2024 Ford Expedition Technical Service Bulletins

109 technical service bulletins (TSBs) are on record for the 2024 Ford Expedition. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 11019494Jun 5, 2025Transmission and drivetrain. Some 2021-2025 Expedition/Navigator and 2021-2025 F-150 non-Lightning/non-PowerBoost vehicles may exhibit a rattle/scraping noise from the bellhousing area on start-up. This may be due to the torque converter studs contacting the engine to transmission spacer plate (separator plate). To correct this condition, inspect the engine to transmission spacer plate and torque converter studs for wear/damage. If wear/damage…
• 11018521May 13, 2025Transmission and drivetrain, Engine. Some 2020 Continental, 2020-2024 Edge/Nautilus, 2020-2025 Explorer/Aviator/Escape/Corsair/F-150/F-Super Duty/Ranger/Transit/E-Series, 2021-2025 Bronco, and 2022-2025 Maverick vehicles may require an engine cooling system flush to be performed for various concerns. Workshop Manual (WSM), Section 303-03 has been updated to eliminate the need to remove and install the radiator assembly to perform a radiator flush.
• 11018295May 12, 2025Forward collision avoidance, Lane departure. Some 2023-2024 Escape/Corsair vehicles equipped with driver assistance features with minor feature code DBCAB for Escape and minor feature code DBCBC for Corsair and 2022-2024 Expedition vehicles equipped with driver assistance features with minor feature codes DBCBB and DBCBC may exhibit driver assistance feature warning messages displayed in the IPC. Additionally, some modules may store invalid data/lost…
• 11017346Apr 24, 2025Other or unknown. Some 2018-2024 Expedition/Navigator vehicles equipped with 22 inch wheels, may exhibit an increased level of vibrations which can be felt while driving on a smooth road at speeds at or above 75 mph (120 km/h). Pinpoint Test G located in Workshop Manual (WSM), Section 204-04 has been developed to assist with diagnosis of this condition. When submitting a warranty claim, include all results from the Pinpoint Test.
• 11016915Apr 4, 2025Other or unknown. Some 2021-2025 Ford and Lincoln vehicles may exhibit diagnostic trouble code (DTCs) U2100 and/or U3002 stored in the cruise control module (CCM), side obstacle detection control module LH (SODL), side obstacle detection control module RH (SODR), side obstacle detection control module C (SODCMC) and/or side obstacle detection control module D (SODCMD) after a module replacement.
• 11016090Mar 26, 2025Other or unknown. Some 2022-2024 Expedition Timberline vehicles may exhibit a condition where the trail turn assist feature is disabled after a few seconds of activation.
• 11016079Mar 19, 2025Other or unknown. This article supersedes TSB 25-2055 to update the labor time description.
• 11016076Mar 19, 2025Other or unknown. This article supersedes TSB 24-2251 to update the labor times associated with the Service Procedure from M-time to AP-time.
• 11016354Mar 14, 2025Other or unknown. Special Field Action 24L07 Certain 2024 Model Year Expedition Platinum Vehicles Multi-Contour Seat Delete Credit Reimbursement
• 11015517Mar 5, 2025Other or unknown. Some 2022-2024 Expedition/Navigator vehicles may exhibit the liftgate spoiler contacting the roof during freezing temperatures when ice is present.
• 11014840Feb 27, 2025Other or unknown. This TSB supersedes 24-2261. Reason for update: update the procedure, parts list and labor operation. Some of the vehicles listed in the Model statement above may exhibit at least one of the following conditions: * Lower than actual fuel level indication on the fuel gauge * Inaccurate DTE displayed in the IPC after adding fuel to the vehicle This may be due to the IPC software and can occur if the vehicle is shut…
• 11014883Feb 26, 2025Other or unknown. Some 2023-2025 Ford vehicles were not produced with a factory wired keyless entry keypad.
• 11015356Feb 25, 2025Other or unknown. Some 2023-2024 Escape/Corsair vehicles equipped with driver assistance features with minor feature code DBCAB for Escape and minor feature code DBCBC for Corsair and 2022-2024 Expedition vehicles equipped with driver assistance features with minor feature codes DBCBB and DBCBC may exhibit driver assistance feature warning messages displayed in the IPC.
