2015 Chevrolet Silverado 2500 Technical Service Bulletins

2,387 technical service bulletins (TSBs) are on record for the 2015 Chevrolet Silverado 2500. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10115070Jun 24, 2015Body and structure. This Preliminary Information communication provides information to the technician about vehicles that have left or right front floor carpet is wet. Technician will pull back carpet on right floor from kick panel and water test. If the leak is found to be coming from the seam at the right front kick panel it will be necessary to remove the right front fender to gain access to the vertical cowl seam that is leaking…
• 10115069Jun 24, 2015Equipment. This Preliminary Information communication provides information to the technician about vehicles that the radio will lose audio except warning chimes and become inoperative after using Siri. The use of SIRI is not supported by this radio configuration.
• 10113709Jun 24, 2015Transmission and drivetrain, Equipment. This preliminary informational bulletin provides diagnostic tips that may be helpful in correcting a customer concern of a Malfunction Indicator Lamp (MIL) illuminated. Technicians may find DTC P0741 Torque Converter Clutch Stuck Off set .
• 10113705Jun 23, 2015Electrical system. This informational bulletin provides information to dealership personnel regarding original equipment battery part numbers and AC Delco replacement battery approved warranty part numbers.
• 10115067Jun 22, 2015Electrical system. This Preliminary Information communication provides information to the technician about being unable to receive OnStar ?Over The Air? updates. Technician will need to press the OnStar button and verify they have an active account and that the call connects with data and location.
• 10115066Jun 22, 2015Body and structure, Equipment. This Preliminary Information communication provides information to the technician the steps to diagnose and repair vehicles with visible water leak or signs of water intrusion from the antenna base, red OnStar LED, unable to connect to OnStar, OnStar unable to locate the vehicle, OnStar has inaccurate global positioning system location, no global positioning system on the navigation radio display, and inaccurate…
• 10115065Jun 22, 2015Electrical system. This Preliminary Information communication provides information to the technician about the iPod that the first song will still be displayed when the next song in the list is playing. Engineering has deemed this to be a normal operating characteristic of the vehicle and no repair attempts should be made.
• 10115064Jun 22, 2015Electrical system. This Preliminary Information communication provides information to the technician to download the USB software from TIS2WEB using the vehicle identification number every time a programming event of the human machine interface module is needed. Damage could be caused to the module if USB programmed with the incorrect software.
• 10115063Jun 22, 2015Engine cooling. This Preliminary Information communication advises the technician that the 6.6L Diesel Engine Control Module Part number 12658036 General Motors Product Quality Center parts restriction has ended. Dealer can now order the part through the regular Customer Care and Aftersales parts process.
• 10115061Jun 19, 2015Engine cooling, Fuel system. This Preliminary Information communication provides information to the technician about vehicles that may have "Exhaust Fluid Low", "Exhaust Fluid Empty - Refill Now", "Exhaust Fluid Range: XXX" or "Service Exhaust Fluid - See Owners Now" on the Driver Information Center. If the technician is working on 2010 and 2011 model years campaign 11001 has now been released.
• 10113697Jun 19, 2015Equipment. This technical bulletin provides repair information to correct a customer concern of engine misfire/tick noise, Malfunction Indicator Lamp (MIL) On, and/or DTC P0300 set.
• 10113696Jun 19, 2015Equipment. This engineering information bulletin is requesting information from dealers on a customer concern that the Service 4WD message is displayed, and DTC C0392 is set.
