2017 Ford F-250 SD Technical Service Bulletins

328 technical service bulletins (TSBs) are on record for the 2017 Ford F-250 SD. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10191065Apr 7, 2021Wheels. Some 2017-2021 F-Super Duty vehicles equipped with dual rear wheels (DRW) and 17 inch aluminum wheels may require valve stem replacement for the front wheels. The parts catalog has been updated to use service part F2GZ-1700-D for the front wheels.
• 10189584Mar 25, 2021Steering. For 2017-2019 F-Super Duty vehicles equipped with adaptive steering and require steering wheel replacement, corrections for SASM and SECM module programming errors have been included in IDS level 121.03. Using IDS software level 121.03, start a NEW session and run the Programmable Module Installation (PMI) procedure. Follow the remaining procedures in Workshop Manual (WSM), Section 211-04 to complete the steering…
• 10189771Mar 2, 2021Equipment. Some 2017-2021 F-Super Duty vehicles equipped with a 6.7L diesel may exhibit an illuminated malfunction indicator lamp (MIL) with diagnostic trouble codes (DTCs) P2459, P246C and/or P2463 with a Drive to Clean maintenance message. Vehicles operated primarily in a stationary or off-highway low speed use may exhibit frequent exhaust regeneration attempts.
• 10187924Feb 26, 2021Steering. Some 2017-2021 F-Super Duty vehicles may intermittently exhibit excessive steering oscillation. A new instructional video has been published in the Workshop Manual (WSM) to provide specific measurement instructions on the appropriate tools and methods to determine which steering linkage joints are exceeding lash specifications and which are operating as designed. The left side tie rod end and sector shaft arm drag…
• 10187826Feb 1, 2021Electrical system, Engine cooling. Some 2017-2020 F-Super Duty vehicles equipped with a 6.7L engine built on or before 10-Jun-2020 may exhibit an illuminated malfunction indicator lamp (MIL) with diagnostic trouble codes (DTCs) U029D, U029E, P22A7 and/or P2209 in the powertrain control module (PCM). This may be due to water intrusion into the oxides of nitrogen (NOx) connectors. To correct the condition, follow the Service Procedure to inspect the…
• 10186678Jan 27, 2021Equipment. Some 2005-2021 F-Super Duty 4x4 vehicles operated in extreme dust, mud or tar sand conditions may exhibit accelerated 4x4 vacuum hub seal and or wheel bearing wear as a result of harsh operating conditions. A knuckle seal shield kit is now available for customer purchase. The kit is designed for severe duty and is non warrantable. The knuckle seal shield kit GC3Z-54024A38-A includes an installation instruction sheet
• 10186621Jan 21, 2021Transmission and drivetrain. Some 2017-2021 F-Super Duty and 2016-2021 F650-750 with 6.7L diesel engines, 2015-2019 Transit with 3.2L diesel engines and 2018-2021 F-150 with 3.0L diesel engines may exhibit an illuminated malfunction indicator lamp (MIL) with diagnostic trouble code (DTC) P206C in the powertrain control module (PCM). Review of repair data supports that P206C is often the result of incorrect diesel exhaust fluid (DEF)…
• 10186567Jan 6, 2021Engine cooling. 2011-2021 F-Super Duty and 2016-2021 F-650/F-750 vehicles equipped with a 6.7L engine may exhibit a high/elevated idle condition. During prolonged idle time, vehicles may experience this high/elevated idle to reduce buildup of unburned hydrocarbons from the SCR system. The powertrain control module (PCM) estimates hydrocarbon levels in the SCR and may increase idle speed to remove them.
• 10183395Nov 26, 2020Transmission and drivetrain. Some 2017-2019 F-Super Duty vehicles may experience an intermittent no crank condition. Diagnostic trouble code (DTC) P06E9 may also be set in the powertrain control module (PCM). This may be due to corrosion being present on the run start relay in the battery junction box (BJB). Inspect the run start relay for signs of corrosion, including along the terminal edges, prior to performing Workshop Manual (WSM)…
• 10180418Sep 24, 2020Electrical system. Some 2017-2020 F-Super Duty vehicles equipped with a 6.7L diesel engine may exhibit an illuminated malfunction indicator lamp (MIL) and diagnostic trouble code (DTC) P20EE. The Powertrain Controls and Emissions Diagnosis (PC/ED) pinpoint test RD15 has been updated to perform a Diesel Particulate Filter (DPF) Manual Regeneration twice along with performing the Specified Function SCR Parameter Reset with the…
• 10180339Sep 9, 2020Equipment, Electrical system. Some 2015-2020 F-150 except Raptor, 2017-2020 F-Super Duty, 2018-2020 Expedition vehicles equipped with a front camera washer may exhibit a washer fluid leak at the front camera washer jet when not in use. This may be due to the rubber seal internal to the jet. To correct the condition, follow the Service Procedure to replace the washer jet.