• 11014836Feb 25, 2025Other or unknown. Some of the vehicles listed in the Model statement above may exhibit at least one of the following conditions: * General system performance/stability/intermittent system reboot * Intermittent wireless CarPlay or Android Auto function * Phone related concerns with intermittent no audio or static * Navigation/global positioning system (GPS) related concerns through CarPlay and Android Auto * Alexa function…
• 11014932Feb 21, 2025Other or unknown. Certain 2024 Model Year F-150, Mustang, Expedition, Navigator, Transit, Super Duty, and 2025 Model Year Explorer vehicles, equipped a 10R80/10R100 Transmission. Transmission Assembly Replacement
• 11013845Jan 24, 2025Other or unknown. "Quality Improvements: - Customer should be able to enable and disable Intelligent power toggle button. -Adresses SYNC reboots and improves the vehicle's conectivity with the user's phone "
• 11013132Jan 17, 2025Other or unknown. Some 2017-2025 Ford and Lincoln vehicles equipped with a 10R60/10R80/10R80 MHT/10R100 transmission may exhibit a whine noise at idle and/or while driving.
• 11012136Dec 17, 2024Other or unknown. Some 2021-2023 F-150 non-Lightning, 2022-2024 F-150 Lightning/Expedition/Navigator, and 2024 Ranger vehicles may exhibit a "trailer brake module fault" message in the instrument panel cluster (IPC) with diagnostic trouble codes (DTCs) U0137 and/or U0252 stored in the body control module (BCM),
• 11010789Nov 14, 2024Other or unknown. " Some 2023-2024 Escape/Corsair vehicles equipped with driver assistance features with minor feature code DBCAB for Escape and minor feature code DBCBC for Corsair and 2022-2024 Expedition vehicles equipped with driver assistance features with minor feature codes DBCBB and DBCBC may exhibit driver assistance feature warning messages displayed in the IPC"
• 11011348Nov 13, 2024Other or unknown. "Quality improvements include: -Improve battery state of charge drainage issue due to Electronic Control Unit key off load events. -SYNC screen will display correct software update status. -Software update task will be automatically terminated after trigger expiration date"
• 11009438Oct 28, 2024Other or unknown. Some vehicles equipped with SYNC4 may exhibit one or more of the following symptoms after all currently available accessory protocol interface module (APIM) software updates have been performed.
• 11009830Oct 24, 2024Other or unknown. In some of the affected vehicles, it is possible the required software required for the Pro Trailer Backup Assist (PTBA) feature was not installed in the vehicle during assembly. A customer with a vehicle that did not receive the required software will be unable to complete the trailer calibration process required to use the PTBA feature. Trailer maneuvering using the steering wheel will be unaffected
• 11009442Oct 23, 2024Other or unknown. Some 2022-2024 Expedition/Navigator vehicles built on or before 09-Oct-2024 may experience a random BLIS indicator illuminated in the exterior mirror with no vehicle or objects near the vehicle.
• 11008948Oct 10, 2024Other or unknown. While performing a transmission repair on some 2012-2024 Ford and Lincoln vehicles, a transmission seal kit may be on backorder due to supply chain interruptions. While performing a transmission repair on some 2012-2024 Ford and Lincoln vehicles, a transmission seal kit may be on backorder due to supply chain interruptions.
• 11008709Oct 5, 2024Other or unknown. Some 2023-2024 Expedition vehicles equipped with driver assistance features with minor feature code DBCBB and DBCBC may exhibit various driver assistance feature warning messages displayed in the IPC.
• 11008706Oct 5, 2024Other or unknown. An intermittent black screen in the vehicle center display screen with a "Camera Is Unavailable. Please Contact Your Dealership." message in the instrument panel cluster (IPC) when the vehicle is in reverse and DTC B1578:89 stored in the image processing module A (IPMA) may be present on some of the following Ford and Lincoln vehicles: * 2024 F-150/F-Super Duty built on or before 08-Apr-2024 * 2024…
• 11008698Oct 4, 2024Other or unknown. Some 2021-2024 Ford and Lincoln vehicles may exhibit diagnostic trouble codes (DTCs) U2100 and/or U3002 stored in the cruise control module (CCM), side obstacle detection control module LH (SODL), side obstacle detection control module RH (SODR), side obstacle detection control module C (SODCMC) and/or side obstacle detection control module D (SODCMD) after a module replacement.