• 10115059Jun 18, 2015Engine cooling. This Preliminary Information communication provides information to the technician about vehicles that have a Service Engine Soon Malfunction Indicator Lamp on. Technician may find a Diagnostic Trouble Code P0011. If the technician has followed all published Service Information diagnosis and has not come to a conclusion, technician should check the oil pressure at the oil pressure sender. Then the number two cam…
• 10115058Jun 17, 2015Body and structure, Other or unknown. This Preliminary Information communication provides information to the technician about vehicles that have left or right front floor carpet is wet. Technician will pull back carpet on right floor from kick panel and water test. If the leak is found to be coming from the seam at the right front kick panel it will be necessary to remove the right front fender to gain access to the vertical cowl seam that is leaking…
• 10115053Jun 17, 2015Tires, Suspension. This Preliminary Information communication provides information to the technician about vehicles that have had multiple repair attempts are being performed on customer?s vehicles that exhibit vibration conditions without utilizing the support of General Motors Technical Assistance Center. If valid vibration frequency or Road Force Variation data has been collected and a repair attempt does not correct the customer…
• 10113693Jun 17, 2015Exterior lighting. This technical bulletin provides repair information to correct a customer concern that the driver's outside wide load mirror turn signal is too bright.
• 10089971Jun 17, 2015Transmission and drivetrain. 15435a - service update (revised service procedure). This bulletin provides a service procedure to replace the torque converter on certain 2015 model year chevrolet silverado hd, gmc sierra hd and gmc sierra denali hd vehicles equipped with an allison 6-speed automatic transmission (rpo mw7). These vehicles may have been assembled with an incorrectly machined torque converter. Customers may experience noise, poor…
• 10115052Jun 16, 2015Seats, Electrical system. This Preliminary Information communication provides information to the technician only to provide additional tips when diagnosing a front heated seat concern and is not meant to be a diagnostic flow chart or replace Service Information. Always, perform and refer to Service Information for the latest diagnostic information and procedures. Trucks equipped with heated and cooled seats Regular Production Option Code…
• 10115045Jun 15, 2015Equipment. This Preliminary Information communication provides information to the technician about vehicles with a CD player is inoperative. Technician should cycle power to the CD play and retest. If the CD player starts working advise the customer that we apologize for this inconvenience and that General Motors is working on a permanent solution for this concern. If the CD player is still inoperative technician will need to…
• 10089970Jun 15, 2015Transmission and drivetrain. 15435 - service update. This bulletin provides a service procedure to replace the torque converter on certain 2015 model year chevrolet silverado hd, gmc sierra hd and gmc sierra denali hd vehicles equipped with an allison 6-speed automatic transmission (rpo mw7). These vehicles may have been assembled with an incorrectly machined torque converter. Customers may experience noise, poor performance and, if this…
• 10089965Jun 15, 2015Brakes. 15203a - service update (revised service procedure). This bulletin provides a service procedure to inspect and, if required, retighten the torque on the right-rear-brake-line-bracket bolt to the rear-axle on certain fort wayne assembly plant built 2014-2015 chevrolet silverado ld, 2015 chevrolet silverado hd, 2014-2015 gmc sierra ld, 2015 gmc sierra hd and 2015 gmc sierra denali ld vehicles.
• 10115041Jun 12, 2015Equipment. This Preliminary Information communication provides information to the technician about vehicles that radio is inoperative, loss of sound, or their display is blank. Technician will need to cycle power to the radio and retest. If the radio starts working advise the customer that we apologize for this inconvenience and that General Motors is working on a permanent solution for this concern.
• 10115039Jun 12, 2015Equipment. This Preliminary Information communication provides information to the technician about when listening to an iPod that the first song will still be displayed when the next song in the list is playing. If this concern is encountered, use the browse button on the radio display and navigate to the desired artist, album, song, or Genre. Once the desired selection is made, the correct information will be displayed on…
• 10115038Jun 12, 2015Equipment. This Preliminary Information communication provides information to the technician about the Media Oriented Systems Transport Bus Diagnostic Tool Kit (EL-51578) has been released to help diagnose any of the Media Oriented Systems Transport bus concerns. The kit contains header connectors that are installed to bypass Media Oriented Systems Transport bus modules. The bypass connector also contains a terminal for…
• 10115036Jun 12, 2015Equipment. This Preliminary Information communication provides information to the technician about vehicles that navigation system has inaccurate estimated time of arrival. This is a normal operating characteristic of the New Generation Infotainment system.
