2002 Ford E Series Problems
- Complaints
- 6filed with NHTSA
- Median mileage
- 9,793miles, 3 complaints with mileage
- Recalls
- 2campaigns on record
- Trend
- Not enough dataFewer than 15 complaints, too few for a reliable trend.
Sources: NHTSA records for the 2002 Ford E Series (complaints, recalls, investigations). Report an error
NHTSA recorded 6 consumer complaints for the 2002 Ford E Series. The part named most often is visibility, with 2 complaints (33% of the total), followed by electrical system (1) and engine cooling (1). 3 of the complaints include a mileage, and 67% of those were filed for vehicles with under 50,000 miles; the median is 9,793 miles. NHTSA lists 2 recall campaigns and 14 technical service bulletins for this model year.
This model year has fewer than 25 complaints on record, so the numbers below can change a lot with a few new reports.
Which parts are reported most
Complaints can name more than one part, so the counts add up to more than the total. Select a part to see its complaints, recalls and bulletins.
- Electrical system1 17%
- Engine cooling1 17%
- Suspension1 17%
Example complaints
Visibility (wipers, defrost, mirrors): “Defroster and climate control system malfunctioned repeatedly. No defroster, heat, or air conditioning because blower failed to operate. Dealer route 23 automall would not or could not fix.”
NHTSA complaint #10008168, filed 2003-02, 300 milesElectrical system: “The contact owns a 2002 Ford e-series. The contact stated that the bolts on the fuse box failed and caused the vehicle's wires to become exposed. The dealer has not inspected the vehicle. The engine size and correct VIN were unknown. The current and failure mileages were 9,793.”
NHTSA complaint #10191462, filed 2007-05, 9,793 milesEngine cooling: “Driving on primary road way when I heard a loud pop. Sounded like an exhaust leak. Pull off to side of road, turn off engine to check to see what the problem was.checked exhaust ok. Removed engine cowling, found spark plug ejected itself. Spark plug was missing, cop coil mounting broke, boot burnt. Had vehicle towed to Ford dealer after being told it would be covered under warranty. Dealer refused to repair under warranty. Talk to another dealership,an was told this a common problem in the triton engines. No repair has been made. I still have the cop coil.”
NHTSA complaint #10114848, filed 2005-03, 70,150 milesMileage when problems were reported
67% of the 3 complaints with a mileage were filed for vehicles with under 50,000 miles; the middle half falls between 300 and 70,150 miles.
Complaints by year filed
Fewer than 15 complaints, too few for a reliable trend.
Recalls and investigations
- 07V553000Dec 5, 2007Engine and engine cooling › Engine › DieselCovers: Ford E Series 1997–2003, F-450 SD 1997–2003, F-550 SD 1997–2003 +3 more
On certain heavy duty trucks equipped with 7.3l diesel engines, the camshaft position sensor located on the engine of the vehicle may function intermittently, possibly resulting in an engine stall.
- 03V094000Mar 7, 2003Body and structureCovers: Ford E Series 2000–2003, Explorer 2000–2003, Dodge Grand Caravan 2000–2003 +9 more
Certain pickup truck, van, and mini van conversions equipped with southern comfort built running boards that contain certain courtesy lights manufactured by american technology components, inc. These units contain a courtesy light or lights that might…
Recall details for the 2002 Ford E Series → · Check a VIN at nhtsa.gov/recalls
Technical service bulletins
TSBs are manufacturer notes to dealers about known repair procedures. They are not recalls and do not by themselves mean a vehicle has a fault. 14 on record; the latest 10 are shown.
- 10235153Apr 4, 2023Body and structure. For 2000-2024 Ford and Lincoln vehicles, swapping a module from a vehicle for diagnosis purposes is likely to cause errors and is not recommended. It is also not recommended to order a replacement…
- 10042864Nov 17, 2011Engine cooling. Ford: the blower motor on some vehicles are operating either incorrectly or not operating or just functioning on one speed.
- 10023943Oct 1, 2007Engine cooling. Some 1997-2008 vehicles equipped with a 4.6l 2v, 5.4l 2v, or 6.8l 2v engine--spark plug thread repair procedure--not covered under new vehicle limited warranty. *nj this includes f-53 motorhome…
- 10019075Jan 1, 2006Fuel system, Other or unknown. Fuel conditioner. Low power, poor fuel economy, fuel gelling in cold weather, excessive white smoke on cold start, hard start, or coking of components exposed to exhaust.
- 10018745Nov 14, 2005Engine cooling. Wds cop kit diagnostic tip - coil on plug (cop) ignition systems - engine misfire or rough running.
- 10014138Jun 7, 2005Seat belts. Safety belt retraction speed.
- 10014685Mar 21, 2005Engine cooling. Use of stainless steel exhaust studs in service for 5.4l 2v engine.
- 10014666Mar 7, 2005Engine cooling. Intermittent rough idle - non-commanded egr (exhaust gas recirculation valve) flow.
- 10014275Jan 1, 2005Transmission and drivetrain. A driveline clunk or bump when starting from a stop.
- 10013316Jan 1, 2005Transmission and drivetrain. A cold weather reverse engagement stall.
Other model years of the Ford E Series
| Year | Complaints | Median mi | Recalls | Crash ★ | MPG | Score (50 = typical) | Trend |
|---|---|---|---|---|---|---|---|
| 2008 | 5 | 19,000 | 0 | — | — | — | Not enough data |
| 2005 | 10 | 50,000 | 6 | — | — | — | Not enough data |
| 2003 | 5 | 73,500 | 2 | — | — | — | Not enough data |
| 2002 | 6 | 9,793 | 2 | — | — | — | Not enough data |
| 2001 | 6 | 65,000 | 2 | — | — | — | Not enough data |
| 2000 | 6 | 95,105 | 2 | — | — | — | Not enough data |
| 1998 | 13 | 18,500 | 1 | — | — | — | Not enough data |
| 1997 | 16 | 28,650 | 1 | — | — | — | Falling |
Frequently asked questions
How many NHTSA complaints does the 2002 Ford E Series have?
NHTSA recorded 6 consumer complaints for the 2002 Ford E Series as of Oct 28, 2026. Complaints are unverified consumer reports and may be duplicated or inaccurate.
What part of the 2002 Ford E Series is reported most often?
Visibility is named most often, in 2 complaints (33% of the total), followed by electrical system with 1.
Has the 2002 Ford E Series been recalled?
NHTSA lists 2 recall campaigns for this model year. To check a specific vehicle, enter its VIN at nhtsa.gov/recalls.
At what mileage are problems with the 2002 Ford E Series reported?
Among the 3 complaints that include a mileage, the median is 9,793 miles and the middle half falls between 300 and 70,150 miles; 67% were filed for vehicles with under 50,000 miles.
About this data. Data from NHTSA (ODI) complaints, recalls, TSBs and investigations, updated Oct 28, 2026. Complaints are unverified consumer reports and may be duplicated or inaccurate.
Complaint counts come from NHTSA’s public complaint database; we count each complaint once. The source records for this vehicle are on nhtsa.gov. Scores and trends are our own summaries of that data, described in the methodology. This page is not legal, safety or repair advice: for a specific vehicle, check its VIN at nhtsa.gov/recalls and ask a qualified mechanic. See an error? Tell us.