• 11007897Sep 2, 2024Other or unknown. Some 2024 Expedition/Navigator vehicles built on or before 19-Dec-2023 may exhibit lower than actual fuel level indication on the fuel gauge or inaccurate DTE displayed in the IPC after adding fuel to the vehicle. This may be due to the IPC software and can occur if the vehicle is shut off before placing the gear shift module (GSM) in park (p) and then partially filling the fuel tank.
• 11007142Aug 30, 2024Other or unknown. Quality Improvement include: - Addresses potential vehicle no start after OTA update. -SYNC Screen will show correct software update status.
• 11006769Aug 22, 2024Forward collision avoidance, Lane departure. This article supersedes TSB 24-2087 to update the vehicle lines, model years affected, action and service procedure. Some 2021-2024 Mustang Mach-E/F-150, 2022-2024 F-150 Lightning/Expedition/Navigator, 2023-2024 Corsair vehicles may exhibit an inoperative BlueCruise and lane centering with DTCs U2018:51 stored in the camera module - rear (CMR) and U0565:86 stored in the image processing module A (IPMA) without DTC…
• 11005754Jul 22, 2024Other or unknown. Some 2024 Expedition/Navigator vehicles built on or before 07-Mar-2024 may exhibit a concern where the vehicle is unable to complete the trailer calibration drive for the trailer backup assistance feature. The customer will see all instructional information in the center display screen for the trailer calibration including "Drive Straight Forward To Calibrate", "Drive Left Or Right To Calibrate" and "System…
• 11001385Jun 11, 2024Transmission and drivetrain. Some 2021-2024 F-150 and 2023-2024 Expedition/Navigator vehicles equipped with a 3.5L EcoBoost engine may exhibit a rattle/scraping noise from the bellhousing area on start-up. This may be due to the torque converter studs contacting the engine-to-transmission spacer plate (separator plate). To correct this condition, remove the transmission and flexplate and inspect the engine-to-transmission spacer plate and…
• 11001579Jun 6, 2024Electrical system. This article supersedes 24-2028 to update the vehicle symptom. Some 2022-2024 Expedition/Navigator vehicles may exhibit a random "Blind Spot Not Available Sensor Blocked" and/or "Cross Traffic Alert Not Available Sensor Blocked" warning messages in the IPC with no vehicle or objects near the vehicle. This condition may be intermittent, more noticeable in wet conditions.
• 11001112May 30, 2024Other or unknown. Some vehicles equipped with SYNC4 may exhibit one or more of the following symptoms after all currently available accessory protocol interface module (APIM) software updates have been performed. - General system performance, stability, and intermittent system reboots. - Intermittent Wireless CarPlay or Android Auto function. - Phone related concerns with intermittent No Audio or Static. - Navigation/global…
• 11000764May 28, 2024Other or unknown. Some 2022-2024 Expedition/Navigator vehicles may experience a random BLIS indicator illuminated in the exterior mirror with no vehicle or objects near the vehicle. This may be due to the radar signal echoing through the trailer hitch bar. To correct the condition, follow the Service Procedure to block the trailer hitch tube ends.
• 11000297May 18, 2024Transmission and drivetrain. Various vehicles equiped with 10R80/10R80 MHT/10R100/10R140 transmissions may require replacement of the seal kits (7153) when internal repairs are being performed. These kits come with 4 wheel drive (4WD) seals and will no longer include the 2WD seals. When working on a 2WD vehicle, any 2WD seals must be ordered separately. Refer to the parts catalog for the proper 2WD seals required.
• 11000296May 17, 2024Other or unknown. 2024 Expedition/Navigator vehicles built on or after 14-May-2024 may incorrectly list the keyless entry keypad code card on the loose item checklist. 2024 Expedition/Navigator vehicles built on or after 14-May-2024 do not include keyless entry keypad code cards. Customers are now able to retrieve the vehicle's keyless entry keypad master access code in vehicle by following the instructions in the Owners Manual >…
• 11001147May 16, 2024Other or unknown, Electrical system. Certain 2022-2024 Model Year Expedition and Navigator Vehicles - Rear Seat Entertainment Screen Software Update
• 10254142Apr 25, 2024Other or unknown. Some 2018-2019 Explorer and 2018-2024 Transit/F-150/Expedition/Navigator vehicles may exhibit an illuminated MIL with diagnostic trouble codes (DTCs) P0627, P025A, P025B, P00C6, P008A and/or U0109 stored in the powertrain control module (PCM). Diagnosis should include checking for an intermittent or partial disconnect of the harness to the fuel pump control module (FPCM) connector, connector pin push-outs, damaged…
• 10253686Apr 12, 2024Electronic stability control, Other or unknown. Some 2024 Expedition/Navigator vehicles built on or before 19-Dec-2023 may exhibit lower than actual fuel level indication on the fuel gauge or inaccurate DTE displayed in the IPC after adding fuel to the vehicle. This may be due to the IPC software and can occur if the vehicle is shut off before placing the gear shift module (GSM) in park (p) and then partially filling the fuel tank.