• 10115035Jun 11, 2015Electrical system, Equipment, Brakes. This Preliminary Information communication provides information to the technician about vehicles that have a Shudder, bounce, bucking from the rear of the truck while braking when towing a gooseneck or fifth wheel trailer. Technician will need to measure the actual truck and trailer weights, with the trailer loaded to the point that exhibits the condition.
• 10089964Jun 10, 2015Brakes. 15203 - service update. This bulletin provides a service procedure to inspect and, if required, retighten the torque on the right-rear-brake-line-bracket bolt to the rear-axle on certain fort wayne assembly plant built 2014-2015 chevrolet silverado ld, 2015 chevrolet silverado hd, 2014-2015 gmc sierra ld, 2015 gmc sierra hd and 2015 gmc sierra denali ld vehicles. These vehicles may have been assembled with an…
• 10115030Jun 9, 2015Equipment. This Preliminary Information communication provides information to the technician about vehicles with a CD player is inoperative. Technician should cycle power to the CD play and retest. If the CD player starts working advise the customer that we apologize for this inconvenience and that General Motors is working on a permanent solution for this concern. If the CD player is still inoperative technician will need to…
• 10115027Jun 9, 2015Equipment. This Preliminary Information communication advises the technician that the Human Machine Interface, Radio or Tuner, radio controls, Integrated Center Stack, display, and Media Disc Players are placed on restriction through the General Motors Technical Assistance Center. Dealer will need to contact General Motors Technical Assistance Center for further assistance.
• 10115026Jun 8, 2015Electrical system. This Preliminary Information communication provides information to the technician about vehicles that may have the OnStar wireless fidelity inoperative. Technician will need to contact General Motors Technical Assistance Center with a scan tool connect to the vehicle for further assistance.
• 10115024Jun 8, 2015Fuel system. This Preliminary Information communication provides information to the technician about vehicles that have a hard start or a no start. Technician may find Diagnostic Trouble Code DTCs P0087, P0088, P0191 or P128E. Technician will need to follow all Service Information diagnose for the Diagnostic Trouble Code. If the current Service Information diagnostic has led to Fuel Injection Pump replacement, Fuel Pressure…
• 10115021Jun 8, 2015Equipment. This Preliminary Information communication provides information to the technician about vehicles that may have a radio display that flickers at first start up. Engineering is currently evaluating this concern.
• 10115019Jun 8, 2015Back-over prevention (rear camera), Electrical system. This Preliminary Information communication provides information to the technician about vehicles that may have an "Object Detection Unavailable" message on the radio display when shifting into reverse. Technician should reprogram the radio using Service Programming System with the latest software.
• 10113678Jun 5, 2015Transmission and drivetrain. This engineering information bulletin announces the end of need for information from the field regarding a fluid leak from front end of Allison transmission.
• 10113677Jun 5, 2015Transmission and drivetrain. This preliminary informational bulletin provides diagnosis and repair information to correct a customer concern of alleged no park, vehicle rolls in park or park will not hold.
• 10115015Jun 3, 2015Transmission and drivetrain. This Preliminary Information communication provides information to the technician about vehicles that have a Malfunction Indicator Lamp. Technician may find Diagnostic Trouble Code P16F3 as a current or history code in the Transmission Control Module. Technician will need to insure that the Diagnostic Trouble Code P16F3 is set in the Transmission Control Module.
• 10115014Jun 3, 2015Equipment. This Preliminary Information communication provides information to the technician about vehicles that have a Diagnostic Trouble Code B101D stored in Telematics Communication Interface Control Module. Technician will use Global Diagnostic System 2 to review the Firmware Over-the-Air version. If the Firmware Over-the-Air version on the scan tool equals 6708 the technician will need to contact General Motors Technical…
• 10115010Jun 2, 2015Equipment. This Preliminary Information communication provides information to the technician about vehicles that have an inoperative radio. Technician may find Diagnostic Trouble Code U0184 stored in multiple modules. If the concern is present at the dealership technician will need to contact General Motors Technical Assistance Center for further assistance.