• 10179149Aug 19, 2020Engine cooling. Some 2015-2019 Transit vehicles equipped with a 3.2L engine, 2018-2020 F-150 vehicles equipped with a 3.0L engine, 2017-2020 Super Duty vehicles equipped with a 6.7L engine built on or after 13-May-2017 may exhibit an illuminated malfunction indicator lamp (MIL) with diagnostic trouble code (DTC) P2002 stored in the powertrain control module (PCM). This may be due to a crack in the diesel particulate filter (DPF)…
• 10179137Aug 18, 2020Engine cooling. Some 2017 F-Super Duty vehicles equipped with a 6.7L diesel engine built on or before 04-Aug-2017 may exhibit an illuminated malfunction indicator lamp (MIL) with diagnostic trouble code (DTC) P203B. This may be due to a low voltage condition during engine cranking. To correct this condition, reflash the diesel exhaust fluid (DEF) reductant level sensor/quality module using the Urea Sensor Reprogramming tool.
• 10179325Aug 11, 2020Engine cooling, Electrical system, Fuel system. Some 2011-2020 F-Super Duty, 2015-2019 Transit, 2016-2021 F-650/F-750 and 2018-2020 F-150 vehicles equipped with a 6.7L, 3.2L or 3.0L engine may exhibit an illuminated MIL with diagnostic trouble codes (DTCs) P207F, P20EE, P229F, P2201 and/or P24AE. This may be a result of using aftermarket cleaning liquids or tools for the exhaust gas recirculation (EGR) cooler or intake.
• 10179323Aug 11, 2020Transmission and drivetrain. Some 2017-2020 F-Super Duty vehicles equipped with a 6.7L diesel engine may exhibit an illuminated malfunction indicator lamp (MIL) and diagnostic trouble code (DTC) P20EE. The Powertrain Controls and Emissions Diagnosis (PC/ED) pinpoint test RD15 has been updated to perform a diesel particulate filter (DPF) manual regeneration with the appropriate Ford diagnostic scan tool twice along with performing a diesel…
• 10179320Aug 11, 2020Engine cooling. Some 2017-2020 F-Super-Duty vehicles equipped with a 6.7L diesel engine may exhibit hard start, lack of power or runs rough concern with malfunction indicator light (MIL) and diagnostic trouble codes (DTCs) P0087 and/or P008A. This may be due to low fuel level or fuel gelling in cold ambient temperatures. If no root cause is determined after normal PCED diagnostic test MA recommend that customer use a different…
• 10179117Aug 6, 2020Electrical system. Some 2016 MKS, 2016-2017 Navigator, 2016-2018 F150/Focus/CMAX/Edge/Fiesta/MKX/ Transit Connect/Mustang, 2017-2018 Continental/Fusion/MKZ, 2017-2019 Explorer, 2016-2019 Escape/MKC/Flex/MKT/Taurus/Transit/Expedition/F-Super Duty, and 2018-2019 EcoSport vehicles equipped with SYNC 3 may experience various SYNC performance related concerns. To correct the condition, follow the Service Procedure.
• 10177883Jul 30, 2020Equipment, Engine cooling. Some 2015-2019 F-Super Duty and 2016-2019 F-650/F-750 vehicles equipped with a 6.7L engine may exhibit an oil leak from the oil filter, crankcase vent oil separator, oil cooler, upper/lower oil pan. This may be due to a clogged crankcase vent oil separator and/or a sealing concern. Do not remove/replace the engine front cover for upper oil pan leaks. Do not check for warpage on the upper oil pan.
• 10177712Jul 21, 2020Brakes. Some 2017-2020 F-Super Duty vehicles may exhibit concerns related to brake drag. Utilize Workshop Manual (WSM) diagnostics in section 206-00 to verify the correct installation of the stoplamp switch. Improper adjustment of the stoplamp switch can cause the brake pedal assembly to lightly apply the brakes resulting in dragging condition.
• 10178009Jul 16, 2020Equipment. Some 2015-2019 F-150, 2017-2019 F-Super Duty vehicles may exhibit a lack of heat or cooling from the cabin vents when the climate settings are adjusted between hot and cold. This may be due to a stuck/binding temperature door within the climate control housing or binding/inoperative temperature door actuator. Diagnostic trouble code (DTC) B1081:07 may be present in the front controls interface module (FCIM).
