2007 Chevrolet Monte Carlo Technical Service Bulletins

852 technical service bulletins (TSBs) are on record for the 2007 Chevrolet Monte Carlo. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10084683Oct 15, 2012Equipment, Body and structure, Visibility (wipers, defrost, mirrors). This preliminary informational bulletin provides a procedure for relearning the power folding mirriors and road testin to verify they correct a condtion of the power folding mirriors glass shakes, flutters at normal driving conditions.
• 10118626Oct 10, 2012Equipment. This warranty administrational bulletin provides information on Clarification of Use - Dealer Empowerment Labor Operations and Customer Enthusiasm
• 10118623Oct 9, 2012Equipment. This warranty administrational bulletin provides information on courtesy transportation and roadside assistance programs offered through GM.
• 10118619Oct 5, 2012Equipment. This informational bulletin provides information on newly release bulletins used to fi the vehicles in the field the first time.
• 10246951Oct 1, 2012Equipment. Programming And Activation Of Replacement OnStar Modules.
• 10112439Oct 1, 2012Engine cooling. This Preliminary Information communication provides information to the technician that after installing a re-manufactured High Feature V6 engine the vehicle may rough running, idle surge, Check Engine Lamp or Camshaft Position sensor actuator codes. Technician will need to record the actual engine oil pressure at idle and engine compression readings. Technician will need to perform all testing listed in PIP4345A…
• 10037570Apr 1, 2012Body and structure. Gm: on some truck models there is some frame corrosion. *rm updated on 5/2/2012.
• 10025683Mar 1, 2012Engine cooling. Coolant leaking from engine (replace coolant crossover pipe gaskets). Vehicles with 3.5l or 3.9l engine. *pe updated on 5/1/2012.
• 10038294Jan 1, 2012Seat belts. Gm: there are seat belt problems: difficulty latching and unlatching buckle. Buckle release button is sticking. Seat belt warning light illuminated. Likely caused by sticky beverages that are spilled into the buckle assembly. *rm updated 4/3/12.
• 10029924Dec 1, 2011Air bags. General motors: diagnostic information for intermittent restraints, air bag (sir) indicator/lamp on with dtc(s) b0012, b0013, b0016, b0016, b0019, b0020, b0022, b0023, b0026, b0033, b0040, b0042 or b0044 set. This may be caused by a loose, missing, or broken connector position assurance (cpa) retainer at the air bag for the set dtc. Includes trailblazer ext. *pe updated 8/16/10. *pe updated 3/12/12.
• 10037184Oct 1, 2011Seat belts. Gm: service bulletin explaining when the safety belts are supposed to lock. *rm updated 12/6/11.
• 10036464May 1, 2011Engine cooling. Buick/cadillac/chevrolet/gmc/hummer/pontiac/saab: oil consumption and/or exhaust smoke-possible pcv baffle or lifter concern. Upon inspection, obvious oil will be found in the intake manifold and/or pcv vacuum tube. *pe updated 3/21/11. *pe updated 5/9/11. *pe updated 5/25/11. *pe updated 06/16/2011. *kb updated a second time on 06/16/2011. *kb updated 6/27/11.
• 10036384Mar 1, 2011Engine cooling. Buick/chevrolet/pontiac: excessive oil consumption and/or blue exhaust smoke. Its more apparent when driving highway speed. Rare instances, a ses light and engine misfire may be encountered with a p0300 dtc. *pe updated on 06/16/2011.
• 10037941Jan 1, 2011Engine cooling. Gm: service engine soon light is on with a misfire and a possible tick noise.
• 10037933Jan 1, 2011Engine cooling. Gm: the service engine soon light is on, there is also a misfire or engine noise. There are multiple possible causes.
• 10037543Nov 1, 2010Engine cooling. Gm: there may be a squealing noise or vibration from the engine on start-up. A ring in the crankshaft may be slipping.
• 10036324Sep 1, 2010Engine cooling. Pontiac/saturn/buick/gmc/chevrolet/cadillac/hummer: vehicle start and stalls after theft deterrent module replacement. Model years 2006-2011. Does not apply to vehicles with keyless access system.
• 10036550Jun 1, 2010Electrical system. Buick/cadillac/chevrolet/gmc/hummer/pontiac/saturn: additional diagnostic information for u0140 or u0073. Vehicle may exhibits some symptom(s) as door locks cycle while driving; intermittent no start; service stabilitrak dic message; speedometer and tachometer freeze while driving.
• 10036507Jun 1, 2010Brakes. Chevrolet: repeat brake pulsation, steering wheel dither, and/or premature brake pad wear. This condition affects vehicles driven primarily in mountainous terrain. Police vehicle with rpo 9c1 or 9c3.
• 10034404Feb 1, 2010Air bags, Seat belts. Buick/cadillac/chevrolet/gmc: airbag light on, dtc b0071 and b0081 set (diagnose and replace right front seatbelt buckle, if necessary). Upon investigation, the technician may find dtc b0071 set in the passenger presence system (pps) and a dtc b0081 in the sensing and diagnostics module (sdm).
