2015 Ford Transit Connect Engine Problems

“Under normal driving the vehicle got real hot ,and over heated. The water and oil levels where at the proper levels. The engine head cracked or blew the head gasket . Towed to Ford they had to replace the engine. This happened on the highway, going home. The next day the vehicle would not start. There is a safety recall # 17s09, out on these vehicles, but my VIN # was not on the list. Yet lm have the same issue. Luckily we caught it before it got hot enough to catch on fire.”

“The check engine light came on at about 81,000 miles, and a weird noise started happening coming from the engine area. I got into the dealer service department (dealer where I bought the car) at about 81,500 miles. They diagnosed a bad catalytic converter - it was breaking up. Several issues arose from that: first, I have been smelling carbon monoxide in the cab for quite a while and did not know why (now I think I know - clogged catalytic, reversion through the engine bay). Second the catalytic warranty expires at 80,000 miles. (the light went on at 81,000). …”

“99398 miles front drive axle replaced,99652 miles vehicle got stuck in the middle of parking lot lane preventing shifting out of park (shifter bushing replaced),99690 vehicle transmission replaced,101043 miles value cover oil leak,101500 truck idle surging.”

“The contact owns a 2015 Ford Transit Connect. The contact stated that while operating the vehicle the heater would only blow cold air and the defroster was inoperable causing a visibility hazard to the driver. The vehicle was taken to an independent mechanic who diagnosed that the eco boost engine sensor was faulty and needed to be replaced. The vehicle was not repaired. The local dealer(unknown) and the manufacture were notified of the failure but no assistance was offered. The failure mileage was 187,000.”

“The contact owns a 2015 Ford Transit Connect. While driving approximately 70 MPH, it began to rain and the air conditioning did not work. The sensor that read the temperature indicated minus 4 and all the windows fogged up. The contact pulled the vehicle over to the side of the road, rolled down all the windows, and waited until the rain stopped. The contact stated that the failure occurred at least twenty times. The dealer and manufacturer were not notified. The vehicle was not diagnosed or repaired. The approximate failure mileage was 50,000.”