 10204649Sep 1, 2021For the eligible vehicles, BMW of North America, LLC (BMW NA) is extending the limited warranty for the vehicle's engine high pressure fuel pump (shown) to: 10 years/120,000…
- 10184567Nov 1, 2020DIESEL FUEL INJECTORS: LTD WTY EXTENSION TO 10 YEARS/120,000 MILES: Zero-quantity adaptation injector cylinder 1: permitted filtered actuation duration 24BB00 correction too high…
- 10175268Apr 1, 2020Diesel Engine Intake Manifold Damaged: If Recall Campaign 18V-755: Exhaust Gas Recirculation (EGR) Cooler Inspection (and repair) (SI B11 17 18) applies and shows open on an…
- 10167976Oct 1, 2019N47T/N57T DIESEL FUEL INJECTORS: LTD WTY EXTENSION TO 10 YEARS/120,000 MILES. The vehicle may run rough or hesitate.
- 10163991Jul 1, 2019N63T ENGINE FUEL INJECTORS: LIMITED WARRANTY EXTENSION TO 10 YEARS/120000 MILES This Service Information Bulletin replaces SI B01 05 18 dated January 2018. Engine starts poorly…
Fuel system: other model years
| Year | Complaints | Share of year |
|---|---|---|
| 2026 | 2 | 7% |
| 2025 | 1 | 2% |
| 2024 | 4 | 3% |
| 2023 | 1 | 3% |
| 2022 | 3 | 4% |
| 2021 | 3 | 3% |
| 2020 | 2 | 2% |
| 2019 | 5 | 3% |
| 2018 | 18 | 25% |
| 2017 | 20 | 27% |
| 2016 | 12 | 16% |
| 2015 | 50 | 33% |
| 2014 | 32 | 32% |
| 2013 | 9 | 6% |
| 2012 | 29 | 11% |
| 2011 | 43 | 16% |
| 2010 | 29 | 23% |
| 2009 | 42 | 30% |
| 2008 | 41 | 19% |
| 2007 | 28 | 39% |
| 2006 | 5 | 3% |
| 2005 | 8 | 10% |
| 2004 | 2 | 3% |
| 2003 | 5 | 5% |
| 2002 | 1 | 1% |
| 2001 | 7 | 4% |
Other parts of the 2016 BMW X5
23 complaintsEngine
14 complaintsOther or unknown
14 complaintsTransmission and drivetrain
13 complaintsEngine cooling
7 complaintsAir bags
5 complaintsVisibility (wipers, defrost, mirrors)
5 complaintsBody and structure
4 complaintsSuspension
4 complaintsSteering
3 complaintsVehicle speed control
3 complaintsBrakes
2 complaints
← All problems reported for the 2016 BMW X5
About this data. Data from NHTSA (ODI) complaints, recalls, TSBs and investigations, updated Oct 29, 2026. Complaints are unverified consumer reports and may be duplicated or inaccurate.
To check a specific vehicle for open recalls, use its VIN at nhtsa.gov/recalls. Methodology