• 10177868Jul 16, 2020Body and structure. Some 2015-2020 F-150, 2017-2020 F-Super Duty vehicles may exhibit one or more noisy doors when opening and closing. This may be due to dirt and debris on the door check arm(s). To correct this condition, follow the Service Procedure to clean and neutralize the affected door check arms.
• 10177863Jul 13, 2020Body and structure. This article supersedes TSB 19-2026 to update the vehicle model years affected. Some 2000 and newer Ford/Lincoln/Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended.
• 10177042Jun 17, 2020Electrical system, Equipment. Some 2016-2020 Ford and Lincoln vehicles equipped with a SYNC 3 Touchscreen may experience the volume control unresponsive from the Front Control Interface Module (FCIM) and steering volume controls when using Apple Car Play. When the Apple device is removed, volume control is restored. This is due to a concern with the Waze Navigation App software and Apple iOS version.
• 10176941Jun 5, 2020Steering, Equipment. Some 2017-2019 F-Super Duty vehicles equipped with a 6.7L diesel engine may exhibit an illuminated malfunction indicator lamp (MIL) with diagnostic trouble codes (DTCs) P2B11, P2B13, P2B15, P2B17, P2B19, P2B1B, P2B1D and/or P2B1F. If these codes have set with a customer complaint of abnormal steering wheel oscillation, clear these DTCs and address any steering related concerns. If these DTCs do not return, do not…
• 10176937Jun 4, 2020Equipment, Engine cooling. Some 2017-2019 F-Super Duty vehicles equipped with the 6.2L engine may exhibit an illuminated malfunction indicator lamp (MIL) with diagnostic trouble codes (DTCs) P2004 and/or P2005. This may be due to a tear or crack on the intake manifold vacuum hoses resulting in a vacuum leak. Before performing normal diagnostics, inspect the intake manifold vacuum hoses. If a tear or crack is identified, intake manifold…
• 10175895May 18, 2020Seats, Body and structure. Some 2013-2018 C-Max, 2013-2020 Escape/Fusion/MKZ, 2015-2018 Focus,2015-2019 MKC, 2015-2020 Edge/F150/Mustang, 2016-2018 MKX, 2016-2019 Explorer, 2017-2020 F-Super Duty, 2018-2020 EcoSport/Expedition, 2019-2020 Ranger/Nautilus vehicles may experience seat pan looseness, lateral movement, or a clunk/thump noise on turns. This may be due to the seat pan track. To correct the condition, follow the Service Procedure…
• 10174720Apr 30, 2020Equipment, Steering. In some of the affected vehicles, customers may experience sustained steering wheel oscillation after hitting rough pavement or an expansion joint at speeds typically above 45 mph (72 Km/h).
• 10174421Apr 22, 2020Electrical system. Some customers may experience a notification in the FordPass and/or LincolnWay apps that indicates their vehicle has entered "deep sleep mode". This mode is enabled due to the vehicle not being started for 14 consecutive days or battery voltage is at/or below 9.5 volts. Some 2020 models will also set a warning if the telematic control unit (TCU) has received an automatic over the air update. The purpose of deep…
• 10174401Apr 1, 2020Engine cooling, Fuel system. Some 2017-2019 F-Super Duty chassis cab vehicles equipped with a 6.7L engine and an aft of axle fuel tank operating in dusty conditions may exhibit a crank/no start concern with the fuel level showing over 1/4 tank full or the fuel gauge only registers up to 1/2 tank after filling with fuel. For vehicles equipped with an auxiliary fuel delivery source, the customer may also experience the inability to deliver fuel…
• 10172969Mar 19, 2020Engine cooling. Some 2015-2019 Transit vehicles equipped with a 3.2L engine, 2018-2020 F150 vehicles equipped with a 3.0L engine, 2017-2020 Super Duty vehicles equipped with a 6.7L engine built on or after 13-May-2017 may exhibit an illuminated malfunction indicator lamp (MIL) with diagnostic trouble code (DTC) P2002 stored in the powertrain control module (PCM). This may be due to a crack in the diesel particulate filter (DPF)…
• 10172927Mar 11, 2020Engine cooling. Some 2015-2019 Transit vehicles equipped with a 3.2L engine, 2018-2019 F150 vehicles equipped with a 3.0L engine, 2017-2019 Super Duty vehicles equipped with a 6.7L engine built on or after 13-May-2017 may exhibit an illuminated malfunction indicator lamp (MIL) with diagnostic trouble code (DTC) P2002 stored in the powertrain control module (PCM). This may be due to a crack in the diesel particulate filter (DPF)…
• 10172972Mar 9, 2020Other or unknown, Electrical system. SSM 48619 - Various Vehicles - Perimeter Alarm Armed And Original Vehicle Keys Cannot Be Accessed to Enter Vehicle - CAN Protection Strategy Some 2013-2016 Model Year Vehicles may exhibit a concern in which the Perimeter Alarm is active and the original keys cannot be accessed to disable the perimeter alarm. This concern would most often occur when a customer loses keys and the dealership is attempting to program…
• 10171969Feb 19, 2020Steering. Some 2017-2020 F-Super Duty vehicles may exhibit a characteristic or abnormal steering wheel oscillation concern. The workshop manual (WSM) has been updated to provide diagnostic direction for both symptoms, refer to Section 211-03 Steering Linkage > Diagnosis and Testing > Symptom Chart. This message is only to provide awareness of this WSM update and does not supersede other published diagnostic direction.