• 10113669Jun 2, 2015Equipment. This informational bulletin provides information to dealership personnel on properly maintaining vehicles in dealer inventory.
• 10115009Jun 1, 2015Engine, Equipment. This Preliminary Information communication provides information to the technician how to diagnose and repair a vehicle with an engine that runs with an intermittent crank no start with a Diagnostic Trouble Code P0011 or P00C6 current or history. The Camshaft Position Actuator Solenoid Valve may be sticking or binding causing the valve timing to be retarded. Dealer will need to cycle the Camshaft Position Actuator…
• 10113667Jun 1, 2015Electrical system. This technical bulletin provides repair information for transmission control module reprogramming to correct a customer concern for MIL illuminated with firm shifts, shudder, engine RPM flare and DTCs P0606, P16F3 or P2818 set.
• 10059109Jun 1, 2015Brakes. Gmc/chevrolet: service procedures on certain vehicles to inspect, retighten the torque for right rear brake line bracket bolt to rear axle due to incorrectly being torqued allowing brake line to wear against rear axle housing and brake fluid leakage. Model 2014-15 silverado ld, sierra ld, 2015 silverado hd, sierra hd, sierra denali hd.
• 10114584May 29, 2015Electrical system. This Preliminary Information communication advises the technician to call General Motors Technical Assistance Center if the customer has a malfunction indicator lamp on and there is a diagnostic trouble code P16F3 set in the transmission control module.
• 10090006May 29, 2015Transmission and drivetrain, Equipment. 15216 - customer satisfaction program. Certain 2015 model year cadillac escalade and escalade esv; chevrolet silverado ld crew and double cab; and gmc sierra ld crew, sierra ld crew double cab, yukon, and yukon xl model vehicles that are equipped with a 6.2l engine (rpo l86) and 8-speed automatic transmission (rpo m5u) may have a condition in which the u-joint retainer bolts lose index. If this condition occurs…
• 10114576May 27, 2015Engine cooling. This Preliminary Information communication provides information to the technician about vehicles that the blower motor may be noisy or vibrate when running. This concern will only occur when the temperatures is below 32 degrees Fahrenheit and if the blower motor is removed while still cold, ice may be found on the blower motor cage. This concern could be caused by water leaking or snow ingestion into the…
• 10113661May 27, 2015Engine cooling. This preliminary informational bulletin provides repair information to correct a customer concern of warm air exhausting from driver and/or passenger front seat back into 2nd row seating area causing occupant discomfort.
• 10113660May 26, 2015Transmission and drivetrain. This preliminary informational bulletin provides diagnosis and repair information to correct a customer concern of alleged no park, vehicle rolls in park or park will not hold.
• 10114569May 22, 2015Equipment. This Preliminary Information communication provides information to the technician for a Service Engine Soon light with a Diagnostic Trouble code P0300 set. There may be a rough running engine associated with this concern. If service information diagnostics have been completed and there is still no trouble found, the technician is to inspect for a possible terminal tension concern on the ignition coil power feed for…
• 10114567May 21, 2015Electrical system. This Preliminary Information communication provides information to the technician on how the radio display gets the air ambient temperature. On 1500 series trucks and all sport utility vehicle with regular production option code IO3 radio the ambient air temperature sensor is hard wired to the engine control module and then the signal goes on high speed local area network to the body control module from there on…
• 10113656May 21, 2015Electrical system. This informational bulletin communicates part restriction and ordering process information for OnStar®Vehicle Communication Interface Modules (VCIM) (GMNA Only).

← All problems reported for the 2015 Chevrolet Silverado 2500