• 10020222Feb 1, 2010Exterior lighting. Right front turn signal inoperative. *tt diagnosing inoperative turn signals, trunk actuator, or btsi. Updated on 10/03/07. *nj updated 11/10/10.
• 10032431Sep 1, 2009Electrical system. Chevrolet: engine power is reduced message and check engine lamp on with dtc p0841. The concern may be intermittent. Other dtcs that may set are p0532, p0522, p0452, p0335, p0106, p0101 and p0068. Three areas where wire chaffing can occur have been identified and confirmed.
• 10026645Jul 1, 2008Fuel system, Other or unknown, Electrical system. Gmc: 15 amp fuel pump fuse open. Vehicle will crank but fails to start.
• 10025421Apr 1, 2008Transmission and drivetrain. Diagnostic information on mh1, mn8, mt1, m15 transmission slips, will not shift or may overheat, ses/mil may be illuminated, dtcs p0218, p0894 set. *pe updated 8/12/08.
• 10025065Mar 1, 2008Transmission and drivetrain. Informational on 4t65-e mn7, m15 and m76 front wheel drive automatic transmission valve body reconditioning, dtcs p0741, p0742, p0757, p842, harsh shifts or slips.
• 10024262Feb 1, 2008Air bags. Air bag readiness light on, dtc b1019 set in sensing and diagnostic module (sdm) (reprogram instrument panel cluster (ipc)).
• 10024224Feb 1, 2008Engine cooling. Service engine soon light illuminated and dtc p0011, p0016, p0300. Equipped with 3.5l lze, lz4 (vin codes k, n) & 3.9l lz9, lz8, lgd engine (vin codes 1, r, w).
• 10024204Feb 1, 2008Engine cooling. Short duration cold start lifter tick noise. Equipped with the 5.3 or 6.0 active fuel management engines.
• 10025561Jan 1, 2008Transmission and drivetrain. Information on 4t65-e mn7, m15 and m76 front wheel drive automatic transmission valve body reconditioning, dtcs p0741, p0742, p0757, p842, harsh shifts or slips. *pe update 6/11/10.
• 10021397Dec 13, 2007Electrical system. Cam sensor dtc's. *kb (equipped with 3.5l lz4, lze, or 3.9l lz8, lz9 engine) updated 12/13/07.
• 10020881Dec 13, 2007Air bags. Air bag indicator light is on. *kb updated on 12/13/07.
• 10022262Nov 1, 2007Tires. Tire pressure monitor system concerns. *kb 2008 passenger cars and trucks (including saturn). Updated 2/26/08.
• 10021844Oct 1, 2007Transmission and drivetrain. 4t65-e transmission slips, no drive/reverse, tcc shudder, noise with tcc applied. *kb updated 08-15-07. *kb (diagnosis & replace transmission, if necessary). Updated 2/19/08.
• 10022805Sep 28, 2007Engine cooling. Cylinder head gasket replacement.
• 10022769Sep 26, 2007Transmission and drivetrain. Transmission slips, will not shift, ses light may be illuminated.
• 10022924Aug 1, 2007Steering. Overview of steering system noises.
• 10022711Aug 1, 2007Steering. Ei07162 - steering clunk noise felt, heard from steering column. (replace I-shaft) *nj updated on 09/24/07 *nj updated 10/5/07.
• 10020808Jul 1, 2007Fuel system. Information on 3.5l, 3.9l, and 5.3l e85 fuel compatible vehicles, with alcohol content, switching between gasoline and e85 fuel. *kb updated on 09/19/07.
• 10021672Jun 15, 2007Engine cooling. Severe engine damage in one cylinder.
• 10022703Jun 1, 2007Air bags. New procedure for clearing passenger presence system (pps) and sensing and diagnostic module (sdm) dtcs b0071, b0074, b0081.
• 10022369Jun 1, 2007Fuel system. Service update for inventory and customer vehicles e85 virtual flex fuel sensor (vffs) update- reprogram ecm.
• 10020723Jun 1, 2007Air bags. Airbag light is on, dtc b0081 set. (clear dtc using specific procedure). *kb updated 08-15-07.
• 10021853May 1, 2007Other or unknown. Installation instructions for e85 flex fuel emblems and yellow colored fuel caps in support of the e85 ethanol marketing program.
• 10021849May 1, 2007Seats. Front driver or passenger power seat inoperative/binds when moving forward or rearward.
• 10021846May 1, 2007Interior lighting, Exterior lighting. Headlamps and/or interior lamps flicker.
• 10021001Feb 22, 2007Engine cooling. Harsh shift, no power and ses/mil light on with dtc p0742.
• 10020849Jan 24, 2007Interior lighting, Exterior lighting. Headlamp flicker and interior lamp flicker. *kb updated 03-01-07.
• 10020930Oct 11, 2006Other or unknown, Tires. Remote keyless entry or tire pressure monitor concerns.
• 10020580Oct 6, 2006Electrical system. Intermittent no crank starter clicks or vehicle starts to crank then stops cranking. Crank driveability dtc electrical engine ims intermittent internal ls4, lz4, lz8.
• 10020948Oct 1, 2006Engine cooling. Diagnostic information on battery draw no start - body control module, bcm power timer.

← All problems reported for the 2007 Chevrolet Monte Carlo