• 10171953Feb 11, 2020Engine cooling. SSM 48539 - 2017-2020 F-Super Duty/2018-2020 F-150 - 6.7L/3.0L - Diagnostic Trouble Code (DTC) P208E - Diesel Exhaust Fluid (DEF) Injector Testing Some 2017-2020 F-Super Duty/2018-2020 F-150 vehicles equipped with the 6.7L or 3.0L engines may exhibit an illuminated malfunction indicator lamp (MIL) with DTC P208E in the powertrain control module (PCM).
• 10171943Feb 11, 2020Electrical system. SSM 48537 - 2017-2019 F-Super Duty - 6.8L - Instrument Cluster Warning Indicators And/Or Radio Inoperative During Snow Plow Operation Some 2017-2019 F-Super Duty vehicles equipped with a 6.8L gas engine may exhibit multiple warning indicators in the instrument panel cluster and/or inoperative radio during snow plow use. Battery state of charge is important to verify prior to any repairs. 12.72v to 12.8v is a fully…
• 10170992Jan 29, 2020Suspension. Some 2005-2020 F-Super Duty 4x4 vehicles operated in extreme dust, mud or tar sand conditions may exhibit accelerated 4x4 vacuum hub seal and or wheel bearing wear as a result of harsh operating conditions. A knuckle seal shield kit is now available for customer purchase. The kit is designed for severe duty and is non warrantable. The knuckle seal shield kit GC3Z-54024A38-A includes an installation instruction sheet
• 10170985Jan 28, 2020Electrical system, Visibility (wipers, defrost, mirrors). Some 2015-2020 F-150 and 2017-2020 F-Super Duty vehicles equipped with a rear defroster may have factory installed or service replacement rear glass that uses rear defroster electrical terminals with a plastic overmolded cover. The rear glass defroster terminals are not serviceable and should not be removed or detached from the glass during diagnosis or repairs. If the rear glass defroster terminals are separated…
• 10170915Jan 17, 2020Electrical system, Transmission and drivetrain. Some 2017-2019 F-Super Duty vehicles equipped with a 6.7L engine built on 1-Oct-2017 and through 9-Jan-2019 may exhibit an intermittent low oil pressure warning indicator when the oil level is within correct operating range. This may be due to various strategies within the PCM software. To correct the condition, follow the Service Procedure to reprogram the PCM.