• 10253552Apr 3, 2024Other or unknown. Various vehicles have had pinpoint tests, guided routines and the Warranty and Policy Manual recentlyupdated for diagnostics and repairs on SYNC generation 3 and later applications. When performingdiagnostics and repairs on SYNC Gen 3 or later, select the diagnostics tab and search for related symptoms,DTCs and keywords. The search results will be shown in the search results pane.
• 10252702Mar 16, 2024Equipment. Quality Improvements include: - Fix the no audio out of random speakers issue.
• 10252525Mar 11, 2024Equipment. This article supersedes 23-2266 to update the vehicle model years affected to include 2024 model year. Some 2022-2024 Expedition/Navigator vehicles may exhibit a random BLIS warning with no vehicle or objects near the vehicle. This condition may be intermittent, more noticeable in wet conditions.
• 10251956Mar 8, 2024Electrical system. Some 2022-2024 various Ford/Lincoln vehicles equipped with SYNC 4 may experience concern where customers are receiving an error message when trying to enroll in connected services. This may be due to the gateway module (GWM) software. To correct the concern, download and run the Transport and Factory Mode Deactivation app: under HS1 modules select BCM > Transport and Factory Mode > Download > Run. When the pop-up…
• 10252694Mar 6, 2024Electrical system. Quality Improvements include: Various dashboard alerts display enhanced such as speed warning and temperature.
• 10251952Mar 6, 2024Engine cooling. For 2015-2024 Ford and Lincoln vehicles equipped with turbocharged engines and customer concern of an engine oil leak, refer to Workshop Manual (WSM), Section 303-00 for oil leak inspection and testing methods. Ford has evaluated turbochargers replaced for oil leak symptoms and although oil may collect on the external surface of a turbocharger, it is extremely rare for a turbocharger assembly to be the root cause…
• 10251937Mar 1, 2024Other or unknown, Electrical system. 2023 F-Super Duty, 2023-2024 Expedition, 2024 Nautilus/F-150 vehicles will exhibit no light emitting diode (LED) confirmation from the key fob indicating that the vehicle has remote started (or not remote started). Factory key fobs with remote start no longer contain a LED feedback indicator. Do not replace the key fob for this condition. This is a normal operating characteristic and no service action is necessary.
• 10251934Mar 1, 2024Transmission and drivetrain. During service and repair requiring removal and replacement of a crankshaft bolt and/or crankshaft damper, achieving proper torque of the crankshaft pulley bolt is critical. Incorrect torque may allow the bolt to loosen resulting in the timing gear breaking and engine damage. Replacement of the bolt is critical to the repair and accurately following the installation procedure in the Workshop Manual (WSM) Section…
• 10250847Feb 26, 2024Transmission and drivetrain, Engine cooling. Some 2021-2023 F-150 and 2023-2024 Expedition/Navigator vehicles equipped with a 3.5L EcoBoost engine may exhibit a rattle/scraping noise from the bellhousing area on start-up. This may be due to the torque converter studs contacting the engine-to-transmission spacer plate (separator plate). To correct this condition, remove the transmission and flexplate and inspect the engine-to-transmission spacer plate and…
• 10250526Feb 16, 2024Equipment, Body and structure. 2022-2024 Explorer/Aviator vehicles built on or after 28-May-2022, 2022-2024 Expedition/Navigator vehicles built on or after 08-Jun-2022, 2022-2024 Escape vehicles built on or after 01-Jun-2022 and 2022 Corsair vehicles built on or after 01-Jun-2022 are no longer equipped with a hands free liftgate system. The vehicle is not misbuilt. The addition of any parts is not a warrantable repair. Do not submit a claim for…

← All problems reported for the 2024 Ford Expedition