2016 Chevrolet Cruze Technical Service Bulletins

1,331 technical service bulletins (TSBs) are on record for the 2016 Chevrolet Cruze. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10134545May 13, 2016Electrical system. This informational bulletin provides warranty information on accessory power outlet and trailer lighting fuse replacement.
• 10078880May 11, 2016Equipment. This preliminary information communication advises the technician that the upper and lower oil pan will be placed on product quality center part restriction. Dealer will need to call general motors product quality center for assistance.
• 10078878May 11, 2016Engine. This preliminary information communication advises the technician that the e80 engine control module part numbers 12669908 or 12672502 have been placed on part restriction by general motors technical assistance. Dealer will need to call general motors technical assistance center for further assistance.
• 10134536May 6, 2016Equipment. This warranty administration bulletin provides information on GM?s policy on performing GM covered vehicle services and maintenance on vehicles originating/sold in Canada.
• 10081443May 6, 2016Electrical system. This technical bulletin provides a procedure to retrofit the vehicles remote keyless system to correct a customer concern on the rke transmitter range of the remote start function being too short caused by electrical interference, which may degrade the remote signal and shorten the range.
• 10134537May 5, 2016Equipment. This informational bulletin provides information on the introduction of the 2016 Chevrolet Cruze to help the Service Department Personnel become familiar with some of the vehicle?s new features and to describe some of the action they will need to take to service this vehicle.
• 10081264May 3, 2016Electrical system. This technical bulletin provides a procedure to clear the dtc to correct a customer concern that the stop/start system is inoperative, “stop/start system disabled” message appears on the dic, malfunction indicator lamp (mil) being illuminated and dtc p16dc set caused by the dtc disabling the stop/start system.
• 10078583May 1, 2016Equipment. This informational bulletin provides information to advise the customers that have enrolled their vehicle into the onstar advanced diagnostics & real time diagnostic alerts they may receive alerts from their vehicle when it is being serviced.
• 10078571May 1, 2016Equipment. This informational bulletin provide information on the product quality center (pqc) assembly replacement process.
• 10078569May 1, 2016Fuel system, Other or unknown. This informational bulletin provides information on vehicles designed to operate on gaseous fuels.
• 10083782Apr 27, 2016Engine, Electrical system. This preliminary information communication advises the technician on the steps to diagnose and repair the concern of black smoke when starting the vehicle after sitting.
• 10083513Apr 27, 2016Equipment. This preliminary information communication advises the technician on the steps to diagnose and repair the concern of receiving frequent "off route" messages while following turn by turn (tbt) route navigation. The technician is provided instructions for resetting the vehicle communication interface module for this concern.
• 10078745Apr 27, 2016Equipment. This preliminary information communication advises the technician on the steps to diagnose and repair the concern of receiving frequent "off route" messages while following turn by turn (tbt) route navigation. The technician is provided instructions for resetting the vehicle communication interface module for this concern.
• 10083781Apr 22, 2016Electrical system. This preliminary information communication advises the technician on the steps to diagnose the concern, and the steps to repair the concern of the vehicle cranks but does not start. The technician is to inspect for a sheared cam pin in the engine.
• 10083765Apr 22, 2016Equipment. This preliminary information communication advises the technician on the steps to diagnose the concern and the steps to repair the concern. Phone will not connect to android auto.
• 10083587Apr 22, 2016Equipment. This preliminary information communication advises the technician to contact the gm technical assistance center for further instructions. The concern is the radio may be unable to save xm favorite stations.
• 10078548Apr 22, 2016Equipment. This informational bulletin announces that gm is offering an android auto feature upgrade for 2016 model year vehicles.
• 10083509Apr 21, 2016Equipment. This preliminary information communication advises the technician on the steps to diagnose and repair the concern. The vehicle's xm radio only has xm preveiw channels.
• 10083482Apr 21, 2016Equipment. This preliminary information communication advises the technician to diagnose the concern and the steps to repair the concern. The vehicle's xm travel link may be inopertive.
• 10078522Apr 20, 2016Equipment. "this technical bulletin provides a procedure to contact onstar for hard mute request to correct a customer concern when the radio is on, it does not mute enough when the onstar® turn-by-turn navigation directions are announced due to customer improperly setting the radio volume high enough when the turn-by-turn navigation messages are played. "
• 10078520Apr 20, 2016Electrical system. This informational bulletin provides information that may be useful on diagnosing batteries that have set for a long period of time and/or set in cold weather climates and testing those batteries.
• 10083884Apr 19, 2016Equipment. This preliminary information communication advises the technician on the steps for diagnosing the concern. The vehicle may be unable to connect to onstar using the white, blue or red onstar buttons.
• 10083484Apr 19, 2016Electrical system. This preliminary information communication provides information to help the dealership technicians perform a parasitic drain test for the onstar module. When performing battery parasitic drain test, there may be some confusion as to what the normal power consumption reading should be from the onstar system.
• 10078735Apr 19, 2016Electrical system. This preliminary information communication provides information to help the dealership technicians perform a parasitic drain test for the onstar module. When performing battery parasitic drain test, there may be some confusion as to what the normal power consumption reading should be from the onstar system.
• 10078507Apr 18, 2016Electrical system, Equipment. This warranty administration bulletin provide policy information on using the el-50313 midtronics gr8 battery tester/charger for diagnosing battery replacements and maintaining batteries on new vehicles in dealer inventory.