• 10169898Dec 20, 2019Seats, Electrical system. Some 2015-2019 F-150, 2015-2020 Explorer, 2017-2019 F-Super Duty, 2017-2020 Continental, 2018-2020 Expedition/Navigator, 2016-2018 MKX, 2019-2020 Nautilus, 2020 Aviator/Corsair and 2013-2020 MKZ vehicles equipped with multi-contour seats may exhibit intermittent multi-contour seat operation and/or massage and lumbar adjust inoperative from the seat switch or SYNC screen with or without diagnostic trouble code (DTC)…
• 10169880Dec 16, 2019Body and structure. Some 2015-2019 F-150, 2017-2019 F-Super Duty, 2018-2019 Expedition/Navigator vehicles may exhibit a rattle and/or squeak noise from the vista roof opening panel while driving with the roof opening panel closed. This may be due to dirt and/or debris build up between the vista roof opening panel seal and the body. To correct the condition, follow the Service Procedure steps to clean and lubricate the vista roof…
• 10168821Nov 21, 2019Body and structure, Latches, locks and linkages. Customer Satisfaction Program 18N03 - Supplement #7 Certain 2015-2018 Model Year F-150 and 2017-2018 Model Year F-250-F-550 Vehicles - Door Latch Freezing Concerns
• 10168810Nov 21, 2019Electrical system. Some 2016-2019 vehicles equipped with SYNC 3 may experience a map displayed on the left half of the SYNC screen with no other information/soft buttons present after updating to the latest version of V3.0 software. This issue occurs when the SYNC 3 system has been previously modified using an aftermarket device to display the Ford GT welcome screen/HMI Theme. To correct this issue, please contact the Technical…
• 10168760Nov 18, 2019Electrical system, Transmission and drivetrain. This message is superseding TSB 19-2271 to update the Issue, Action and Service Procedure. Some 2017-2018 F-Super Duty and 2019 F-Super Duty F-450/F-550 Chassis Cab only vehicles equipped with a 6.7L engine built on or before 9-Jan-2019 may exhibit an illuminated malfunction indicator lamp (MIL) with diagnostic trouble codes (DTCs) P2074, P0401, P0402 and/or P0170. This may be due to various strategies within the…
• 10168792Nov 7, 2019Electrical system. Some 2017-2019 F-Super Duty vehicles may exhibit a "Cruise Control Unavailable" or "Collision Avoidance Unavailable" message in the instrument cluster message center with diagnostic trouble code (DTC) U3000:49 in the cruise control module (CCM). Reprogram the CCM using the latest software level of the appropriate Ford diagnostic scan tool. For claiming use base part 9E731, refer to Section 10 in the Service Labor…
• 10168771Nov 1, 2019Transmission and drivetrain. Some 2017-2019 F-Super Duty 4x4 vehicles may exhibit an inoperative transfer case function with various diagnostic trouble codes (DTCs), including but not limited to P1839, P1867, P1861, P1891, P1841, U0102. If normal diagnosis leads to shift motor as the cause, first disconnect transfer case control module (TCCM) connector C2371A, and inline connectors C1010 (diesel) or C145 (gasoline) as well as transfer case…
• 10167191Oct 21, 2019Transmission and drivetrain, Engine cooling, Electrical system. Some 2017-2019 F-Super Duty vehicles built on or before 1-Aug-2018 equipped with a 6.7L engine may exhibit an illuminated malfunction indicator lamp (MIL) with diagnostic trouble codes (DTCs) P21DD, P204C, P21CD and/or U02A2 in the powertrain control module (PCM). This may be due to water intrusion within connectors C3613 and/or C4851 on the reductant harness going to the reductant pump/heater assembly and the…
• 10165709Sep 27, 2019Seats. Some 2015-2019 F-150/Explorer, 2017-2019 F-Super Duty/Continental, 2018-2019 Expedition/Navigator, 2016-2018 MKX, 2019 Nautilus, and 2013-2019 MKZ vehicles equipped with Multi-Contour seats may exhibit intermittent multi-contour seat operation and/or massage and lumbar adjust inoperative from the seat switch or SYNC screen with or without diagnostic trouble code (DTC) B1471, U024B, and/or U024C.
• 10165703Sep 11, 2019Suspension, Steering. This article supersedes TSB 18-2268 to update the Service Procedure and the Parts List. Some 2017-2019 F-250/F-350 4WD vehicles may exhibit a sustained steering wheel oscillation after hitting rough pavement or an expansion joint above 72 Km/h (45 mph). This may be due to excessive lag/lash of the steering linkage damper. To correct the condition, follow the Service Procedure steps to replace the steering linkage…
• 10165700Sep 6, 2019Engine cooling. Some 2017-2019 F-Super Duty vehicles equipped with a 6.7L engine built on or before 9-Jan-2019 may exhibit an illuminated malfunction indicator lamp (MIL) with diagnostic trouble codes (DTCs) P2074, P0401, P0402 and/or P0170. This may be due to various strategies within the powertrain control module (PCM) software. To resolve this condition, follow the Service Procedure steps to reprogram the PCM and perform a mass…
• 10164596Aug 14, 2019Equipment. Some 2013-2020 vehicles equipped with an EVDC air conditioning (A/C) compressor may exhibit poor A/C performance/improper climate function. To support the proper diagnosis of this compressor, the EVDC control valve tester has been provided to each U.S. dealership (339-EVDC100). Ensure the A/C system has a full charge prior to any compressor diagnostics.

← All problems reported for the 2017 Ford F-250 SD