1992 Chevrolet C1500 Transmission and drivetrain Problems

“I have specific dates from repair bills if requested.I understand there was problems w/ the paint finish in which the dealership said the GM wasn't repairing the problem anymore. $1200.00 to repair. I bought the truck in 96' w/ 29,000 miles. The transmission has always clunked when shifting. The dealership said it was ok. 92 's shift hard normally. The water pump went out prematurly in which now I need to replace the oil rings do to warpage. The radiator was a surprise to me and especially the exuast system. …”

“Repair shop reports an obstruction in the hydraulic system of truck's front brakes, requiring replacement of front brake hoses, lines, calipers and brake pads. Also, there is a failure of the rear axle seals of the truck, causing damage to the rear brakes. The shop, sullivan's automotive service of kingwood, tx, also told me they have repeatedly observed failure of '91-'95 GM truck rear axle seals, which affects the performance of the truck's braking system. The cost to repair this defect in my vehicle is approximately $1300.”

“Original paint flaking off the exterior of truck; transmission jumping from high to low gear for no reason. Also when transmission gets under a load(climbing a small hill) the transmission vibrates excessively untill you let off of the throttle. The entire vehicle shakes.”

“Driving approximately 65mph and vehicle started to shift from overdrive to drive, heard engine making a noise and hit brakes to take out of cruise control. Suddenly saw smoke coming from the back and side and transmission fluid was leaking. Vehicle caught on fire, cause unknown. There was a recall on transmission oil cooling lines leaking, resulting in a fire. (93v-016). Fire being investigated by insurance company.”