• 10078506Apr 18, 2016Electrical system. This informational bulletin provides warranty information on using the service programming system (sps) for programming control modules
• 10078504Apr 18, 2016Engine. This informational bulletin provides information internal engine noise or damage after oil filter replacement
• 10078502Apr 15, 2016Equipment. This warranty administration bulletin provides information on gm’s policy on performing gm covered vehicle services and maintenance on vehicles originating/sold in canada.
• 10078501Apr 13, 2016Body and structure, Visibility (wipers, defrost, mirrors), Equipment. This technical bulletin provides a procedure to install an air inlet deflector over the hvac air inlet to correct water leaking on the front passenger floor due to water running down the windshield under the air inlet grille panel, entering the body air inlet of the hvac system.
• 10078481Apr 12, 2016Equipment. This informational bulletin provides information on the purpose of magnetic drain plugs.
• 10078472Apr 12, 2016Visibility (wipers, defrost, mirrors). This informational bulletin provides information on a normal condition on tempered glass of spots showing on the rear and side windows when the vehicle is in the sunlight.
• 10078435Apr 7, 2016Equipment, Body and structure. This preliminary informational bulletin provides information that may be helpful when addressing underbody component corrosion with customers.
• 10083512Apr 5, 2016Visibility (wipers, defrost, mirrors), Equipment. This preliminary information communication advises the technician the steps on diagnosing the concern. Vehicle's sunroof operation intermittent, bind, noise, auto-reverse, and/or water leaks.
• 10078604Apr 5, 2016Electrical system, Body and structure, Visibility (wipers, defrost, mirrors). This preliminary information communication advises the technician the steps on diagnosing the concern. Vehicle's sunroof operation intermittent, bind, noise, auto-reverse, and/or water leaks.
• 10078434Apr 1, 2016Transmission and drivetrain. This informational bulletin provide information on the operating characteristics of a manual transmission.
• 10078431Apr 1, 2016Vehicle speed control. This informational bulletin provides information on a clicking noise or detent feel when depressing the accelerator pedal all the way down that should be considered normal operation.
• 10078430Apr 1, 2016Steering. "this technical bulletin provides a procedure to inspect the steering gear for a normal condition of grease or sealant on exterior case of gear due to the manufacturing process."
• 10078426Apr 1, 2016Electrical system. "this technical bulletin provides a procedure to inspect the g114 ground and repair as needed to correct a customer concern that the vehicle stalls, will not start, a/c does not work or the transmission does not shift correctly due to a loose ground connection at g114."
• 10078422Apr 1, 2016Brakes. This technical bulletin provides a procedure to inspect the foot operated parking brake assembly for the presence of a rubber stopper and remove if present to correct a customer concern that the red brake indicator is illuminated when the parking brake is released due to the stopper not being removed during assembly.
• 10078420Apr 1, 2016Electrical system. This technical bulletin provides a procedure to reprogram the radio to correct a customer concern of radio inoperative, blue screen, am clipping noise, hd on/off status not retained in stations, time lag on transitions, no audio with internal amp, park assist symbol position wrong in rear view camera.
• 10113973Mar 31, 2016Electrical system. This Preliminary Information communication provides information to the technician about vehicles that have a Diagnostic Trouble Code B101D stored in Telematics Communication Interface Control Module. Technician will check Global Warranty Management system for customer satisfaction program 15086 status. If the status of the customer satisfaction program 15086 was not completed follow the steps to get the Telematics…
• 10112831Mar 30, 2016Wheels. This informational bulletin provides information on chemical staining, pitting, and corrosion on wheels and the proper cleaners to use to fix the conditions due to multiple causes.
• 10112829Mar 29, 2016Equipment. This preliminary informational bulletin provides information on GM is implementing a new service strategy that uses a set of universal coaxial repair kits to service vehicles. This only applies to cable used for high frequency signals, such as cellular (OnStar®), satellite radio (XM) and GPS (navigation). The kits do NOT apply to the AM/FM cables.
• 10112821Mar 24, 2016Electrical system. This preliminary informational bulletin provides information on GM Accessory Remote start not working with onstars remotelink phone applications
• 10112819Mar 23, 2016Engine. This informational bulletin provides information on Identifying Non-GM (Aftermarket) Engine Calibrations for Gasoline Engines Using Tech 2® or GDS 2 (U.S. and Canada)
• 10113948Mar 21, 2016Equipment. This Preliminary Information communication provides information to the technician about iPhones will not always autoconnect through Bluetooth to the vehicle. If the vehicle has more than one device listed in the Bluetooth device list, and the last device used was an Apple product, the Apple products will not autoconnect. The system will connect to one of the other devices instead. This concern is usually noticed…
• 10112795Mar 15, 2016Equipment. This informational bulletin provides information on what is needed to be prepared for TAC, caller preparedness and checklists and contacting U.S. technical Assistance and the use of strategy based diagnostics
• 10112791Mar 14, 2016Equipment. This warranty administration bulletin provides information on Courtesy Transportation and Roadside Assistance Programs
• 10112789Mar 14, 2016Visibility (wipers, defrost, mirrors). This technical bulletin provides a procedure to relearn the power folding mirriors and road test to correct a conditon of power fold away mirriors glass shakes or flutters at normal driving speeds
• 10113928Mar 11, 2016Engine. This Preliminary Information communication advises the technician the 1.4L Engine Assembly Regular Production Option Code LE2 is on the engine exchange program. Dealerships are required to call the Product Quality Center not General Motors Technical Assistance Center to request an exchange.

← All problems reported for the 2016 Chevrolet Cruze