2018 Chrysler Pacifica Plug-In Hybrid Recalls
NHTSA lists 6 recall campaigns for the 2018 Chrysler Pacifica Plug-In Hybrid. A recall applies only to vehicles built within the affected range, so check your own VIN at nhtsa.gov/recalls. Repairs for recalls are free at a franchised dealer.
- Hybrid propulsion systemCovers: Chrysler Pacifica Plug-In Hybrid 2017–2018
Reported issue: Chrysler (FCA US, LLC) is recalling certain 2017-2018 Pacifica Plug-In Hybrid Electric (PHEV) vehicles that received a software update remedy under NHTSA recall number 22V-077. The battery pack may cause a vehicle fire when parked, even with the ignition in the "Off" position.
Possible consequence: A vehicle fire increases the risk of injury.
Remedy: Owners are advised not to charge their vehicles, and to park outside and away from structures, until they are repaired. Dealers will update the high voltage battery pack control module (BPCM) software. In addition, dealers will inspect and if necessary, replace the battery pack assembly. Repairs will be performed…
- Hybrid propulsion systemCovers: Chrysler Pacifica Plug-In Hybrid 2017–2018
Reported issue: Chrysler (FCA US, LLC) is recalling certain 2017-2018 Pacifica Plug-In Hybrid Electric Vehicles (PHEV). A vehicle fire can occur when parked, even with the ignition in the "Off" position.
Possible consequence: A vehicle fire increases the risk of injury.
Remedy: Owners are advised not to recharge their vehicles, and to park outside and away from structures, until they are repaired. Dealers will update the high voltage battery pack control module (BPCM) software. In addition, dealers will inspect and if necessary, replace the battery pack assembly. Repairs will be performed…
- Electrical system › Wiring › Interior/under dashCovers: Chrysler Pacifica Plug-In Hybrid 2017–2020
Reported issue: Chrysler (FCA US LLC) is recalling certain 2017-2020 Pacifica Plug-in Hybrid Electric Vehicles ("PHEV"). The 12 volt isolator post located behind the driver's seat may develop high resistance.
Possible consequence: A high resistance electrical connection may result in the connection overheating, increasing the risk of a fire with the vehicle on or off.
Remedy: FCA will conduct a voluntary safety recall on affected vehicles to increase the torque and install a waterproof gasket to the 12v isolator post, the post will also be inspected for signs of contamination. In the event the post is compromised, the 12v isolator post and associated cables will be replaced. Until the…
- Suspension › Front › Control arm › Lower armCovers: Chrysler Pacifica Plug-In Hybrid 2018, Pacifica 2018
Reported issue: Chrysler (FCA US LLC) is recalling certain 2018 Chrysler Pacifica and Pacifica hybrid vehicles. The right front lower control arm may separate from the steering knuckle.
Possible consequence: A control arm separation could increase the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will inspect the right front knuckle and lower control arm for damage, replacing the components as necessary. The right front lower control arm knuckle pinch bolt will be replaced with a larger-diameter pinch bolt. These repairs will be performed free of charge. The recall…
- Hybrid propulsion systemCovers: Chrysler Pacifica Plug-In Hybrid 2017–2018
Reported issue: Chrysler (FCA US LLC) is recalling certain 2017-2018 Chrysler Pacifica Plug-in Hybrid Electric vehicles (PHEV). After the vehicle has been operating in PHEV propulsion mode, the gas-fueled engine may not restart properly resulting in unburned fuel entering the exhaust catalyst.
Possible consequence: The improperly started engine could result in a loss of motive power increasing the risk of a crash or the unburned fuel in the catalyst may ignite increasing the risk of a fire.
Remedy: FCA will notify owners, and dealers will update the powertrain controller module software, and inspect and replace the catalytic converter as necessary, free of charge. The recall began November 15, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U94.
- Electrical system › Wiring › Front underhoodCovers: Chrysler Pacifica Plug-In Hybrid 2018, Pacifica 2017–2019, Jeep Wrangler 2017–2018 +14 more
Reported issue: Chrysler (FCA US LLC) is recalling certain 2018 Jeep Renegade, Compass and Grand Cherokee, RAM 1500 and Promaster, Fiat 500x, Dodge Journey, Challenger, Charger and Durango and Chrysler 300x vehicles, 2017-2018 Jeep Wrangler, Dodge Grand Caravan and Chrysler Town and Country vehicles and 2018-2019 Jeep Cherokee and 2018 Chrysler Pacifica and Pacifica Hybrid vehicles. The powertrain control module may be equipped…
Possible consequence: A vehicle stall can increase the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the powertrain control module, free of charge. The recall began October 2, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U87.
NHTSA investigations
- RQ24004Loss of motive power due to an internal wiring connector short.Open · Feb 27, 2024
← All problems reported for the 2018 Chrysler Pacifica Plug-In Hybrid
About this data. Data from NHTSA (ODI) complaints, recalls, TSBs and investigations, updated Oct 31, 2026. Complaints are unverified consumer reports and may be duplicated or inaccurate.