2008 Ford F-450 SD Technical Service Bulletins

88 technical service bulletins (TSBs) are on record for the 2008 Ford F-450 SD. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10023435Oct 1, 2007Transmission and drivetrain. 2005-2008 f-super duty manual transmission- clutch pedal concern.
• 10023279Oct 1, 2007Engine cooling. 2008 f-super duty - 6.4l air induction snow restriction.
• 10022675Sep 19, 2007Brakes. Brake booster system may exhibit a brake pedal kickback and/or grabbing condition when applying the brakes.
• 10023166Sep 17, 2007Engine cooling. Diesel exhaust modification on 2008 ford super duty f-series for mpl series wreckers.
• 10023115Sep 4, 2007Other or unknown. Blizzard snowplows - on 2008 ford super duty trucks (snowplow headlamp switch operation w/snowplow headlamps connected (6-pin headlamp kit).
• 10023251Sep 1, 2007Electrical system. (wiring fault on trailer) displayed in message center with dtc c2806 - my 2008 f-super duty.
• 10022854Aug 22, 2007Other or unknown. Isolation module - installation location for all 2008 ford super duty trucks. Blizzard snowplows.
• 10022831Aug 22, 2007Engine cooling. Installation location for all 2008 ford super duty trucks (isolation module). Western products.
• 10022285Jul 25, 2007Engine cooling. Exhaust smoke from front of vehicle. Exhaust odor inside the vehicle.
• 10022283Jul 25, 2007Suspension. Rear of vehicle is too high/low -5th wheel and goose neck applications.
• 10023300Jul 1, 2007Electrical system. Some 2008 f-super duty - wiring fault on trailer displayed in message center with dtc c2806.
• 10023299Jul 1, 2007Transmission and drivetrain. Some 2008 f-super duty - gas engines/torqshift with water in the transmission.
• 10021904Jun 25, 2007Engine cooling. 6.4l-pcm update- built before 7/-30/2007- intermitten p0342 and/or p1326, update-pto function, turbo proctection, high idle, shift quality and ic. *kb updated 11/05/07.
• 10021900Jun 25, 2007Exterior lighting. Lighting on snow plow equipped vehicles.
• 10022715Jun 8, 2007Fuel system. In some of the affected vehicles, three fuel injectors were subjected to a reverse polarity voltage during engine testing that may have damaged the injector resulting in reduced fuel flow. This may potentially cause the vehicle to run rough, hesitate, or stumble on acceleration.
• 10022911Jun 1, 2007Fuel system. Distance to empty (dte) and fuel gauge service tip.
• 10022772Jun 1, 2007Electrical system. Wiring fault on trailer displayed in message center with dtc c2806.
• 10022767Jun 1, 2007Suspension. Dana s110 rear - axle fluid leak.
• 10022765Jun 1, 2007Fuel system. Uvc 15-way connections that are secured by an o-ring.
• 10022718Jun 1, 2007Fuel system. 2008 f-super duty - 6.4l diesel engine - the fuel cooling pump noise.
• 10022716Jun 1, 2007Brakes. 2008 f-super duty - soft or increased brake pedal travel - perform both master cylinder bypass test and pinpoint test f.
• 10022657Jun 1, 2007Fuel system. Injector circuit open- dtc(s) p0201-p0208 with a misfire/rough running/lack of power condition.
• 10022656Jun 1, 2007Engine cooling. Air induction snow restriction. Vehicle operated in heavy snow conditions may experience a lack of power during acceleration. This could cause the check air filter message on dash.
• 10022444May 10, 2007Other or unknown. Mpl series wrecker application. Jerr-dan.
• 10021977May 1, 2007Exterior lighting. Stop/turn lamp separation.
• 10021626May 1, 2007Other or unknown. Standard duty carrier applications.
• 10021625May 1, 2007Fuel system. After market fuel tanks.
• 10021624May 1, 2007Exterior lighting. Rapid flashing turn lights.
• 10022244Apr 1, 2007Electrical system. Wiring fault on trailer displayed in message center with dtc c2806.
• 10022243Apr 1, 2007Engine cooling. Lack of power due to low fuel pressure - fuel tank liner seperation.
• 10022240Apr 1, 2007Electrical system. Instrument panel lights dim - spdjb must learn resistance values of dimmer.
• 10022238Apr 1, 2007Electrical system. Wiring fault on trailer, displayed in message center with dtc c2806.
• 10022237Apr 1, 2007Visibility (wipers, defrost, mirrors). Power folding mirror.
• 10021622Feb 1, 2007Engine cooling. Ids unable to communicate with the pcm.
• 10021621Feb 1, 2007Fuel system. Lack of power due to low fuel pressure, fuel tank liner seperation.
• 10021620Feb 1, 2007Engine cooling. Injector circuit open codes p0201, p0202, p0203, p0204, p0205, p0206, p0207, p0208 with a misfire / rough running / lack of power condition.
• 10021619Feb 1, 2007Engine cooling. Air filter water ingestion / snow packing with codes p0103.
• 10021611Feb 1, 2007Engine cooling. Malfunction indicator lamp on with code p132b.

← All problems reported for the 2008 Ford F-450 SD