2003 Ford E-150 Recalls
NHTSA lists 5 recall campaigns for the 2003 Ford E-150. A recall applies only to vehicles built within the affected range, so check your own VIN at nhtsa.gov/recalls. Repairs for recalls are free at a franchised dealer.
- Vehicle speed controlCovers: Ford E-150 1992–2003, E-350 1992–2003, E-250 1992–2003 +12 more
Reported issue: Ford is recalling model years 1995-2003 windstar, 2000-2003 excursion diesel, 1993-1997 and 1999-2003 f-250 sd through f-550 sd diesel, 1992-2003 e-150 through e-550, 1995-2002 explorer, 1997 and 2002 mercury mountaineer, 1995-1997 and 2001-2003 ranger, and 1994 f53 vehicles equipped with the texas instruments speed control deactivation switch (scds). The scds may leak internally and then overheat, smoke, or burn.
Possible consequence: A vehicle fire could occur with or without the engine running.
Remedy: Ford will notify owners that dealers will install a fused wiring harness in line with the scds. On 1999-2003 windstar vehicles with a leaking scds, dealers will also inspect the abs control module connector and repair as necessary. Repairs will be completed free of charge. The safety recall began on october 27, 2009…
- Vehicle speed control › Cruise controlCovers: Ford E-150 1992–2003, Econoline 1992–2003, E-350 1992–2003 +10 more
Reported issue: Ford is recalling 225,000 my 1992-2003 econoline, my 1993-1995 taurus sho, my 1992-1998 crown victoria, my 1993 bronco, f-series, my 1995-1997 f-series super duty stripped chassis, my 1992-1998 mercury grand marquis, and my 1992-1995 lincoln town car vehicles. The affected vehicles were previously repaired using a wiring harness that is not compatible with the vehicle circuit polarity.
Possible consequence: As a result, the fuse is located in the output circuit rather than in the intended input power feed circuit, and may not offer the intended protection in the event of an electrical short to ground.
Remedy: Dealers will install a new wiring harness, or replace the mating electrical component. The recall began on february 18, 2008. Owners may contact ford at 1-800-392-3673.
- Vehicle speed controlCovers: Ford E-150 1992–1993, 1997–2003, E-350 1992–1993, 1997–2003, E-250 1992–1993, 1997–2003 +18 more
Reported issue: On certain pickup trucks, passenger vehicles, sport utility vehicles, and motor homes chassis, the speed control deactivation switch may, under certain conditions, leak internally and then overheat, smoke, or burn.
Possible consequence: This could result in an underhood fire.
Remedy: Dealers will install a fused wiring harness. Owners of the passenger cars included in this campaign will be instructed to return their vehicles to their dealers to have the speed control deactivation switch disconnected as an interim repair. As soon as repair parts are available (expected october 2007), owners will…
- Electrical system › WiringCovers: Ford E-150 2003–2004, E550 2003–2004, E-350 2003–2004 +2 more
Reported issue: On certain vans, a diode in the anti-lock braking system (abs) module may experience an electrical short.
Possible consequence: The electrical short may cause an abs malfunction that would illuminate the abs warning light, or the module may overheat resulting in a burning odor, smoke, and/or fire. This condition may occur while the vehicle is being driven or unattended.
Remedy: Dealers will install a new fuse in the abs circuit and install a heat shield over the abs module. The recall began on october 15, 2004. Owners should contact ford at 1-800-392-3673. Also ford is extending the limited warranty (for a one time replacement) of the abs module for a total of 10 years or 150,000 miles from…
- Engine and engine coolingCovers: Ford E-150 2003–2004, E550 2003–2004, E-350 2003–2004 +2 more
Reported issue: On certain vans, the air filter element material process resulted in an air filter paper element that can smolder or burn. This change in filter paper composition combined with the configuration of the air induction system, may allow hot carbon particles to contact the air filter element during certain driving conditions that create hot particles.
Possible consequence: These hot particles may ignite the air filter element with the potential for air induction system damage or underhood fire.
Remedy: Dealers will inspect and replace the air filter element. The recall began september 27, 2004. Owners should contact ford at 1-800-392-3673. Also ford is extending the limited warranty (for a one time replacement) of the abs module for a total of 10 years or 150,000 miles from the warranty start date, whichever occurs…
← All problems reported for the 2003 Ford E-150
About this data. Data from NHTSA (ODI) complaints, recalls, TSBs and investigations, updated Oct 30, 2026. Complaints are unverified consumer reports and may be duplicated or inaccurate.